Performance Characterization of Biorecycled Asphalt and Gray Correlation Analysis between Its Components and Macroproperties
Publication: Journal of Materials in Civil Engineering
Volume 34, Issue 3
Abstract
To explore the macroproperties of biorecycled asphalt and the correlation between its components and macroproperties, the cooking-aged waste soybean oil was used as the base oil, along with mixing additives, to prepare the biorejuvenator, and a total of six biorejuvenators with different component ratios were first developed. Then, using these rejuvenators, six biorecycled asphalts were prepared and their chemical components and viscosity and a series of pavement properties were measured and evaluated. Finally, using the gray correlation theory, gray correlation analysis between macroproperties and four components was conducted for recycled asphalts. Results show that the addition of biorejuvenator can adjust the component distribution in the aged asphalt, and the components in the aged asphalt can be gradually restored to the original level, thus achieving the regeneration of aged asphalt. Biorejuvenator can restore the penetration, softening point, ductility, and viscosity of aged asphalt to the same level as original asphalt. Further, the biorejuvenator with appropriate composition can restore the rheological parameters such as , , , , , and of aged asphalt to the level consistent with that of original asphalt. And it can significantly improve the low-temperature and fatigue properties of aged asphalt, while ensuring that the high-temperature performance of regenerated asphalt meets the specification requirements. Overall, the regeneration effects of R5 [base oil: dibutyl phthalate (DBP): antiaging agent: ] and R6 (base oil: DBP: antiaging agent: ) are optimal, which can guarantee that the pavement performance of recycled asphalt basically meets the requirements of original asphalt. The gray correlation analysis shows that the change of the four components of biorecycled asphalt will significantly affect its viscosity, high- and low-temperature performance, and fatigue behavior. The seven indexes of , softening point, penetration, , viscosity, , and demonstrate a higher gray correlation with the four components of asphalt (all exceed 0.6), followed by ductility, , and . However, correlates poorly with the four components of asphalt, whose gray correlation degree is not more than 0.4.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
Some or all data, models, or code that support the findings of this study are available from the corresponding author upon reasonable request.
Acknowledgments
This work was supported by the Key Laboratory of the Ministry of Education of China. The authors gratefully acknowledge it for providing relevant instruments.
References
AASHTO. 2010a. Standard method of test for estimating damage tolerance of asphalt binders using the linear amplitude sweep. AASHTO TP 101-14. Washington, DC: AASHTO.
AASHTO. 2010b. Standard specification for performance graded asphalt binder using multiple stress creep recovery (MSCR) test. AASHTO MP 19-10. Washington, DC: AASHTO.
Borghi, A., A. Jiménez del Barco Carrión, D. Lo Presti, and F. Giustozzi. 2017. “Effects of laboratory aging on properties of biorejuvenated asphalt binders.” J. Mater. Civ. Eng. 29 (10): 04017149. https://doi.org/10.1061/(ASCE)MT.1943-5533.0001995.
Chen, M., B. Leng, S. Wu, and Y. Sang. 2014. “Physical, chemical and rheological properties of waste edible vegetable oil rejuvenated asphalt binders.” Constr. Build. Mater. 66 (36): 286–298. https://doi.org/10.1016/j.conbuildmat.2014.05.033.
Chinese Standard. 2011. Standard test methods of bitumen and bituminous mixtures for highway engineering. JTG E20-2011. Beijing: People’s Communications Press.
Cui, L. Z., S. F. Liu, Z. P. Li, and J. Cui. 2010. “Study on grey slope similarity incidence and its applications.” Stat. Inf. Forum 25 (3): 56–59.
Du, Y., J. Chen, Z. Han, and W. Liu. 2018. “A review on solutions for improving rutting resistance of asphalt pavement and test methods.” Constr. Build. Mater. 168 (Apr): 893–905. https://doi.org/10.1016/j.conbuildmat.2018.02.151.
Elkashef, M., J. Podolsky, R. C. Williams, and E. Cochran. 2017. “Preliminary examination of soybean oil derived material as a potential rejuvenator through Superpave criteria and asphalt bitumen rheology.” Constr. Build. Mater. 149 (Sep): 826–836. https://doi.org/10.1016/j.conbuildmat.2017.05.195.
Elkashef, M., R. C. Williams, and E. W. Cochran. 2018. “Physical and chemical characterization of rejuvenated reclaimed asphalt pavement (RAP) binders using rheology testing and pyrolysis gas chromatography-mass spectrometry.” Mater. Struct. 51 (1): 1–9. https://doi.org/10.1617/s11527-018-1141-z.
Fang, Y., Z. Zhang, S. Wang, and N. Li. 2020. “High temperature rheological properties of high modulus asphalt cement (HMAC) and its definition criteria.” Constr. Build. Mater. 238 (Mar): 117657. https://doi.org/10.1016/j.conbuildmat.2019.117657.
Fen, Y., Z. Kong, J. Xiao-Yang, L. Qing-Qing, and Y. Jun. 2009. “Evaluation of shear performance of flexible waterproof-adhesive layer in concrete bridge pavement based on grey correlation analysis.” Supplement, Road Mater. Pavement Des. 10 (S1): 349–360. https://doi.org/10.1080/14680629.2009.9690251.
Girimath, S., and D. Singh. 2019. “Effects of bio-oil on performance characteristics of base and recycled asphalt pavement binders.” Constr. Build. Mater. 227 (Dec): 116684. https://doi.org/10.1016/j.conbuildmat.2019.116684.
Guo, M., Y. Tan, L. Wang, and Y. Hou. 2017. “Diffusion of asphaltene, resin, aromatic and saturate components of asphalt on mineral aggregates surface: Molecular dynamics simulation.” Supplement, Road Mater. Pavement Des. 18 (S3): 149–158. https://doi.org/10.1080/14680629.2017.1329870.
Guo, P., F. Xie, J. Meng, X. Meng, L. Wei, J. Xu, and Y. Feng. 2020. “Review on the interface blending behavior of virgin asphalt and aged asphalt during asphalt reclaiming.” Mater. Rev. 34 (13): 13100–13108. https://doi.org/10.11896/cldb.19070255.
Guo, Y. M., and F. J. Ni. 2013. “Analysis of nonlinear viscoelastic response of modified asphalt based on repeated creep.” J. Build. Mater. 16 (5): 908–912. https://doi.org/10.3969/j.issn.1007-9629.2013.05.030.
He, R., S. Chen, M. Hu, H. Chen, and Y. Sheng. 2015. “Shearing deformation performance of asphalt concrete function layer in cement concrete pavement.” J. Build. Mater. 18 (3): 415–420. https://doi.org/10.3969/j.issn.1007-9629.2015.03.010.
Hu, S. S., H. Wang, R. P. Qin, H. Tan, H. Li, Z. H. Xu, and Z. G. Zhou. 2018. “Correlation between asphalt four components and asphalt rubber zero shear viscosity under different loading modes.” Acta Materiae Compositae Sin. 35 (4): 999–1013. https://doi.org/10.13801/j.cnki.fhclxb.20170712.001.
Hugener, M., M. N. Partl, and M. Morant. 2014. “Cold asphalt recycling with 100% reclaimed asphalt pavement and vegetable oil-based rejuvenators.” Road Mater. Pavement Des. 15 (2): 239–258. https://doi.org/10.1080/14680629.2013.860910.
Ji, X. P. 2008. “Nonlinear simulation and regeneration of pavement asphalt aging.” Master thesis, School of Highway, Chang’an Univ.
Leng, B. B., M. Z. Chen, and S. P. Wu. 2014a. “Effect of waste edible vegetable oil on high temperature properties of different aged asphalts.” Key Eng. Mater. 599 (Feb): 135–140. https://doi.org/10.4028/www.scientific.net/KEM.599.135.
Leng, B. B., M. Z. Chen, and S. P. Wu. 2014b. “Research on physical properties of recycled asphalt with waste vegetable oil.” Highway 59 (2): 175–179.
Li, Y.-C., Y. Meng, L.-W. Zhou, and D.-L. Li. 2007. “Grey relation degree analysis of influence factors on asphalt mixtures voids.” China J. Highway Transport 20 (1): 30–34. https://doi.org/10.3321/j.issn:1001-7372.2007.01.006.
Nayak, P., and U. C. Sahoo. 2017. “A rheological study on aged binder rejuvenated with Pongamia oil and composite castor oil.” Int. J. Pavement Eng. 18 (7–8): 595–607. https://doi.org/10.1080/10298436.2015.1103851.
Oldham, J., H. Fini, and E. Chailleux. 2015. “Application of a bio-binder as a rejuvenator for wet processed asphalt shingles in pavement construction.” Constr. Build. Mater. 86 (Jul): 75–84. https://doi.org/10.1016/j.conbuildmat.2015.03.085.
Wang, Z. X. 2013. “Correlation analysis of sequences with interval grey numbers based on the kernel and greyness degree.” Kybernetes 42 (2): 309–317. https://doi.org/10.1108/03684921311310620.
Yang, X., J. Mills-Beale, and Z. You. 2017. “Chemical characterization and oxidative aging of bio-asphalt and its compatibility with petroleum asphalt.” J. Cleaner Prod. 142 (Jan): 1837–1847. https://doi.org/10.1016/j.jclepro.2016.11.100.
Yin, H., and K. Li. 2020. “Grey correlation analysis of zero shear viscosity and high temperature rheological parameters of asphalt.” J. Build. Mater. 23 (1): 108–113. https://doi.org/10.3969/j.issn.1007-9629.2020.01.016.
Zaumanis, M., R. B. Mallick, and R. Frank. 2015. “Evaluation of different recycling agents for restoring aged asphalt binder and performance of 100% recycled asphalt.” Mater. Struct. 48 (8): 2475–2488. https://doi.org/10.1617/s11527-014-0332-5.
Zhang, D., M. Chen, S. Wu, J. Liu, and S. Amirkhanian. 2017. “Analysis of the relationships between waste cooking oil qualities and rejuvenated asphalt properties.” Materials (Basel) 10 (5): 508. https://doi.org/10.3390/ma10050508.
Zhang, H., G. Xu, X. Chen, R. Wang, and K. Shen. 2019. “Effect of long-term laboratory aging on rheological properties and cracking resistance of polymer-modified asphalt binders at intermediate and low temperature range.” Constr. Build. Mater. 226 (Nov): 767–777. https://doi.org/10.1016/j.conbuildmat.2019.07.206.
Zhang, S., and J. Zhang. 2020. “Study on preparation of organic montmorillonite by freeze-drying method and its modified asphalt performance.” Mater. Rep. 34 (4): 4037–4042. https://doi.org/10.11896/cldb.19010060.
Zhang, Y. 2013. “Study on aging mechanism of asphalt and development of regeneration agent.” Master thesis, School of Civil Engineering, Chongqing Jiaotong Univ.
Information & Authors
Information
Published In
Copyright
© 2021 American Society of Civil Engineers.
History
Received: May 1, 2021
Accepted: Jul 28, 2021
Published online: Dec 29, 2021
Published in print: Mar 1, 2022
Discussion open until: May 29, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Ying Fang, Jianhua Yang, Zhengqi Zhang, Yanchao Wang, Development of Bioregenerant and Its Potential Application: Investigation for Regeneration of RAP Materials, Journal of Materials in Civil Engineering, 10.1061/JMCEE7.MTENG-17881, 36, 9, (2024).
- Ning Xu, Hainian Wang, Huimin Wang, Mohammadjavad Kazemi, Elham Fini, Research progress on resource utilization of waste cooking oil in asphalt materials: A state-of-the-art review, Journal of Cleaner Production, 10.1016/j.jclepro.2022.135427, 385, (135427), (2023).
- Ning Xu, Hainian Wang, Yu Chen, Nabil Hossiney, Ziye Ma, Huimin Wang, Insight into the effects of waste vegetable oil on self-healing behavior of bitumen binder, Construction and Building Materials, 10.1016/j.conbuildmat.2022.129888, 363, (129888), (2023).
- Zhao Yuechao, Chen Meizhu, Wu Shaopeng, Jiang Qi, Rheological properties and microscopic characteristics of rejuvenated asphalt using different components from waste cooking oil, Journal of Cleaner Production, 10.1016/j.jclepro.2022.133556, 370, (133556), (2022).
- Shiao Yan, Qiao Dong, Xueqin Chen, Changjun Zhou, Shi Dong, Xingyu Gu, Application of waste oil in asphalt rejuvenation and modification: A comprehensive review, Construction and Building Materials, 10.1016/j.conbuildmat.2022.127784, 340, (127784), (2022).