Experimental Performance Evaluation of Pipelines Rehabilitated with Cured-In-Place Pipe Liner under Earthquake Transient Ground Deformations
Publication: Journal of Infrastructure Systems
Volume 23, Issue 2
Abstract
The cured-in-place pipe (CIPP) liner technology involves installation of flexible polymeric composite liners coated with thermosetting resin to the inner surfaces of existing pipelines. This innovative technology provides an efficient, economic, and environmentally friendly method for rehabilitation of structurally compromised underground pipelines without expensive and disruptive excavation. However, the unverified and unquantified seismic performance of CIPP liner-reinforced pipelines under earthquake transient ground deformations (TGD) remains a barrier to the deployment of this technology in seismically active regions. Full-scale quasi-static and dynamic tests were performed on five water-pressurized ductile iron (DI) pipelines, with 150-mm (6.0-in.) nominal diameter and 9.14-m (30-ft) nominal length, reinforced with one type of CIPP liner commonly used in engineering practice. This paper evaluates experimentally the behavior of the liner-strengthened DI pipelines under static loading and also quantifies their seismic response under TGD-induced tensile axial loads. The test results indicate that CIPP liner provides substantial longitudinal tensile stiffness and strength to the joints of DI pipelines and improves significantly their seismic behavior under high-intensity TGD.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The work reported in this paper was supported by the George E. Brown, Jr., Network for Earthquake Engineering Simulation (NEES) Program of the National Science Foundation (NSF), Grant CMS-421142. Any opinions, findings, conclusions, or recommendations expressed in this paper are those of the authors and do not necessarily reflect the views of NSF. Sincere thanks are extended to Prof. Thomas D. O’Rourke, Prof. Harry E. Stewart, and Dr. Dimitra Bouziou from the School of Civil and Environmental Engineering at Cornell University for providing input motions and sharing important opinions in performing shake-table tests. The Los Angeles Department of Water and Power (LADWP) is also gratefully acknowledged for providing the pipeline specimens.
References
Abaqus 6.10 [Computer software]. Dassault-Systèmes, Waltham, MA.
Ariman, T. (1983). “Buckling and rupture failure in pipelines due to large ground deformations.” Proc., 14th Joint Panel Conf. of the US-Japan Cooperative Program in Natural Resources, National Bureau of Standards, Gaithersburg, MD.
ASTM. (2007). “Standard test method for in-plane shear properties of polymer matrix composite materials by the rail shear method.” ASTM D4255/D4255M-01, West Conshohocken, PA.
ASTM. (2008). “Standard test method for tensile properties of polymer matrix composite materials.” ASTM D3039/D3039M-08, West Conshohocken, PA.
Ayala, A. G., O’Rourke, M. J., and Escobar, J. A. (1990). “Evaluation of the effects of the 1985 Michoacán earthquake on the water systems in metropolitan Mexico City.” Earthquake Spectra, 6(3), 473–496.
Borden, F., et al. (1995). “Fire-related aspects.” Earthquake Spectra, 11(S2), 419–435.
Bouziou, D., et al. (2012). “Earthquake response and rehabilitation of critical lifelines.” Proc., 5th World Conf. on Earthquake Engineering, Sociedade Portuguesa de Engenharia Sismica (SPES), Lisbon, Portugal.
Bouziou, D. (2015). “Earthquake-induced ground deformation effects on buried pipelines.” Ph.D. thesis, Cornell Univ., Ithaca, NY.
Duke, C. M., and Moran, D. F. (1975). “Guidelines for evolution of lifeline earthquake engineering.” Proc., U.S. National Conf. on Earthquake, Earthquake Engineering Research Institute (EERI), Oakland, CA, 367–376.
Eidinger, J., de Castro, L., and Ma, D. (2006). “The 1906 earthquake impacts on the San Francisco and Santa Clara water systems—What we learned, and what we are doing about it.” Earthquake Spectra, 22(S2), 113–134.
EQE International. (1995). “The January 17, 1995 Kobe earthquake: An EQE summary report.” Warrington, U.K.
Jeon, S.-S., and O’Rourke, T. D. (2005). “Northridge earthquake effects on pipelines and residential buildings.” Bull. Seismol. Soc. Am., 95(1), 294–318.
Jeon, S.-S., O’Rourke, T. D., and Netravali, A. N. (2004). “Repetitive loading effects on cast iron pipelines with cast-in-place pipe lining systems.” J. Transp. Eng., 692–705.
Lund, L. V., et al. (1995). “Lifelines aspect of the 1994 Northridge earthquake.” Earthquake Spectra, 11(S2), 143–244.
Newmark, N. M. (1968). “Problems in wave propagation in soil and rock.” Proc. Int. Symp. on Wave Propagation and Dynamic Properties of Earth Materials, Univ. of New Mexico, Albuquerque, NM.
Nikon Metrology. (2014). “Krypton K600 optical measurement system.” 〈http://www.nikonmetrology.com/Products/Portable-Measuring/Optical-CMM/K-Series-Optical-CMM〉 (Aug. 2, 2014).
O’Rourke, T. D., Bonneau, A. L., Pease, J. W., Shi, P., and Wang, Y. (2006). “Liquefaction and ground failures in San Francisco.” Earthquake Spectra, 22(S2), 91–112.
O’Rourke, T. D., Roth, B. L., and Hamada, M. (1992). “Large ground deformations and their effects on lifeline facilities; 1971 San Fernando earthquake.”, National Center for Earthquake Engineering Research, Buffalo, NY.
O’Rourke, T. D., Stewart, H. E., Blackburn, F. T., and Dickerman, T. S. (1990). “Geotechnical and lifeline aspects of the October 17, 1989 Loma Prieta earthquake in San Francisco.”, National Center for Earthquake Engineering Research, State Univ. of New York, Buffalo, NY.
RMS (Risk Management Solutions), and FAA (Failure Analysis Associates). (1995). “Japan: The Great Hanshin Earthquake on January 17, 1995.” 〈http://catalog.lib.buffalo.edu/vufind/Record/001650340〉 (Apr. 24, 2014).
Scawthorn, C., O’Rourke, T. D., and Blackburn, F. T. (2006). “The 1906 San Francisco earthquake and fire—Enduring lessons for fire protection and water supply.” Earthquake Spectra, 22(S2), 135–158.
Schiff, A. J., et al. (1990). “Lifelines aspect of the 1998 Loma Prieta earthquake.” Earthquake Spectra, 6(S1), 239–338.
St John, C. M., and Zahrah, T. F. (1987). “Aseismic design of underground structures.” Tunneling Underground Space Technol., 2(2), 165–197.
Wang, Y., and O’Rourke, T. D. (2008). “Seismic performance evaluation of water supply systems.”, Univ. at Buffalo, Buffalo, NY.
Zhong, Z., et al. (2014a). “Performance evaluation of water pipelines retrofitted with cured in place pipe lining technology under transient earthquake motions.” Proc., 10th National Conf. in Earthquake Engineering, Earthquake Engineering Research Institute, Anchorage, AK.
Zhong, Z., et al. (2014b). “Seismic testing of critical lifelines rehabilitated with cured in place pipeline lining technology.” J. Earthquake Eng., 18(6), 964–985.
Zhong, Z. (2015). “Earthquake response and rehabilitation of critical underground lifelines reinforced with cured in place pipe liner technologies under transient ground deformations.” Ph.D. dissertation, Univ. at Buffalo, Buffalo, NY.
Information & Authors
Information
Published In
Copyright
© 2016 American Society of Civil Engineers.
History
Received: Apr 23, 2015
Accepted: Jun 20, 2016
Published online: Sep 13, 2016
Discussion open until: Feb 13, 2017
Published in print: Jun 1, 2017
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.