Evaluation of Aluminum Hydroxide-Amended Zeolites in Fluoride Removal: Column Filtration and Regeneration
Publication: Journal of Environmental Engineering
Volume 143, Issue 4
Abstract
Pure aluminum (hydr)oxide (AlOOH) and AlOOH-amended sodalite exhibited good performance in column fluoride removal studies in terms of service time (time until breakthrough), energy required for operation, and cost. The long service times (2,000 and 1,370 bed volumes for pure AlOOH and AlOOH-amended sodalite, respectively) were due to the relatively large mass loading of AlOOH, as well as the formation of a very adsorptive amorphous AlOOH phase at a slightly acidic pH (5.3). There was significant aluminum release from the columns during the first 70 bed volumes, which was attributed to outflow of AlOOH particles. Subsequently, the effluent aluminum concentration stayed below until breakthrough, after which it increased, possibly due to fluoride-induced AlOOH dissolution and formation of aqueous aluminum–fluoride complexes. The pumping energy required to treat of water using AlOOH-amended sodalite in a community-scale filter (approximately ) is two orders of magnitude lower than the energy required to operate electrocoagulation and reverse osmosis, and is favorable for the practical use of AlOOH-amended sodalite. In the absence of a continuous power supply, hydrostatic energy could also be used to run a community-scale filter using an elevated water tank. The relatively low cost of these materials (e.g., $1.05 to produce sufficient AlOOH-amended sodalite to treat of water) makes them appealing for use in developing regions. The overall materials costs can be further decreased by regeneration with 0.01 M sodium hydroxide.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This research was funded by the National Science Foundation (NSF) (CBET-1066425), Oklahoma University Graduate Senate Research Grant, and Oklahoma University Graduate College Research Grant.
References
Adem, M., Sani, T., Chebude, Y., Fetter, G., Bosch, P., and Diaz, I. (2015). “Comparison of the defluoridation capacity of zeolites from Ethiopia and Mexico.” Bull. Chem. Soc. Ethiopia, 29(1), 53–62.
Alfredo, K. A. (2012). “Drinking water treatment by alum coagulation: Competition among fluoride, natural organic matter, and aluminum.” Ph.D. dissertation, Univ. of Texas at Austin, Austin, TX.
Ayoob, S., Gupta, A. K., and Bhat, V. T. (2008). “A conceptual overview on sustainable technologies for the defluoridation of drinking water.” Crit. Rev. Env. Sci. Technol., 38(6), 401–470.
Boegman, R. J., and Bates, L. A. (1984). “Neurotoxicity of aluminum.” Can. J. Physiol. Pharmacol., 62(8), 1010–1014.
Brunson, L. R., and Sabatini, D. A. (2014). “Practialuminum concentration considerations, column studies and natural organic material competition for fluoride removal with bone char and aluminum amended materials in the Main Ethiopian Rift Valley.” Sci. Total Environ., 488–489, 580–587.
Cerqueira, A. A., and da Costa Marques, M. R. (2012). “Electrolytic treatment of wastewater in the oil industry.” New technologies in the oil and gas industry, J. S. Gomes, ed., INTECH, Rijeka, Croatia.
Darcy, H. (1856). “Les fontaines publiques de la ville de Dijon: Exposition et application.” Victor Dalmont, Paris (in French).
Doshi, R., Braida, W., Christodoulatos, C., Wazne, M., and O’Connor, G. (2008). “Nano-aluminum: Transport through sand columns and environmental effects on plants and soil communities.” Environ. Res., 106(3), 296–303.
Du, J., Sabatini, D., and Butler, E. (2016). “Preparation, characterization, and regeneration of aluminum (hydr)oxide amended molecular sieves for fluoride removal from drinking water.” J. Environ. Eng., .
Du, J., Sabatini, D. A., and Butler, E. C. (2014). “Synthesis, characterization, and evaluation of simple aluminum-based adsorbents for fluoride removal from drinking water.” Chemosphere, 101(0), 21–27.
Du, X., Wang, Y., Su, X., and Li, J. (2009). “Influences of pH value on the microstructure and phase transformation of aluminum hydroxide.” Powder Technol., 192(1), 40–46.
Edmunds, W. M., and Smedley, P. (2013). “Fluoride in natural waters.” Essentials of medical geology, O. Selinus, ed., Springer, Dordrecht, Netherlands.
Ergun, S. (1952). “Fluid flow through packed columns.” Chem. Eng. Prog., 48(2), 89–94.
Evanko, C. R., and Dzombak, D. A. (1998). “Influence of structural features on sorption of NOM-analogue organic acids to goethite.” Environ. Sci. Technol., 32(19), 2846–2855.
Farooqi, A., Masuda, H., and Firdous, N. (2007). “Toxic fluoride and arsenic contaminated groundwater in the Lahore and Kasur districts, Punjab, Pakistan and possible contaminant sources.” Environ. Pollut., 145(3), 839–849.
Feenstra, L., Vasak, L., and Griffioen, J. (2007). Fluoride in groundwater: Overview and evaluation of removal methods, International Groundwater Resources Assessment Center, Utrecht, Netherlands.
Flaten, T. P. (2001). “Aluminium as a risk factor in Alzheimer’s disease, with emphasis on drinking water.” Brain Res. Bull., 55(2), 187–196.
Frant, M., and Ross, J. W. (1968). “Use of a total ionic strength adjustment buffer for electrode determination of fluoride in water supplies.” Anal. Chem., 40(7), 1169–1171.
Ghorai, S., and Pant, K. (2004). “Investigations on the column performance of fluoride adsorption by activated alumina in a fixed-bed.” Chem. Eng. J., 98(1–2), 165–173.
Ghosh, D., Medhi, C. R., and Purkait, M. K. (2008). “Treatment of fluoride containing drinking water by electrocoagulation using monopolar and bipolar electrode connections.” Chemosphere, 73(9), 1393–1400.
Gizaw, B. (1996). “The origin of high bicarbonate and fluoride concentrations in waters of the Main Ethiopian Rift Valley, East African Rift system.” J. Afr. Earth Sci., 22(4), 391–402.
Gomez, M. L., Blarasin, M. T., and Martínez, D. E. (2009). “Arsenic and fluoride in a loess aquifer in the central area of Argentina.” Environ. Geol., 57(1), 143–155.
Gómez-Hortigüela, L., Pérez-Pariente, J., García, R., Chebude, Y., and Díaz, I. (2013). “Natural zeolites from Ethiopia for elimination of fluoride from drinking water.” Sep. Purif, Technol., 120, 224–229.
Gong, W. X., Qu, J. H., Liu, R. P., and Lan, H. C. (2012). “Adsorption of fluoride onto different types of aluminas.” Chem. Eng. J., 189–190(0), 126–133.
Jagtap, S., Yenkie, M. K., Labhsetwar, N., and Rayalu, S. (2012). “Fluoride in drinking water and defluoridation of water.” Chem. Rev., 112(4), 2454–2466.
Krishnamachari, K. A. (1986). “Skeletal fluorosis in humans: A review of recent progress in the understanding of the disease.” Prog. Food Nutr. Sci., 10(3–4), 279–314.
Ku, Y., and Chiou, H. M. (2002). “The adsorption of fluoride ion from aqueous solution by activated alumina.” Water Air Soil Pollut., 133(1–4), 349–361.
Largent, E. J. (1961). Fluorosis: the health aspects of fluorine compounds, Ohio State University Press, Columbus, OH.
Liao, Y., Liang, J., and Zhou, L. (2011). “Adsorptive removal of As (III) by biogenic schwertmannite from simulated As-contaminated groundwater.” Chemosphere, 83(3), 295–301.
Liu, R., Gong, W., Lan, H., Gao, Y., Liu, H., and Qu, J. (2011). “Defluoridation by freshly prepared aluminum hydroxides.” Chem. Eng. J., 175, 144–149.
Ma, Y., Shi, F., Zheng, X., Ma, J., and Gao, C. (2011). “Removal of fluoride from aqueous solution using granular acid-treated bentonite (GHB): Batch and column studies.” J. Hazard. Mater., 185(2–3), 1073–1080.
Maji, S. K., Pal, A., Pal, T., and Adak, A. (2007). “Modeling and fixed bed column adsorption of As (III) on laterite soil.” Sep. Purif. Technol., 56(3), 284–290.
Maliyekkal, S. M., Sharma, A. K., and Philip, L. (2006). “Manganese-oxide-coated alumina: A promising sorbent for defluoridation of water.” Water Res., 40(19), 3497–3506.
Mandal, S., and Mayadevi, S. (2008). “Cellulose supported layered double hydroxides for the adsorption of fluoride from aqueous solution.” Chemosphere, 72(6), 995–998.
Nordin, J. P., Sullivan, D. J., Phillips, B. L., and Casey, W. H. (1999). “Mechanisms for fluoride-promoted dissolution of bayerite [] and boehmite : spectroscopy and aqueous surface chemistry.” Geochim. Cosmochim. Acta, 63(21), 3513–3524.
Okada, K., Nagashima, T., Kameshima, Y., Yasumori, A., and Tsukada, T. (2002). “Relationship between formation conditions, properties, and crystallite size of boehmite.” J. Colloid Interf. Sci. 253(2), 308–314.
Onyango, M. S., Kojima, Y., Aoyi, O., Bernardo, E. C., and Matsuda, H. (2004). “Adsorption equilibrium modeling and solution chemistry dependence of fluoride removal from water by trivalent-cation-exchanged zeolite F-9.” J. Colloid Interf. Sci., 279(2), 341–350.
Panias, D., and Krestou, A. (2007). “Effect of synthesis parameters on precipitation of nanocrystalline boehmite from aluminate solutions.” Powder Technol., 175(3), 163–173.
Parthasarathy, N., Buffle, J., and Haerdi, W. (1986). “Study of interaction of polymeric aluminium hydroxide with fluoride.” Can. J. Chem., 64(1), 24–29.
Rango, T., et al. (2012). “Groundwater quality and its health impact: An assessment of dental fluorosis in rural inhabitants of the main Ethiopian Rift.” Environ. Int., 43, 37–47.
Roberson, C. E., and Hem, J. D. (1969). “Solubility of aluminum in the presence of hydroxide, fluoride, and sulfate.” Water-Supply Paper 1827-AU.S. Geological Survey, ASCE, Reston, VA.
Samatya, S., Yüksel, Ü., Yüksel, M., and Kabay, N. (2007). “Removal of fluoride from water by metal ions (, and ) loaded natural zeolite.” Sep. Sci. Technol., 42(9), 2033–2047.
Shannon, M. A., Bohn, P. W., Elimelech, M., Georgiadis, J. G., Mariñas, B. J., and Mayes, A. M. (2008). “Science and technology for water purification in the coming decades.” Nature, 452(7185), 301–310.
Shimelis, B., Zewge, F., and Chandravanshi, B. S. (2006). “Removal of excess fluoride from water by aluminum hydroxide.” Bull. Chem. Soc. Ethiopia, 20(1), 17–34.
Soni, M. G., White, S. M., Flamm, W. G., and Burdock, G. A. (2001). “Safety evaluation of dietary aluminum.” Regul. Toxicol. Pharm., 33(1), 66–79.
Sreedevi, P. D., Ahmed, S., Madé, B., Ledoux, E., and Gandolfi, J. M. (2006). “Association of hydrogeological factors in temporal variations of fluoride concentration in a crystalline aquifer in India.” Environ. Geol., 50(1), 1–11.
Srivastava, S. K., and Ramanathan, A. L. (2008). “Geochemical assessment of groundwater quality in vicinity of Bhalswa landfill, Delhi, India, using graphical and multivariate statistical methods.” Environ. Geol., 53(7), 1509–1528.
Sujana, M. G., and Anand, S. (2010). “Iron and aluminium based mixed hydroxides: A novel sorbent for fluoride removal from aqueous solutions.” Appl. Surf. Sci., 256(23), 6956–6962.
Tomar, V., and Kumar, D. (2013). “A critical study on efficiency of different materials for fluoride removal from aqueous media.” Chem. Cent. J., 7(1), 51.
Tor, A., Danaoglu, N., Arslan, G., and Cengeloglu, Y. (2009). “Removal of fluoride from water by using granular red mud: Batch and column studies.” J. Hazard. Mater., 164(1), 271–278.
Tripathy, S. S., Bersillon, J. L., and Gopal, K. (2006). “Removal of fluoride from drinking water by adsorption onto alum-impregnated activated alumina.” Sep. Purif. Technol., 50(3), 310–317.
UNICEF (The United Nations Children’s Fund). (1999). “States of the art report on the extent of fluoride in drinking water and the resulting endemicity in India.” New Delhi, India.
UNICEF (The United Nations Children’s Fund). (2003). “Water, environment and sanitation-Common water and sanitation-related diseases.” ⟨http://www.unicef.org/wash/index_wes_related.html⟩ (Jan. 18, 2016).
USEPA (U.S. Environmental Protection Agency). (1994). “Methods for the determination of metals in environmental samples, supplement I.”, Cincinnati.
USEPA (U.S. Environmental Protection Agency). (2004). “Method 6020 A: Inductively coupled plasma-mass spectrometry.”, Washington, DC.
Violante, A., and Huang, P. M. (1984). “Nature and properties of pseudoboehmites formed in the presence of organic and inorganic ligands.” Soil Sci. Am. J., 48(5), 1193.
Violante, A., and Huang, P. M. (1993). “Formation mechanism of aluminum hydroxide polymorphs.” Clay Clay Miner., 41(5), 590–597.
Visual Minteq 3.1 [Computer software]. Stockholm, Sweden.
Vyas, R. K., and Kumar, S. (2004). “Determination of micropore volume and surface area of zeolite molecular sieves by DR and DA equations: A comparative study.” Indian J. Chem. Technol., 11(5), 704–709.
Wang, S. G., Ma, Y., Shi, Y. J., and Gong, W. X. (2009a). “Defluoridation performance and mechanism of nano-scale aluminum oxide hydroxide in aqueous solution.” J. Chem. Technol. Biotechnol., 84(7), 1043–1050.
Wang, Y., Gao, B. Y., Xu, X. M., Xu, W. Y., and Xu, G. Y. (2009b). “Characterization of floc size, strength and structure in various aluminum coagulants treatment.” J. Colloid Interf. Sci., 332(2), 354–359.
WHO (World Health Organization). (2004). Guidelines for drinking-water quality: Recommendations, Vol. 1, Geneva.
Xu, Y. H., Ohki, A., and Maeda, S. (2000). “Removal of arsenate, phosphate, and fluoride ions by aluminium-loaded shirasu-zeolite.” Toxicol. Environ. Chem., 76(1–2), 111–124.
Zhao, Y., Li, X., Liu, L., and Chen, F. (2008). “Fluoride removal by Fe(III)-loaded ligand exchange cotton cellulose adsorbent from drinking water.” Carbohyd. Polym., 72(1), 144–150.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 143 • Issue 4 • April 2017
Copyright
©2016 American Society of Civil Engineers.
History
Received: Jun 8, 2016
Accepted: Sep 12, 2016
Published online: Dec 5, 2016
Published in print: Apr 1, 2017
Discussion open until: May 5, 2017
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.