Similitude in an Open-Channel UV Wastewater Disinfection Reactor
Publication: Journal of Environmental Engineering
Volume 141, Issue 3
Abstract
The possibility of using a small-scale model to predict the performance of a full-size open-channel ultraviolet (UV) wastewater disinfection reactor was numerically investigated using a computational fluid dynamics (CFD) model. The CFD model consists of the volume of fluid (VOF) method for capturing the water–air interface, realizable model for turbulence, discrete ordinate (DO) model for resolving the UV intensity field in the reactor, and Lagrangian particle tracking for calculating the microbial particle trajectory. To ensure the similarity of the hydrodynamics between the full-size and two scaled-down open-channel reactors, the Froude and Reynolds numbers were considered. Scaling methodology for the UV radiation field was formulated to ensure that the same disinfection performance can be achieved between the full-size and the scaled-down reactors. The disinfection characteristics of the full-size and scaled-down reactors predicted by the CFD model were comparable suggesting that the open-channel reactor is scalable and the behavior of a large-scale reactor can be predicted from the results of a small-scale reactor.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors wish to acknowledge the financial help of NSERC, Canada and Trojan Technologies for providing the reactor model and the experimental data.
References
ANSYS FLUENT Theory Guide. Release 13. (2010). ANSYS, Canonsburg, PA.
Aquafine. 〈http://www.aquafineuv.com/Products/UVComponents/UVLampsBallasts.aspx〉 (Sep. 05, 2014).
Blatchley, E., et al. (2006). “Dyed microspheres for quantification of UV dose distributions: Photochemical reactor characterization by Lagrangian actinometry.” J. Environ. Eng., 1390–1403.
Bohrerova, Z., Bohrer, G., Mohanraj, S., Ducoste, J., and Linden, K. (2005). “Experimental measurements of fluence distribution in a UV reactor.” Environ. Sci. Technol., 39(22), 8925–8930.
Cabaj, A., and Sommer, R. (2000). “Measurement of ultraviolet radiation with biological dosimeters.” Radiat. Prot. Dosim., 91(1–3), 139–142.
Chiu, K., Lyn, D., Savoye, P., and Blatchley, E. III (1999). “Integrated UV disinfection model based on particle tracking.” J. Environ. Eng., 7–16.
Ducoste, J., Liu, D., and Linden, K. (2005). “Alternative approaches to modeling fluence distribution and microbial inactivation in ultraviolet reactors: Lagrangian versus Eulerian.” J. Environ. Eng., 1393–1403.
Elyasi, S., and Taghipour, F. (2011). “Performance evaluation of UV reactor using optical diagnostic techniques.” AIChE J., 57(1), 208–217.
Gandhi, V. N., Roberts, P. J. W., and Kim, J. H. (2012). “Visualizing and quantifying dose distribution in a UV reactor using three-dimensional laser-induced fluorescence.” Environ. Sci. Technol., 46(24), 13220–13226.
Linden, K. G., and Darby, J. L. (1998). “Ultraviolet disinfection of marginal effluents: Determining ultraviolet absorbance and subsequent estimation of ultraviolet intensity.” Water Environ. Res., 70(2) 214–223.
Liu, D. (2004). “Numerical simulation of UV disinfection reactors: impact of fluence rate distribution and turbulence modeling.” Ph.D. thesis, Dept. of Civil, Construction, and Environmental Engineering, North Carolina State Univ., Raleigh, NC.
Lyn, D. (2004). “Steady and unsteady simulations of turbulent flow and transport in ultraviolet disinfection channels.” J. Hydraul. Eng., 762–770.
Lyn, D., and Blatchley, E. (2005). “Numerical computational fluid dynamics-based models of ultraviolet disinfection channels.” J. Environ. Eng., 838–849.
Lyn, D., Chiu, K., and Blatchley, E. III (1999). “Numerical modeling of flow and disinfection in UV disinfection channels.” J. Environ. Eng., 17–26.
MATLAB [Computer software]. Natick, MA, MathWorks.
Morsi, S. A., and Alexander, S. A. (1972). “An investigation of particle trajectories in two phase flow systems.” J. Fluid Mech., 55(2), 193–208.
Munoz, A., Craik, S., and Kresta, S. (2007). “Computational fluid dynamics for predicting performance of ultraviolet disinfection—Sensitivity to particle tracking inputs.” J. Environ. Eng. Sci., 6(3), 285–301.
Peng, B., Santoro, D., Sasges, M., Petri, B., and Olson, D. (2012). “Free surface effects and UV disinfection in open channel UV reactors.” Disinfection of Water, Wastewater, & Biosolids Conf., International Water Association, London.
Yang, Q., Ang, P. L., Ray, M. B., and Pehkonen, S. O. (2005). “Light distribution field in catalyst suspensions within an annular photoreactor.” Chem. Eng. Sci., 60(19), 5255–5268.
Younis, B. A., and Yang, T. H. (2010). “Computational modeling of ultraviolet disinfection.” Water Sci. Technol., 62(8), 1872–1878.
Younis, B. A., and Yang, T. H. (2011). “Prediction of the effects of vortex shedding on UV disinfection efficiency.” J. Water Supply Res. Technol.—AQUA, 60(3), 147–158.
Information & Authors
Information
Published In
Copyright
© 2014 American Society of Civil Engineers.
History
Received: Dec 13, 2013
Accepted: Aug 15, 2014
Published online: Sep 19, 2014
Discussion open until: Feb 19, 2015
Published in print: Mar 1, 2015
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.