Influence of Flooded Loessial Overburden on the Tunnel Lining: Case Study
Publication: Journal of Performance of Constructed Facilities
Volume 31, Issue 6
Abstract
Cracks observed in the secondary lining of loess highway tunnel may be caused by various sources, among which flooded surrounding loess is a possible one. This paper studies the influence of flooded surrounding loess on tunnel lining by carrying out in situ investigation, in situ permeability test, and numerical simulations. The statistical analysis of tunnel distress reveals that the length of vault cracks accounted for more than 70% of the total length of tunnel cracks, the cracks in two adjacent sidewalls between the uplink and the downlink were much longer than that of the other two, and the vault cracked more seriously than the sidewalls. Tunnel construction caused ground cracks that allow surface water to infiltrate through the cracks, which floods and deteriorates the surrounding loess, leading to cracking of the tunnel lining. An empirical equation for predicting water infiltration through in situ loess is proposed based on the in situ permeability test, which was used to determine the flooded cases in the numerical simulation. Numerical simulations based on finite-element method were performed to investigate the mechanical response of tunnel lining in different flooded cases. The simulation results show that the tensile stress in the vault and the compressive stress in the sidewalls increased significantly after the surrounding loess was flooded; the vault cracks were due to exerted tensile stress exceeding the capacity of tunnel lining, whereas the sidewall cracks were due to the high localized compression; and the vault cracks prior to the sidewall. The simulation results are generally in good agreement with the in situ observation. This case study may have value for optimal design and long-term operation of future tunnels constructed in similar geological environments.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study was supported by the National Natural Science Foundation of China (Grant Nos. 51008029 and 51378071), Natural Science Foundation of Shaanxi Province (Grant Nos. 2014KJXX-53 and 2014SZS19-Z01), and the Fundamental Research Funds for the Central Universities (Grant Nos. 2014G3213006 and 310821163302).
References
Ansell, A. (2010). “Investigation of shrinkage cracking in shotcrete on tunnel drains.” Tunnelling Underground Space Technol., 25(5), 607–613.
ANSYS version 12.0 [Computer software]. ANSYS, Pittsburgh.
Ban, H. K., Yang, L. D., and Huang, K. (2005). “Research on unsymmetrical load effect and lining cracks of a highway tunnel.” Chin. J. Rock Mech. Eng., 24(18), 3311–3315.
Campos, A., López, C., Blanco, A., and Aguado, A. (2016). “Structural diagnosis of a concrete dam with cracking and high nonrecoverable displacements.” J. Perform. Constr. Facil., 04016021.
Changiz, R., Edward, J. F. R., and Howard, F. T. (2011). “Unsaturated loessial soils: A sustainable solution for earthworks.” Proc. Inst. Civil Eng. Geotech. Eng., 164(4), 257–276.
Hoda, A., Soheil, N., and Deren, Y. (2015). “Validation of strengths and limitations of seismic methods in quality management and assessment of shotcrete liners.” J. Perform. Constr. Facil., 04014048.
Huang, X. F., et al. (2012). “Study of infiltration and collapsible deformation law if unsaturated loess under over burden pressure by using TDR soil water probe.” Chin. J. Rock Mech. Eng., 31(S1), 3231–3238.
Inokuma, A., and Inano, S. (1996). “Road tunnels in Japan: Deterioration and countermeasures.” Tunneling Underground Space Technol., 11(3), 305–309.
Li, Z. G., and Zhang, Y. J. (2004). “Stability analysis for tunnels with cracked linings and the techniques for repairing the cracked linings.” Modern Tunneling Technol., 41(1), 26–31.
Liu, B. J., You, X. L., Xie, Y. L., and Zhang, W. B. (2005). “Analysis of problems on loess hydrocompaction in highway engineering.” China J. Highway Transp., 18(4), 27–31.
Liu, Y. T. (2010). “Effect of rainfall infiltration on stability of loess slope.” M.S. thesis, Northwest A&F Univ., Xi’an, China, 89–91.
Mashimo, H., Isago, N., Kitani, T., and Endou, T. (2006). “Effect of fiber reinforced concrete on shrinkage crack of tunneling.” Tunneling Underground Space Technol., 21(3–4), 382–383.
McAdams, M., and Wang, J. (2013). “Gunnison tunnel: Engineering history of an early American reclamation project.” J. Perform. Constr. Facil., 826–835.
Pan, H. K., Yang, L. D., and Huang, K. (2005). “Research on unsymmetrical load effect and lining cracks of a highway tunnel.” Chin. J. Rock Mech. Eng., 24(18), 3311–3315.
Wang, G. L., and Luo, Y. S. (2011). Research and engineering of collapsed loess, China Architecture and Building Press, Beijing.
Wang, X. M. (2007). ANSYS numerical analysis of engineering structure, China Communications Press, Beijing.
Xiao, J. Z., Dai, F. C., and Wei, Y. Q. (2014). “Cracking mechanism of secondary lining for a shallow and asymmetrically-loaded tunnel in loose deposits.” Tunneling Underground Space Technol., 43(Jul), 232–240.
Xu, F., Li, S. C., Zhang, Q. Q., Li, L. P., Shi, S. S., and Zhang, Q. (2017). “A new type support structure introduction and its contrast study with traditional support structure used in tunnel construction.” Tunneling Underground Space Technol., 63(Mar), 171–182.
Ye, F., He, C., and Xia, Y. X. (2010). “Post-construction monitoring and analysis for highway tunnel lining cracks.” China Civil Eng. J., 43(7), 97–104.
Zhang, J. F. (2004). “Experimental study on infiltration characteristics and finger flow in layer soils of the loess area.” Ph.D. thesis, Northwest A&F Univ., Xi’an, China, 87–109.
Zhang, M. H., Xie, Y. L., and Liu, B. J. (2006). “Study on constitutive relation of loess moistening deformation based on secant-modulus method.” Chin. J. Rock Mech. Eng., 25(3), 609–617.
Zhao, C., Lavasan, A. A., Barciaga, T., Zarev, V., Datcheva, M., and Schanz, T. (2015). “Model validation and calibration via back analysis for mechanized tunnel simulations—The Western Scheldt tunnel case.” Comput. Geotech., 69(Sep), 601–614.
Zheng, J. J., and Zhao, K. (2011). “Influence on stability of loess subway tunnel in flooded surrounding rock.” J. China Railway Soc., 33(2), 91–95.
Zhong, Z. L., Wang, S., and Liu, X. R. (2015). “Yield criterion of intact structural loess based on integrated structural potential concept.” Rock Soil Mech., 36(11), 3041–3046.
Information & Authors
Information
Published In
Journal of Performance of Constructed Facilities
Volume 31 • Issue 6 • December 2017
Copyright
©2017 American Society of Civil Engineers.
History
Received: Jan 9, 2017
Accepted: May 30, 2017
Published online: Oct 5, 2017
Published in print: Dec 1, 2017
Discussion open until: Mar 5, 2018
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.