Impact of Freight Consolidation on Logistics System Performance
Publication: Journal of Transportation Engineering
Volume 114, Issue 2
Abstract
The effect of recent deregulation of the transportation industry has been to increase the relative costs of small shipments in low‐volume traffic lanes. Freight consolidation has been suggested as an effective way to reduce transportation costs and improve service levels for small shipments. Previous investigations of freight consolidation have been very general in nature and narrow in scope, even though the strategy has been suggested as useful for the design of a distribution system that deals primarily with small shipments. This paper focuses on an analysis of consolidation strategy and the impact of the number of consolidation points and special delivery requirements on various system performance elements. The special delivery requirement level is the portion of orders that must be shipped immediately without waiting for the specified holding period, thus resulting in a reduction of consolidated volume movements. The study indicates that consolidation can be used as a distribution strategy, with the prior knowledge that the level of special delivery requirement (priority shipment) can create a significant impact on system costs. The number of consolidation points, however, is not as critical to system performance as the level of special delivery requirement.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Blumenfeld, D. E., et al. (1985). “Analyzing trade‐offs between transportation, inventory and production costs on freight networks.” Transp. Res. B, 19B(5), 361–380.
2.
Bowersox, D. J. (1978). Logistical management, 2nd Ed., Macmillan Publishing Co., New York, N.Y.
3.
Bowersox, D. J. (1981). “Evaluating order consolidation strategies using simulation.” J. Business Logistics, 2(2), 110–138.
4.
Bowersox, D. J., et al. (1981). Introduction to transportation, Macmillan Publishing Co., New York, N.Y.
5.
Burns, D., et al. (1985). “Distribution strategies that minimize transportation and inventory costs.” Oper. Res., 33(3), 469–490.
6.
Cooper, M. C. (1982). “An investigation of freight consolidation and warehouse strategies in industrial distribution systems, thesis presented to Ohio State University, at Columbus, Ohio, in partial fulfillment of the requirements for the degree of Doctor of Philosophy.
7.
Daganzo, C. F., and Newell, G. F. (1985). “Physical distribution from a warehouse: vehicle coverage and inventory levels.” Transp. Res. B, 19B(5), 397–407.
8.
Geoffrion, A. M., and Graves, G. W. (1974). “Multicommodity distribution systems design by benders decomposition.” Mgmt. Sci., 20(5), Jun., 822–844.
9.
Ha, K. H. (1986). “An investigation of freight consolidation and field warehousing: effects on logistics systems performance,” thesis presented to Wayne State University, at Detroit, Mich., in partial fulfillment of the requirements for the degree of Doctor of Philosophy.
10.
Harper, D. V. (1980). “Federal motor carrier act of 1980: review and analysis.” Transp. J., 20(2), Winter, 5–33.
11.
Jackson, G. C. (1980). “Order consolidation research to 1980 and beyond.” Proceedings of the Tenth Annual Transportation and Logistics Educators Conference, B. J. LaLonde, ed., Atlanta, GA, 63–85.
12.
Jackson, G. C., and Morgan, F. W. (1982). “Freight consolidation strategies for channel management: a response to environmental change.” Annual Proceedings of the Academy of Marketing Science, Las Vegas, Nev., 11–14.
13.
Kirk, R. E. (1968). “Experimental design.” Procedures for the behavioral sciences, Brooks/Cole Publishing Co., Belmont, Calif., 98–99.
14.
Law, A. M., and Kelton, W. D. (1982). Simulation modeling and analysis. McGraw‐Hill, Inc., New York, N.Y.
15.
Maranzana, F. E. (1964). “On the location of supply points to minimize transportation costs.” Oper. Res. Q., 15, 261–270.
16.
Masters, J. M. (1981). “The effects of freight consolidation on customer service.” J. Business Logistics, 2(1), 55–73.
17.
Newbourne, M. J. (1976). A guide to freight consolidation for shippers, The Traffic Service Corp., Washington, D.C.
18.
Piercey, J. E., and Ballou, R. H. (1979). “A performance evaluation of freight transport modes.” Logistics and Transp. Review, 14(2), Spring, 99–115.
19.
Rand McNally zip code atlas (1978). Rand McNally and Co., Chicago, Ill.
Information & Authors
Information
Published In
Journal of Transportation Engineering
Volume 114 • Issue 2 • March 1988
Pages: 173 - 193
Copyright
Copyright © 1988 ASCE.
History
Published online: Mar 1, 1988
Published in print: Mar 1988
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.