Biotrickling Filtration for Control of Volatile Organic Compounds from Microelectronics Industry
Publication: Journal of Environmental Engineering
Volume 129, Issue 7
Abstract
This study investigated the transient and steady-state performance of a bench-scale biotrickling filter for the removal of an organic mixture (acetone, toluene, and trichloroethylene) typically emitted by the microelectronics industry. The microbial consortium consisting of seven bacterial strains that were fully acclimated prior to inoculation onto activated carbon media. Among the seven strains, the Pseudomonas and Sphingomonas strains appeared to be the major groups degrading toluene cell) and trichloroethylene cell), while Mycobacteria and Acetobacteriaceae strains were the primary decomposers of acetone cell). The column performance was evaluated by examining its responses to the fluctuating influent total hydrocarbon concentrations, which varied from 850 to 2,400 ppmv. Excellent steady-state removal efficiencies greater than 95% were consistently observed, and system recovery was typically within two days after a significant increase in the inlet loading was experienced. The overall mass-transfer rate and the biokinetic constants were determined for each organic component. Mathematical simulations based on these parameters demonstrated that the removal of acetone was kinetically limiting, whereas the removals of toluene and trichloroethylene were at least partially mass-transfer limiting.
Get full access to this article
View all available purchase options and get full access to this article.
References
Atlas, R. M., and Unterman, R. (1999). “Bioremediation.” Manual of industrial microbiology and biotechnology, 2nd Ed., A. L. Demain and J. E. Davies, eds., American Society of Microbiology, Washington, D.C., 666–681.
Barton, J. W., Hartz, S. M., Klasson, K. T., and Davison, B. R.(1998). “Microbial removal of alkanes from dilute gaseous waste streams: mathematical modeling of advanced bioreactor systems.” J. Chem. Technol. Biotechnol., 72(2), 93–98.
Bitzi, U., Egli, T., and Hamer, G.(1991). “The biodegradation of mixtures of organic solvents by mixed and monocultures of bacteria.” Biotechnol. Bioeng., 37(10), 1037–1042.
Chung, Y.-C., Huang, C., and Tseng, C. P.(1996). “Biodegradation of hydrogen sulfide by a laboratory-scale immobilized Pseudomonas putida CH11 biofilter.” Biotechnol. Prog., 12(6), 773–778.
Coogan, J. J., and Jassal, A. S. (1997). “Silent discharge plasma (SDP) for point-of-use (POU) abatement of volatile organic compound (VOC) emissions: Final report (ESHCOO3).” Technology Transfer Rep. No. 97023244-ENG, SEMATECH, Austin, Tex.
Cox, C. D., Woo, H.-J., and Robinson, K. G.(1998). “Cometabolic biodegradation of trichloroethylene (TCE) in the gas phase.” Water Sci. Technol., 37(8), 97–104.
Den, W. (2001). “Evaluating gas phase biofilter performance in treating chlorinated VOCs from industrial emissions: Principles, modeling and design.” PhD thesis, Dept. of Civil Engineering, Univ. of Southern California, Los Angeles.
Diks, R. M. M., Ottengraf, S. P. P., and Vrijland, S.(1994). “The existence of a biological equilibrium in a trickling filter or waste gas purification.” Biotechnol. Bioeng., 44(11), 1279–1287.
Fetzner, S.(1998). “Bacterial dehalogenation.” Appl. Microbiol. Biotecnol., 50(6), 633–657.
Fortin, N. Y., and Deshusses, M. A.(1999). “Treatment of methyl tert-butyl ether vapors in biotrickling filters. 1. Reactor startup, steady-state performance, and culture characteristics.” Environ. Sci. Technol., 33(17), 2980–2986.
Hanson, R. S., and Brusseau, G. A. (1994). “Biodegradation of low-molecular-weight halogenated organic compounds by aerobic bacteria.” Biological Degradation and Remediation of Toxic Chemicals, G. R. Chandhry, ed., Dioscorides Press, Portland, Ore., 277–297.
Harris, R. F., and Sommers, L. E.(1968). “Plate-dilution frequency technique for assay of microbial ecology.” Appl. Microbiol., 16(4), 330–334.
Hirai, M., Ohtake, M., and Shoda, M.(1990). “Removal kinetics of hydrogen sulfide, methanethiol and dimethyl sulfide by peat biofilters.” J. Ferment. Bioeng., 70(5), 334–339.
Kiared, K., Bibeau, L., Brzezinski, R., Viel, G., and Heitz, M.(1996). “Biological elimination of VOCs in biofilter.” Environ. Prog., 15(3), 148–152.
Kim, B. R., Adams, J. A., Klaver, P. R., Kalis, E. M., Contrera, M., Griffin, M., Davidson, J., and Pastick, T.(2000). “Biological removal of gaseous VOCs from automotive painting operations.” J. Environ. Eng., 126(8), 745–753.
Kim, N. J., Harai, M., and Shoda, M.(1998). “Comparison of organic and inorganic carriers in removal of hydrogen sulfide in biofilters.” Environ. Technol., 19(12), 1233–1241.
Kim, S.-H., and Pirbazari, M.(1989). “Bioactive adsorber model for industrial wastewater treatment.” J. Environ. Eng., 115(6), 1235–1256.
Lackey, L. W., Gamble, J. R., and Holt, M. T.(1998). “Feasibility testing of biofiltration technology for remediating air contaminated by a boat manufacturing facility.” J. Air Waste Manag. Assoc., 48(6), 527–536.
Lazarova, V., Bellahcen, D., Rybacki, D., Rittmann, B., and Manem, J.(1998). “Population dynamics and biofilm composition in a new three-phase circulating bed reactor.” Water Sci. Technol., 37(4/5), 149–158.
Lazarova, V., and Manen, J.(1995). “Biofilm characterization and activity analysis in water and wastewater treatment.” Water Res., 29(10), 2227–2245.
Leson, G., and Winer, A. M.(1991). “Biofiltration: An innovative air pollution control technology for VOC emissions.” J. Air Waste Manag. Assoc., 41(8), 1045–1054.
Mackey, D., and Shui, W. Y.(1981). “A critical review of Henry’s law constants for chemicals of environmental interest.” J. Phys. Chem. Ref. Data, 10(4), 1175–1199.
Maier, W. J. (1989). “Kinetics-dynamics of biodegradation of potentially toxic organic chemicals.” Proc., 43rd Purdue Industrial Waste Conf., Lewis, Chelsea, Mich., 257–265.
Nelson, M. J., Montgomery, S. O., Mahaffey, W. R., and Pritchard, P. H.(1987). “Biodegradation of trichloroethylene and involvement of an aromatic biodegradative pathway.” Appl. Environ. Microbiol., 53(5), 949–954.
Ochman, H., Lawrence, J., and Groisman, E. A.(2000). “Lateral gene transfer and the nature of bacterial innovation.” Nature (London), 405(6784), 299–304.
Pederson, A. R., and Arvin, E.(1997). “Effect of biofilm growth on the gas-liquid mass transfer in a trickling filter for waste gas treatment.” Water Res., 31(8), 1963–1968.
Pirbazari, M., Voice, T. C., and Weber, W. J. Jr., (1990). “Evaluation of biofilm development on various natural and synthetic media.” Hazard. Waste Hazard. Mater., 7(3), 239–250.
Quinlan, C., Strevett, K., and Ketcham, M.(1999). “VOC elimination in a compost biofilter using a previously acclimated bacterial inoculum.” J. Air Waste Manag. Assoc., 49(5), 544–553.
Roberts, P. V., Hopkins, G. D., Munz, C., and Riojas, A. H.(1985). “Evaluating two-resistance models for air stripping of volatile organic contaminants in a countercurrent, packed column.” Environ. Sci. Technol., 19(2), 164–173.
Shields, M. S., Montgomery, S. O., Chapman, P. J., Cuskey, S. M., and Pritchard, P. H.(1989). “Novel pathway of toluene catabolism in the trichloroethylene-degrading bacterium G4.” Appl. Environ. Microbiol., 55(6), 1624–1629.
Speitel, G. E., DiGiano, F. A., and Dovantzis, Jr., K.(1987). “Mathematical modeling of bioregeneration in GAC Columns.” J. Environ. Eng., 113(1), 32–48.
U.S. EPA. (1995). “Sector notebook project: Profile of the electronics and computer industry.” Rep. No. EPA/310-R-95-002, Office of Compliance, Research Triangle Park, N.C.
van Groenestijn, J. W., and Lake, M. E.(1999). “Elimination of alkanes from off-gases using biotrickling filters containing two liquid phases.” Environ. Prog., 18(3), 151–155.
Wackett, L. P., and Gibson, D. T.(1988). “Degradation of trichloroethylene by toluene dioxygenase in whole-cell studies with Pseudomonas putida F1.” Appl. Environ. Microbiol., 54(7), 1703–1708.
Weber, F. J., and Hartmans, S.(1996). “Prevention of clogging in a biological trickle-bed reactor removing toluene from contaminated air.” Biotechnol. Bioeng., 50(1), 91–97.
Winter, R. B., Yen, K.-M., and Ensley, B. D.(1989). “Efficient biodegradation of trichloroethylene by a recombinant Escherichia coli.” Bio/Technology, 7(3), 282–285.
Wolfrum, E. J., Rabago, R., and Jassal, A. S. (1997). “Destruction of volatile organic compound (VOC) emissions by photocatalytic oxidation (PCO): Final report (ESHCOO3).” Technology Transfer Rep. No. 97013236-ENG, SEMATECH, Austin, Tex.
Wright, W. F., Schroeder, E. D., Chang, D. P. Y., and Romstad, K.(1997). “Performance of a pilot-scale compost biofilter treating gasoline vapor.” J. Environ. Eng., 123(6), 547–555.
Wu, H.-H., Lin, S.-S., Yang, W.-J., Chou, C.-Y., and Lai, C.-C. (2001). “Emerging technology for control of volatile organic compounds (VOCs) from semiconductor manufacturing industry—wet scrubbing oxidation process.” Proc., 8th Annual Int. Conf. on Semiconductor Environmental Safety Health (ISESH), Semiconductor Industry Association, Kenting, Taiwan, 2B-1.
Yani, M., Harai, M., and Shoda, M.(1998). “Ammonia gas removal characteristics using biofilter with activated carbon fiber as a carrier.” Environ. Technol., 19(7), 709–715.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 129 • Issue 7 • July 2003
Pages: 610 - 619
Copyright
Copyright © 2003 American Society of Civil Engineers.
History
Received: Sep 18, 2001
Accepted: Aug 26, 2002
Published online: Jun 13, 2003
Published in print: Jul 2003
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.