A Feasibility Study on Harvesting Rainwater from Large Solar Panel Canopies to Supplement Makeup Water for Cooling Towers by Using Remotely Controlled and Self-Cleaning Rain Cistern
Publication: World Environmental and Water Resources Congress 2021
ABSTRACT
Rainwater collected from rooftops can be a safe, low-cost alternative source for non-potable water uses, thereby reducing tap water usage. In climates with adequate rainfall during cooling seasons, rainwater can compensate for evaporative water loss in cooling towers. Central chillers and cooling towers play an essential role in removing heat from large commercial, institutional, and industrial buildings. Water losses from evaporative cooling in the towers increase the concentration of minerals in the water system loop, and scaling occurs within the system, decreasing the heat exchange’s effectiveness and damaging equipment. Freshwater must be added to the cooling tower water system loop to make up for water losses. This paper presents a feasibility study on harvesting rainwater from solar panel canopies as an alternative water source for a cooling tower water makeup. A remotely controlled and automatically self-cleaning rain cistern is demonstrated in this study. In addition, a water quality analysis including the concentration of chemicals relevant to cooling tower operation was conducted on tap water and rainwater samples. The results show that the total dissolved solids concentration of the rainwater was significantly lower than tap water, indicating that an increase in the number of cycles of concentration (COC) could be achieved by using rainwater as part of the water makeup source. The predicated COC values for the rainwater/tap water blends were calculated, and the tap water reductions, financial benefits of using rainwater, and the pay-back period of the application of the remote control technology are analyzed in this study.
Get full access to this article
View all available purchase options and get full access to this chapter.
REFERENCES
ASHRA. (2004). American Society of Heating, Refrigerating and Air-Conditioning Engineers handbook: HVAC systems and equipment. Refrigeration and Air-Conditioning Engineers, Inc.
Bedient, P., Huber, W., and Vieux, B. (2018). Hydrology and Floodplain Analysis. Pearson.
Chien, S., Hsieh, M., Li, H., Monnell, J., Dzombak, D., and Vidic, R. (2012). “Pilot-scale cooling tower to evaluate corrosion, scaling, and biofouling control strategies for cooling system makeup water.” Review of Scientific Instruments, 83(2), 024101.
Costello, E. S. (2012). Utilization of Rainwater as a Supplementary Water Source for Cooling Tower Makeup : A Sustainability Strategy for Potable Water Use Reduction.
Datta, S., Sahgal, P. N., Subrahmaniyam, S., Dhingra, S. C., and Kishore, V. V. N. (1987). “Design and operating characteristics of evaporative cooling systems.” International Journal of Refrigeration, 10(4), 205–208.
Doyle, K. C. (2008). Sizing the first flush and its effect on the storage-reliability-yield behavior of rainwater harvesting in Rwanda. Massachusetts Institute of Technology.
EPA. (2017). Water Efficiency Management Guide Mechanical System. U.S. Environmental Protection Agency Water Sense Program.
FAO. (2000). “World-wide agroclimatic database.” Environmental and Natural Resources Working, 5.
Feng, X. (2008). “Design Experience of Roof Rainwater Recycled as Makeup Water for Cooling Tower.” Urban Environment and Urban Ecology, 21(6), 40–42.
“Florida Climate Center.” (n.d.). Office of the State Climatologist, <https://climatecenter.fsu.edu/climate-data-access-tools/downloadable-data> (Oct. 14, 2020).
Hamoda, M. F., Al-Ghusain, I., and AL-Mutairi, N. Z. (2004). “Sand filtration of wastewater for tertiary treatment and water reuse.” Desalination, 164(3), 203–211.
Hughes, J. D., and White, J. T. (2014). “Hydrologic conditions in urban Miami-Dade County, Florida, and the effect of groundwater pumpage and increased sea level on canal leakage and regional groundwater flow.” U.S. Geological Survey, 175.
Kim, J.-K., and Smith, R. (2004). “Cooling System Design for Water and Wastewater Minimization.” Industrial & Engineering Chemistry Research, American Chemical Society, 43(2), 608–613.
Kloss, C. (2008). Managing wet weather with green infrastructure municipal handbook: rainwater harvesting policies. U.S. Environmental Protection Agency.
Kus, B., Kandasamy, J., Vigneswaran, S., and Shon, H. K. (2010). “Analysis of first flush to improve the water quality in rainwater tanks.” Water Science and Technology, 61(2), 421–428.
Lee, K. E., Mokhtar, M., Mohd Hanafiah, M., Abdul Halim, A., and Badusah, J. (2016). “Rainwater harvesting as an alternative water resource in Malaysia: Potential, policies and development.” Journal of Cleaner Production, 126, 218–222.
Leon, A. S., and Verma, V. (2020). “Towards Smart and Green Flood Control: Remote and Optimal Operation of Control Structures in a Network of Storage Systems for Mitigating Floods.” World Environmental and Water Resources Congress 2019, Proceedings.
Liu, J., Li, K., Chan, T., and Liu, Y. (2014). Rainwater Harvesting and Technology: To Investigate the Application of Rainwater Reuse in Makeup Water of Fresh Water Cooling Tower System in Hong Kong. City University of Hong Kong.
McCoy, J. W. (1983). The Chemical Treatment of Cooling Water. New York: Chemical Publishing Co.
Mendez, C. B., Afshar, B. R., Kinney, K., Barrett, M. E., and Kirisits, M. J. (2010). Effect of roof material on water quality for rainwater harvesting systems. Texas Water Development Board.
Moreira Neto, R. F., Calijuri, M. L., Carvalho, I. D. C., and Santiago, A. D. F. (2012a). “Rainwater treatment in airports using slow sand filtration followed by chlorination: Efficiency and costs.” Resources, Conservation and Recycling, Elsevier B.V., 65, 124–129.
Moreira Neto, R. F., Calijuri, M. L., Carvalho, I. de C., and Santiago, A. da F. (2012b). “Rainwater treatment in airports using slow sand filtration followed by chlorination: Efficiency and costs.” Resources, Conservation and Recycling, 65, 124–129.
Mortensen, K. (2003). “How to manage cooling tower water quality.” RES Journal.
Mun, J., and Han, M. (2012). “Design and operational parameters of a rooftop rainwater harvesting system: Definition sensitivity and verification.” Journal of Environmental Management, 93(1), 147–153.
Nguyen, T. A., and Aiello, M. (2013). “Energy intelligent buildings based on user activity: A survey.” Energy and Buildings, 56, 244–257.
Perry, R. (1984). Perry’s Chemical Engineers’ Handbook. McGraw-Hill, Inc.
Qin, L., Leon, A. S., Bian, L., Dong, L., Verma, V., and Yolcu, A. (2019). “A Remotely-Operated Siphon System for Water Release From Wetlands and Shallow Ponds.” IEEE Access, 7, 157680–157687.
San Diego Country Water Authority. (2009). “Technical Information for Cooling Towers Using Recycled Water.” Www.Sdcwa.Org.
Stoeglehner, G., Edwards, P., Daniels, P., and Narodoslawsky, M. (2011). “The water supply footprint (WSF): a strategic planning tool for sustainable regional and local water supplies.” Journal of Cleaner Production, 19(15), 1677--1686.
USDA. (1986). “Urban Hydrology for Small Watershed TR-55.”.
Verma, V., Bian, L., Rojali, A., Ozecik, D., and Leon, A. (2020a). “A Remotely Controlled Framework for Gravity-Driven Water Release in Shallow and Not Shallow Storage Ponds.” World Environmental and Water Resources Congress 2020, Proceedings, 12–22.
Verma, V., Vutukuru Krishna, S., Bian, L., Rojali, A., Ozecik, D., and Leon, A. (2020b). “Reliability and Robustness Evaluation of a Remotely Operated Siphon System for Flood Mitigation during Hurricanes.” World Environmental and Water Resources Congress 2020, Proceedings.
Visscher, J. T. (1990). “Slow sand filtration. Design, operation, and maintenance.” Journal/American Water Works Association, 82(6), 67–71.
Wijesinghe, B., Kaye, R. B., and Fell, C. J. D. (1996). “Reuse of treated sewage effluent for cooling water make up: A feasibility study and a pilot plant study.” Water Science and Technology, International Association on Water Quality, 33(10–11), 363–369.
Williams, J. R., Haka, S. F., Bettner, M. S., and Carcello, J. V. (2005). Financial and managerial accounting. China Machine Press.
Information & Authors
Information
Published In
World Environmental and Water Resources Congress 2021
Pages: 1118 - 1134
Copyright
© 2021 American Society of Civil Engineers.
History
Published online: Jun 3, 2021
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Linlong Bian, Vivek Verma, Zeda Yin, William Campbell, Arturo S. Leon, An Integrated Framework for Automatic Flood Mitigation at the Watershed Scale, International Low Impact Development Conference 2023, 10.1061/9780784485002.006, (58-66), (2023).