Ground Improvement of Dredged Fills with Two Improved Vacuum Preloading Methods: Case Study
Publication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 148, Issue 12
Abstract
In a full-scale case study, the performance of two methods—the vacuum-surcharge preloading method (S-VP) and the air-booster vacuum preloading method (A-VP)—were compared in terms of the dredged soft soil ground of the Xiang’an International Airport pavement reinforcement project in Xiamen City, China. The pore water pressure dissipation, settlement, lateral displacement, and consolidation degree were measured in the zones reinforced using the two methods. The direct shear test and field vane shear test were conducted before and after improvement. The S-VP and A-VP methods were loaded for 308 and 228 days, respectively. The results show that both reinforcement methods significantly improved the shear strength and foundation bearing capacity of the soft soil ground. The S-VP method has about 30% higher final vane shear strength and more uniform settlement compared to the A-VP method. However, the dissipation value of the average pore water pressure and the maximum foundation settlement were 5.6% and 11% higher, respectively, in A-VP than in S-VP. Compared to the S-VP method, the A-VP method decreased the maximum lateral displacements by 15%–20%, and increased the maximum reinforcement depth by 11%. Finally, compared with the use of sand cushion and vacuum pump, the A-VP method was more economical in terms of cost and energy use.
Practical Applications
Land reclamation projects will produce a large area of ground composed of ultrasoft soil, which has very low strength and cannot be used for construction activities directly on such ground. For such ultrasoft soil ground, the vacuum preloading method is generally used to strengthen the ultrasoft soil. In this study, two different vacuum preloading methods [the vacuum-surcharge preloading method (S-VP) and the air-booster vacuum preloading method (A-VP)] were used to strengthen the ultrasoft soil, and the final reinforcement effect and cost of the two methods were compared. The results show that the final reinforcement effect of the A-VP method was close to that of the S-VP method. Furthermore, the A-VP method saved more than 3 million Chinese currency (CNY) and reduced the power consumption by 80% in this project. In addition, the implementation of the A-VP method does not require a large amount of sand that is difficult to obtain in coastal areas, which is good protection for the natural resources in coastal areas. Therefore, in the ultrasoft soil reinforcement project, the A-VP method is a method worth considering.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
All data used during the study appear in the published paper.
Acknowledgments
The authors would like to acknowledge the National Natural Science Foundation of China (NSFC) (Nos. 51908406 and 52078334) for their financial support.
References
Aghazadeh Ardebili, Z., M. A. Gabr, and M. S. Rahman. 2016. “Uplift capacity of plate anchors in saturated clays: Analyses with different constitutive models.” Int. J. Geomech. 16 (2): 04015053. https://doi.org/10.1061/(ASCE)GM.1943-5622.0000518.
Anda, R., H. Fu, J. Wang, H. Lei, X. Hu, Q. Ye, Y. Cai, and Z. Xie. 2020. “Effects of pressurizing timing on air booster vacuum consolidation of dredged slurry.” Geotext. Geomembr. 48 (4): 491–503. https://doi.org/10.1016/j.geotexmem.2020.02.007.
Asaoka, A. 1978. “Observational procedure of settlement prediction.” Soils Found. 18 (4): 87–101. https://doi.org/10.3208/sandf1972.18.4_87.
Baral, P., B. Indraratna, C. Rujikiatkamjorn, R. Kelly, and P. Vincent. 2021. “Consolidation by vertical drains beneath a circular embankment under surcharge and vacuum preloading.” J. Geotech. Geoenviron. Eng. 147 (8): 05021004. https://doi.org/10.1061/(ASCE)GT.1943-5606.0002576.
Bergado, D. T., J. C. Chai, N. Miura, and A. S. Balasubramaniam. 1998. “PVD improvement of soft Bangkok clay with combined vacuum and reduced sand embankment preloading.” Geotech. Eng. 29 (1): 95–122.
Cai, Y., H. Qiao, J. Wang, X. Geng, P. Wang, and Y. Cai. 2017. “Experimental tests on effect of deformed prefabricated vertical drains in dredged soil on consolidation via vacuum preloading.” Eng. Geol. 222 (May): 10–19. https://doi.org/10.1016/j.enggeo.2017.03.020.
Cai, Y., Z. Xie, J. Wang, P. Wang, and X. Geng. 2018. “New approach of vacuum preloading with booster prefabricated vertical drains (PVDs) to improve deep marine clay strata.” Can. Geotech. J. 55 (10): 1359–1371. https://doi.org/10.1139/cgj-2017-0412.
Chai, J. C., J. P. Carter, and S. Hayashi. 2005. “Ground deformation induced by vacuum consolidation.” J. Geotech. Geoenviron. Eng. 131 (12): 1552–1561. https://doi.org/10.1061/(ASCE)1090-0241(2005)131:12(1552).
Chu, J., and S. Yan. 2015. “Application of the vacuum preloading method in soil improvement projects.” In Ground improvement case histories: Embankments with special reference to consolidation and other physical methods, edited by B. Indraratna, J. J. Chu, and C. Rujikiatkamjorn 123–150. Amsterdam, Netherlands: Elsevier. https://doi.org/10.1016/S1571-9960(05)80006-0.
Gabr, M. A., J. Xiao, and M. S. Rahman. 2015. “Plastic flow of sand and pullout capacity of suction caissons.” J. Geotech. Geoenviron. Eng. 141 (8): 02815002. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001331.
Han, J., and M. A. Gabr. 2002. “Numerical analysis of geosynthetic-reinforced and pile-supported earth platforms over soft soil.” J. Geotech. Geoenviron. Eng. 128 (1): 44–53. https://doi.org/10.1061/(ASCE)1090-0241(2002)128:1(44).
Han, J., A. R. Sheth, A. Porbaha, and S. L. Shen. 2004. “Numerical analysis of embankment stability over deep mixed foundations.” In Proc., Geo-Trans 2004: Geotechnical Engineering for Transportation Projects, 1385–1394. Reston, VA: ASCE. https://doi.org/10.1061/40744(154)128.
Indraratna, B., C. Rujikiatkamjorn, X. Geng, J. Ameratunga, and P. Boyle. 2011. “Performance and prediction of vacuum combined surcharge consolidation at port of Brisbane.” J. Geotech. Geoenviron. Eng. 137 (11): 1009–1018. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000519.
Jiang, Y., J. Han, and G. Zheng. 2013a. “Consolidation of column-reinforced soft foundations under embankments.” In Proc., Geo-Congress 2013: Stability and Performance of Slopes and Embankments III, 1818–1821. Reston, VA: ASCE. https://doi.org/10.1061/9780784412787.182.
Jiang, Y., J. Han, and G. Zheng. 2013b. “Numerical analysis of consolidation of soft soils fully-penetrated by deep-mixed columns.” KSCE J. Civ. Eng. 17 (1): 96–105. https://doi.org/10.1007/s12205-013-1641-x.
Kjellman, W. 1952. “Consolidation of clayey soils by atmospheric pressure.” In Proc., Conf. on Soil Stabilization, 258–263. Boston: Massachusetts Institute of Technology.
Lei, H., H. Lu, J. Liu, and G. Zheng. 2017a. “Experimental study of the clogging of dredger fills under vacuum preloading.” Int. J. Geomech. 17 (12): 04017117. https://doi.org/10.1061/(ASCE)GM.1943-5622.0001028.
Lei, H., Z. Qi, Z. Zhang, and G. Zheng. 2017b. “New vacuum-preloading technique for ultrasoft-soil foundations using model tests.” Int. J. Geomech. 17 (9): 04017049. https://doi.org/10.1061/(ASCE)GM.1943-5622.0000934.
Lei, H., Y. Xu, X. Li, M. Jiang, and L. Liu. 2019. “Effect of polyacrylamide on improvement of dredger fill with vacuum preloading method.” J. Mater. Civ. Eng. 31 (9): 04019193. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002860.
Lei, H. Y., Y. Hu, J. J. Liu, X. Liu, and C. Y. Li. 2021. “Consolidation behavior of Tianjin dredged clay using two air-booster vacuum preloading methods.” J. Zhejiang Univ. Sci. A 22 (2): 147–164. https://doi.org/10.1631/jzus.A2000133.
Liu, F., Y. Tao, J. Ni, Z. Gao, and G. Yuan. 2021a. “Slurry improvement by vacuum pre-loading in combination with electro-osmosis and with dynamic compaction method.” Mar. Georesour. Geotechnol. 39 (6): 709–718. https://doi.org/10.1080/1064119X.2020.1753865.
Liu, J., H. Lei, G. Zheng, S. Feng, and M. S. Rahman. 2018. “Improved synchronous and alternate vacuum preloading method for newly dredged fills: Laboratory model study.” Int. J. Geomech. 18 (8): 04018086. https://doi.org/10.1061/(ASCE)GM.1943-5622.0001220.
Liu, S., Y. Cai, H. Sun, X. Geng, L. Shi, and X. Pan. 2021b. “Consolidation considering clogging effect under uneven strain assumption.” Int. J. Geomech. 21 (1): 04020239. https://doi.org/10.1061/(ASCE)GM.1943-5622.0001898.
Mesri, G., and A. Q. Khan. 2012. “Ground improvement using vacuum loading together with vertical drains.” J. Geotech. Geoenviron. Eng. 138 (6): 680–689. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000640.
Rujikiatkamjorn, C., and B. Indraratna. 2014. “Environmental sustainability of soft soil improvement via vacuum and surcharge preloading.” In Proc., Geo-Congress, 3658–3665. Reston, VA: ASCE. https://doi.org/10.1061/9780784413272.354.
Shang, J. Q., M. Tang, and Z. Miao. 1998. “Vacuum preloading consolidation of reclaimed land: A case study.” Can. Geotech. J. 35 (5): 740–749. https://doi.org/10.1139/t98-039.
Shen, Y., M. Tao, H. Liu, Y. Gao, and Y. Cui. 2013. “The performance of super soft foundations under a modified vacuum preloading method.” In Proc., Forensic Engineering 2012: Gateway to a Safer Tomorrow, 708–715. Reston, VA: ASCE. https://doi.org/10.1061/9780784412640.075.
Wang, J., Y. Cai, J. Ma, J. Chu, H. Fu, P. Wang, and Y. Jin. 2016. “Improved vacuum preloading method for consolidation of dredged clay-slurry fill.” J. Geotech. Geoenviron. Eng. 142 (11): 06016012. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001516.
Wang, J., J. Ni, Y. Cai, H. Fu, and P. Wang. 2017. “Combination of vacuum preloading and lime treatment for improvement of dredged fill.” Eng. Geol. 227 (Sep): 149–158. https://doi.org/10.1016/j.enggeo.2017.02.013.
Yan, S. W., and J. Chu. 2005. “Soil improvement for a storage yard using the combined vacuum and fill preloading method.” Can. Geotech. J. 42 (4): 1094–1104. https://doi.org/10.1139/t05-042.
Ye, G. B., Z. Zhang, J. Han, H. F. Xing, M. S. Huang, and P. L. Xiang. 2013. “Performance evaluation of an embankment on soft soil improved by deep mixed columns and prefabricated vertical drains.” J. Perform. Constr. Facil. 27 (5): 614–623. https://doi.org/10.1061/(ASCE)CF.1943-5509.0000369.
Zheng, G., J. Liu, H. Lei, M. S. Rahman, and Z. Tan. 2017. “Improvement of very soft ground by a high-efficiency vacuum preloading method: A case study.” Mar. Georesour. Geotechnol. 35 (5): 631–642. https://doi.org/10.1080/1064119X.2016.1215363.
Information & Authors
Information
Published In
Copyright
© 2022 American Society of Civil Engineers.
History
Received: Nov 26, 2021
Accepted: Jul 20, 2022
Published online: Oct 10, 2022
Published in print: Dec 1, 2022
Discussion open until: Mar 10, 2023
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Jingjin Liu, Xuesi Luo, Huayang Lei, Gang Zheng, Haopeng Luo, Yawei Jin, Dredged Clay Treatment Consolidation Theory by Air-Booster Vacuum Preloading, Journal of Geotechnical and Geoenvironmental Engineering, 10.1061/JGGEFK.GTENG-11918, 150, 5, (2024).