Degradation of Acetate, Propionate, and Butyrate under Shock Temperature
Publication: Journal of Environmental Engineering
Volume 119, Issue 2
Abstract
Experiments were performed to determine the degradation of acetate, propionate, and butyrate, and the maximum methanogenic activity of granular sludge from the thermophilic anaerobic digestion (55°C) of pure molasses under shock temperature conditions. The compositions of acetate, propionate, and butyrate that were used as substrates were 25:35:40, respectively. On two duplicate batch reactors (I and II) runnning in parallel and at a pH of 7, the tests were performed at 63°C during the first volatile fatty acid (VFA) addition (first feeding or first experiment) and at 55°C after the second VFA addition. During the first and second VFA additions, there was a lag phase. In the first experiment, by the end of 160 hours, after the initial concentrations of butyrate and acetate had been completely degraded, only 35–55% of the initial concentration of propionate was converted to acetate. The maximum methanogenic activities of the first feeding were not high because the population of propionate degrading bacteria was low and these bacteria were negatively affected from the shock temperature changes. In the second experiment, with the same sludge, the maximum methanogenic activities on second VFA additions were about 1.3 times higher than those of the first VFA additions. This increase may be due to a faster adaptation of the sludge and an increase of the population of the propionate degrading bacteria as a result of returning to the optimum temperature conditions.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Barredo, M. S., and Evison, L. M. (1991). “Effect of propionate on methanogenenrich sludge, methanobrevibacter smithii, and methanospirillum hungatii at different pH values.” Appl. Environ. Microbiol., 57(6), 1764–1769.
2.
Boone, D. (1989). “Fermentation reactions of anaerobic digestion.” Int. Course in Anaerobic Wastewater Treatment, IHE, Delft, The Netherlands.
3.
Denac, M., Miquel, A., and Dunn, I. J. (1988). “Modelling dynamic experiments on the anaerobic degradation of molasses wastewater.” Biotech. and Bioeng., 31(1), 1–10.
4.
Dohanyos, M., Kosova, B., Zabranska, J., and Grau, P. (1985). “Production and utilization of VFA's in various types of anaerobic reactors.” Water Sci. Tech., 17, 191–205.
5.
Field, J., and Sierra, R. (1989). Biodegradability and toxicity—lecture series, Dept. Water Pollution Control, Agricultural Univ., Wageningen, The Netherlands.
6.
Gijzen, H. J., Zwart, K. B., Verhagen, F. J. M., and Vogels, G. D. (1988). “High‐rate two‐phase process for the anaerobic degradation of cellulose employing rumen microoganisms for an efficient adidogenesis.” Biotech. and Bioeng., 31, 418–425.
7.
Hanaki, K., Matsuo, T., Nagose, M., and Tabato, Y. (1987). “Evaluation of the effectiveness of two‐phase anaerobic digestion process degrading complex substrate.” Water Sci. Tech., 19, 311–322.
8.
Lin, C. Y., Sato, K., Noike, T., and Matsumoto, J. (1986). “Methanogenic digestion using mixed substrate of acetic, propionic and butyric acids.” Wat. Res., 20(3), 385–394.
9.
Mosey, F. E. (1982). “Mathematical modelling of the anaerobic digestion process, regulatory mechanism for the formation of short‐chain volatile acids from glucose.” Water Sci. Tech., 15, 209–232.
10.
Parkin, G. F., and Owen, W. F. (1986). Fundamentals of anaerobic digestion of wastewater sludges. J. Envir. Engrg., ASCE, 112(5), 867–920.
11.
Peck, M. W., Skilton, J. M., Hawkes, F. R., and Hawkes, D. L. (1986). “Effect of temperature shock treatments on the stability of anaerobic digesters operated on separated cattle slurry.” Wat. Res., 20(4), 453–463.
12.
Ozturk, M. (1991). “Conversion of acetate, propionate and butyrate to methane under thermophilic conditions in batch reactors.” Wat. Res., 25(12), 1509–1513.
13.
Samsoon, P. A. L. N. S., Loewenthal, R. E., Dold, P. L., and Marois, G. V. R. (1988). “Pelletization in upflow anaerobic sludge bed reactors.” Proc., 5th Int. Symp. on Anaerobic Digestion, IAWPRC, Pergamon Press, Oxford, England, 55–60.
14.
Smith, P. H., and Mah, R. H. (1966). “Kinetics of acetate metabolism during sludge digestion.” Appl. Microbiol., 14(2), 368–371.
15.
Stams, F. (1989). Microbiology of anaerobic digestion. Dept. Water Pollution Control Agricultural Univ., Wageningen, The Netherlands.
16.
Stronach, S. M., Rudd, T., and Lester, J. N. (1986). Anaerobic digestion processes in industrial wastewater treatment. Springer‐Verlag, London, U.K.
17.
Wiegant, W. M., Hennink, M., and Lettinga, G. (1986). “Separation of the propionate degradation to improve the efficiency of thermophilic anaerobic treatment of acidified wastewater.” Wat. Res., 20(4), 517–524.
18.
Wiegant, W. M. (1986). “Thermophilic anaerobic wastewater treatment.” Anaerobic Treatment: A Grown‐up Technology, Water Treatment Conf., NVA, EWPCA, RAI Halls, Amsterdam, The Netherlands.
19.
Zinder, S. H. (1988). “Conversion of acid to methane by thermophilic.” Proc., 5th Int. Symp. on Anaerobic Digester, IAWPRC, Pergamon Press, Oxford, England, 1–11.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 119 • Issue 2 • March 1993
Pages: 321 - 331
Copyright
Copyright © 1993 American Society of Civil Engineers.
History
Received: Aug 10, 1991
Published online: Mar 1, 1993
Published in print: Mar 1993
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.