Potential Energy, Economic, and Environmental Impacts of Hydro Power Pressure Reduction on the Water-Energy-Food Nexus
Publication: Journal of Water Resources Planning and Management
Volume 148, Issue 5
Abstract
The installation of hydropower pressure reduction (HPPR) technology in water supply networks (WSN) has recently been encouraged to limit water losses through leakage. Traditionally, pressure reducing valves (PRVs) were positioned at strategic nodes in a water network and were operated continuously to dissipate excess energy and minimize pipe failure. The alternative adoption of low-cost and highly reliable HPPR technology—Pump As Turbine (PAT)—can recover energy to improve the sustainable management of water networks and increase the energy, economic, and environmental benefits derived from the provision of water resources. To encourage the exploitation of HPPR, indicators and metrics were developed and applied for a case study (olive crop production with an irrigation network in Andalusia, Spain). The case study incorporated (1) a number of WSN scenarios based on water supply conditions, location of the HPPR within the network, and pipe age; (2) the expected performance of the PAT in the market; and (3) the expected optimal performance of an HPPR design based on a variable operation strategy (VOS). Independent life cycle indicators and nexus metrics were created to enhance the evaluation of the performance of HPPR technology as part of the water-energy-food nexus. In this case study, the new metrics expressed the impact of HPPR technology on the water-energy food nexus in terms of climate change and in the context of olive production in an irrigation network. The methodology for assessing combined energy, economic, and environmental metrics (3EM) can be used to account for the value of HPPR deployment in any WSN. These metrics can inform local decision makers and national policy makers, by providing relative and/or absolute evidence on the environmental impacts of HPPR technology in the water sector.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
All data, models, and code generated or used during the study appear in the published article.
Acknowledgments
This paper was part funded by the European Regional Development Funds, Interreg Atlantic Area Programme 2014-2020, through the REDAWN project (EAPA 198_2016).
References
Almandoz, J., E. Cabrera, F. Arregui, E. Cabrera Jr., and R. Cobacho. 2005. “Leakage assessment through water distribution network simulation.” J. Water Resour. Plann. Manage. 131 (6): 458–466. https://doi.org/10.1061/(ASCE)0733-9496(2005)131:6(458).
Arriaga, M. 2010. “Pump as turbine—A pico-hydro alternative in Lao People’s Democratic Republic.” Renewable Energy 35 (5): 1109–1115. https://doi.org/10.1016/j.renene.2009.08.022.
Brockway, P. E., A. Owen, L. I. Brand-Correa, and L. Hardt. 2019. “Estimation of global final-stage energy-return-on-investment for fossil fuels with comparison to renewable energy sources.” Nat. Energy 4 (7): 612–621. https://doi.org/10.1038/s41560-019-0425-z.
Carravetta, A., M. C. Conte, O. Fecarotta, and H. M. Ramos. 2014a. “Evaluation of PAT performances by modified affinity law.” Procedia Eng. 89 (Jan): 581–587. https://doi.org/10.1016/j.proeng.2014.11.481.
Carravetta, A., S. Derakhshan Houreh, and H. M. Ramos. 2018a. Pumps as turbines. Berlin: Springer.
Carravetta, A., O. Fecarotta, and M. C. Conte. 2017. “Minimum efficiency index: Testing its performance.” World Pumps 2017 (Apr): 34–37. https://doi.org/10.1016/S0262-1762(17)30141-4.
Carravetta, A., O. Fecarotta, G. Del Giudice, and H. Ramos. 2014b. “Energy recovery in water systems by PATs: A comparisons among the different installation schemes.” Procedia Eng. 70 (Jan): 275–284. https://doi.org/10.1016/j.proeng.2014.02.031.
Carravetta, A., O. Fecarotta, U. M. Golia, M. La Rocca, R. Martino, R. Padulano, and T. Tucciarelli. 2016. “Optimization of osmotic desalination plants for water supply networks.” Water Resour. Manage. 30 (11): 3965–3978. https://doi.org/10.1007/s11269-016-1404-9.
Carravetta, A., O. Fecarotta, and H. M. Ramos. 2018b. “A new low-cost installation scheme of PATs for pico-hydropower to recover energy in residential areas.” Renewable Energy 125 (Sep): 1003–1014. https://doi.org/10.1016/j.renene.2018.02.132.
CEER (Council of European Energy Regulators). 2018. Status review of renewable support schemes in Europe for 2016 and 2017: Rublic report. Brussels: CEER.
Coelho, B., and A. Andrade-Campos. 2014. “Efficiency achievement in water supply systems—A review.” Renewable Sustainable Energy Rev. 30 (Feb): 59–84. https://doi.org/10.1016/j.rser.2013.09.010.
Corcoran, L., A. McNabola, and P. Coughlan. 2016. “Optimization of water distribution networks for combined hydropower energy recovery and leakage reduction.” J. Water Resour. Plann. Manage. 142 (2): 04015045. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000566.
Crespo Chacón, M., J. A. R. Díaz, J. G. Morillo, and A. McNabola. 2019. “Pump-as-turbine selection methodology for energy recovery in irrigation networks: Minimising the payback period.” Water 11 (1): 149. https://doi.org/10.3390/w11010149.
Crespo Chacón, M., J. A. Rodríguez Díaz, J. García Morillo, and A. McNabola. 2020. “Hydropower energy recovery in irrigation networks: Validation of a methodology for flow prediction and pump as turbine selection.” Renewable Energy 147 (Mar): 1728–1738. https://doi.org/10.1016/j.renene.2019.09.119.
Derakhshan, S., and A. Nourbakhsh. 2008a. “Experimental study of characteristic curves of centrifugal pumps working as turbines in different specific speeds.” Exp. Therm Fluid Sci. 32 (3): 800–807. https://doi.org/10.1016/j.expthermflusci.2007.10.004.
Derakhshan, S., and A. Nourbakhsh. 2008b. “Theoretical, numerical and experimental investigation of centrifugal pumps in reverse operation.” Exp. Therm Fluid Sci. 32 (8): 1620–1627. https://doi.org/10.1016/j.expthermflusci.2008.05.004.
Ecoinvent. 2020. “Ecoinvent association.” Accessed July 30, 2020. https://www.ecoinvent.org/.
European Union. 2012. Implementing directive 2009/125/EC of the European Parliament and of the Council with regard to ecodesign requirements for water pumps. Commission Regulation (EU) No. 547/2012. Maastricht, Netherlands: European Union.
Fecarotta, O., A. Carravetta, H. M. Ramos, and R. Martino. 2016. “An improved affinity model to enhance variable operating strategy for pumps used as turbines.” J. Hydraul. Res. 54 (3): 332–341. https://doi.org/10.1080/00221686.2016.1141804.
Fecarotta, O., and A. McNabola. 2017. “Optimal location of pump as turbines (PATs) in water distribution networks to recover energy and reduce leakage.” Water Resour. Manage. 31 (15): 5043–5059. https://doi.org/10.1007/s11269-017-1795-2.
Fecarotta, O., H. M. Ramos, S. Derakhshan, G. Del Giudice, and A. Carravetta. 2018. “Fine tuning a PAT hydropower plant in a water supply network to improve system effectiveness.” J. Water Resour. Plann. Manage. 144 (8): 04018038. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000961.
Fontana, N., M. Giugni, and D. Portolano. 2012. “Losses reduction and energy production in water-distribution networks.” J. Water Resour. Plann. Manage. 138 (3): 237–244. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000179.
Gaius-obaseki, T. 2010. “Hydropower opportunities in the water industry.” Int. J. Environ. Sci. 1 (3): 392–402.
Gallagher, J., I. M. Harris, A. J. Packwood, A. McNabola, and A. P. Williams. 2015a. “A strategic assessment of micro-hydropower in the UK and Irish water industry: Identifying technical and economic constraints.” Renewable Energy 81 (Sep): 808–815. https://doi.org/10.1016/j.renene.2015.03.078.
Gallagher, J., D. Styles, A. McNabola, and A. P. Williams. 2015b. “Life cycle environmental balance and greenhouse gas mitigation potential of micro-hydropower energy recovery in the water industry.” J. Cleaner Prod. 99 (Jul): 152–159. https://doi.org/10.1016/j.jclepro.2015.03.011.
Giugni, M., N. Fontana, and A. Ranucci. 2014. “Optimal location of PRVs and turbines in water distribution systems.” J. Water Resour. Plann. Manage. 140 (9): 06014004. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000418.
Gobierno de Espana. 2016. Factores de emisión de y coeficientes de paso a energía primaria de diferentes fuentes de energía final consumidas en el sector de edificios en España. Madrid: Government of Spain.
González-Gómez, F., M. A. García-Rubio, and J. Guardiola. 2012. “Introduction: Water policy and management in Spain.” Int. J. Water Resour. Dev. 28 (1): 3–11. https://doi.org/10.1080/07900627.2012.640604.
IEA (International Energy Agency). 2016. Water-energy nexus—Excerpt from the world energy outlook 2016. Paris: IEA.
IEC (International Electrotechnical Commission). 2014. Rotating electrical machines—Part 30-1: Efficiency classes of line operated AC motors (IE code). IEC 60034-30-1:2014. Geneva: IEC.
INE (National Statistics Institute). 2015. “Survey on the use of water in the agricultural sector 2014.” In Encuesta sobre el uso del agua en el sector agrario. London: INE.
Jones, L. E., and G. Olsson. 2017. “Solar photovoltaic and wind energy providing water.” Global Challenges 1 (5): 1600022. https://doi.org/10.1002/gch2.201600022.
King, C. W., and M. Carbajales-Dale. 2016. “Food–energy–water metrics across scales: Project to system level.” J. Environ. Stud. Sci. 6 (1): 39–49. https://doi.org/10.1007/s13412-016-0390-9.
Martin, B., and T. Ries. 2015. “Control water loss in your distribution system.” Opflow 41 (4): 8–9. https://doi.org/10.5991/OPF.2015.41.0023.
Marttunen, M., J. Mustajoki, S. Sojamo, L. Ahopelto, and M. Keskinen. 2019. “A framework for assessing water security and the water–Energy–Food Nexus—The case of Finland.” Sustainability 11 (10): 2900. https://doi.org/10.3390/su11102900.
McNabola, A., P. Coughlan, L. Corcoran, C. Power, A. P. Williams, I. Harris, J. Gallagher, and D. Styles. 2014. “Energy recovery in the water industry using micro-hydropower: An opportunity to improve sustainability.” Water Policy 16 (1): 168–183. https://doi.org/10.2166/wp.2013.164.
Morani, M. C., A. Carravetta, G. Del Giudice, A. McNabola, and O. Fecarotta. 2018. “A comparison of energy recovery by PATs against direct variable speed pumping in water distribution networks.” Fluids 3 (2): 41. https://doi.org/10.3390/fluids3020041.
Nguyen, V. B., Q. B. Nguyen, Z. G. Liu, S. Wan, C. Y. H. Lim, and Y. W. Zhang. 2014. “A combined numerical–experimental study on the effect of surface evolution on the water–sand multiphase flow characteristics and the material erosion behavior.” Wear 319 (1–2): 96–109. https://doi.org/10.1016/j.wear.2014.07.017.
Nhamo, L., T. Mabhaudhi, S. Mpandeli, C. Dickens, C. Nhemachena, A. Senzanje, D. Naidoo, S. Liphadzi, and A. T. Modi. 2020. “An integrative analytical model for the water-energy-food nexus: South Africa case study.” Environ. Sci. Policy 109 (Jul): 15–24. https://doi.org/10.1016/j.envsci.2020.04.010.
Novara, D., A. Carravetta, A. McNabola, and H. M. Ramos. 2019. “Cost model for pumps as turbines in run-of-river and in-pipe microhydropower applications.” J. Water Resour. Plann. Manage. 145 (5): 04019012. https://doi.org/10.1061/(ASCE)WR.1943-5452.0001063.
Novara, D., and A. McNabola. 2018. “A model for the extrapolation of the characteristic curves of pumps as turbines from a datum best efficiency point.” Energy Convers. Manage. 174 (Oct): 1–7. https://doi.org/10.1016/j.enconman.2018.07.091.
Okot, D. K. 2013. “Review of small hydropower technology.” Renewable Sustainable Energy Rev. 26 (Oct): 515–520. https://doi.org/10.1016/j.rser.2013.05.006.
Payet-Burin, R., M. Kromann, S. Pereira-Cardenal, K. M. Strzepek, and P. Bauer-Gottwein. 2019. “WHAT-IF: An open-source decision support tool for water infrastructure investment planning within the water-energy-food-climate nexus.” Hydrol. Earth Syst. Sci. 23 (10): 4129–4152. https://doi.org/10.5194/hess-23-4129-2019.
Prescott, S. L., and B. Ulanicki. 2008. “Improved control of pressure reducing valves in water distribution.” J. Hydraul. Eng. 134 (1): 56–65. https://doi.org/10.1061/(ASCE)0733-9429(2008)134:1(56).
Punys, P., A. Dumbrauskas, A. Kvaraciejus, and G. Vyciene. 2011. “Tools for small hydropower plant resource planning and development: A review of technology and applications.” Energies 4 (9): 1258–1277. https://doi.org/10.3390/en4091258.
Ramos, H., and A. Borga. 1999. “Pumps as turbines: An unconventional solution to energy production.” Urban Water 1 (3): 261–263. https://doi.org/10.1016/S1462-0758(00)00016-9.
Ramos, H., and A. Borga. 2000. “Pumps yielding power.” Dam Eng. Water Power Dam Constr. 10 (4): 197–217.
Ramos, H., D. I. C. Covas, L. Araujo, and M. Mello. 2005. “Available energy assessment in water supply systems.” In Proc., XXXI IAHR Congress, 1050–1060. Seoul: International Association for Hydraulic Research, Korea Water Resources Association.
Ramos, H. M., M. Mello, and P. de. 2010. “Clean power in water supply systems as a sustainable solution: From planning to practical implementation.” Water Sci. Technol. Water Supply 10 (1): 39–49. https://doi.org/10.2166/ws.2010.720.
REDAWN (Reducing Energy Dependency in Atlantic Area Water Networks). 2016. “European regional development funds, Interreg Atlantic area programme 2014–2020.” EAPA 198-2016. Accessed July 1, 2016. https://www.redawn.eu.
Rothausen, S. G. S. A., and D. Conway. 2011. “Greenhouse-gas emissions from energy use in the water sector.” Nat. Clim. Change 1 (4): 210–219. https://doi.org/10.1038/nclimate1147.
Stoffel, B. 2015. Assessing the energy efficiency of pumps and pump units: Background and methodology. Amsterdam, Netherlands: Elsevier.
Tevar, A. D., H. M. Aelion, M. A. Stang, and J. Mendlovic. 2016. “The need for universal metrics in the energy-water-food nexus.” J. Environ. Stud. Sci. 6 (1): 225–230. https://doi.org/10.1007/s13412-016-0365-x.
Tucciarelli, T., A. Criminisi, and D. Termini. 1999. “Leak analysis in pipeline systems by means of optimal valve regulation.” J. Hydraul. Eng. 125 (3): 277–285. https://doi.org/10.1061/(ASCE)0733-9429(1999)125:3(277).
UN Water. 2019. “Climate change and water—UN-Water policy brief.” Accessed July 30, 2020. https://www.unwater.org/publications/un-water-policy-brief-on-climate-change-and-water/.
Virto property. 2020. “Utility costs in Spain 101: Electricity, gas and water supply explained | virtoproperty.com.” Accessed July 30, 2020. https://virtoproperty.com/info/utilities-in-spain-electricity-gas-water-costs.
Walski, T., W. Bezts, E. Posluzny, M. Weir, and B. E. Whitman. 2006. “Modelling leakage reduction through pressure control.” J. Am. Water Work Assoc. 98 (4): 147–155. https://doi.org/10.1002/j.1551-8833.2006.tb07642.x.
Wang, T., C. Wang, F. Kong, Q. Gou, and S. Yang. 2017. “Theoretical, experimental, and numerical study of special impeller used in turbine mode of centrifugal pump as turbine.” Energy 130 (Jul): 473–485. https://doi.org/10.1016/j.energy.2017.04.156.
Zakkour, P. D., M. R. Gaterell, P. Griffin, R. J. Gochin, and J. N. Lester. 2002. “Developing a sustainable energy strategy for a water utility. Part I: A review of the UK legislative framework.” J. Environ. Manage. 66 (2): 105–114. https://doi.org/10.1006/jema.2001.0549.
Zhang, C., X. Chen, Y. Li, W. Ding, and G. Fu. 2018. “Water-energy-food nexus: Concepts, questions and methodologies.” J. Cleaner Prod. 195 (Sep): 625–639. https://doi.org/10.1016/j.jclepro.2018.05.194.
Information & Authors
Information
Published In
Journal of Water Resources Planning and Management
Volume 148 • Issue 5 • May 2022
Copyright
© 2022 American Society of Civil Engineers.
History
Received: Aug 6, 2020
Accepted: Dec 21, 2021
Published online: Feb 25, 2022
Published in print: May 1, 2022
Discussion open until: Jul 25, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Esra Aleisa, Sara Al-Haddad, Optimizing the Nonconventional Water Supply across the Water-Energy-Food Nexus for Arid Regions Using a Life Cycle Assessment, Journal of Water Resources Planning and Management, 10.1061/JWRMD5.WRENG-6103, 150, 12, (2024).
- Zhe Cheng, Jialin He, Yun Li, Yixin Zhu, Juncheng Dai, Coupling-Coordinated Development of the Water-Economy-Innovation Nexus: A Case Study of the Grand Canal Area in China, Journal of Water Resources Planning and Management, 10.1061/JWRMD5.WRENG-6063, 149, 11, (2023).
- Francesco Pugliese, Maurizio Giugni, An Operative Framework for the Optimal Selection of Centrifugal Pumps As Turbines (PATs) in Water Distribution Networks (WDNs), Water, 10.3390/w14111785, 14, 11, (1785), (2022).
- Armando Carravetta, Giuseppe Del Giudice, Oreste Fecarotta, Maria Cristina Morani, Helena M. Ramos, A New Low-Cost Technology Based on Pump as Turbines for Energy Recovery in Peripheral Water Networks Branches, Water, 10.3390/w14101526, 14, 10, (1526), (2022).
- Oreste Fecarotta, Armando Carravetta, Maria Cristina Morani, The PAT Energy Booster, a New Device for the Energy Recovery and Hydraulic Control in Water Supply Systems: Preliminary Experimental Tests, EWaS5, 10.3390/environsciproc2022021003, (3), (2022).