Potential of Energy Recovery and Water Saving Using Micro-Hydropower in Rural Water Distribution Networks
Publication: Journal of Water Resources Planning and Management
Volume 145, Issue 3
Abstract
Water distribution networks have a significant water and energy demand and, therefore, must face the challenge of adopting measures that improve how these resources are used. Previous investigations have demonstrated the potential of micro-hydropower energy recovery in reducing both energy consumption and water leakage in urban water supply networks. In this work, the potential of hydropower energy recovery combined with leakage reduction has been evaluated in eight rural water distribution networks in Ireland. Two scenarios were evaluated. Scenario 1 consisted of replacing the devices currently being used to reduce pressure with a pump as turbine (PAT). In Scenario 2, potential new locations were proposed for existing sites with excess pressure, according to the flow and elevation of the network. The hydropower generated and leakage reduction due to lower pressure at the nodes were both estimated. The results showed that the estimated hydropower could reduce the net energy demand by 21% in Scenario 1 and by up to 23% in Scenario 2 in some of the networks. However, in many of the networks the amount of energy recoverable was low due to the relatively low water demand in these rural settings. In Scenario 1 three out of the eight rural water networks were found to have economically viable micro-hydropower sites. However, in Scenario 2 the significant water savings achieved as a consequence of leakage reduction made the installation of PATs feasible in all the networks evaluated. The results of this investigation highlight that while energy recovery using micro-hydropower in rural water supply networks produces only modest amounts of power in comparison with urban settings, this power can contribute significantly as a proportion of local energy demand. In addition, combining water savings with energy production greatly improves the economic viability of these micro-hydropower installations.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study was partially funded by the European Regional Development Fund (ERDF) Interreg Ireland–Wales program 2014–2020 through the Distributing Our Water Resources: Utilising Integrated, Smart and Low-Carbon Energy (Dwr Uisce) project. The case study assessments were made possible by the data provided by the National Federation of Group Water Schemes in Ireland and the eight CORWSNs mentioned.
References
Alkasseh, J. M. A., M. N. Adlan, I. Abustan, H. A. Aziz, and A. B. M. Hanif. 2013. “Applying minimum night flow to estimate water loss using statistical modeling: A case study in Kinta valley, Malaysia.” Water Resour. Manage. 27 (5): 1439–1455. https://doi.org/10.1007/s11269-012-0247-2.
Araujo, L. S., H. Ramos, and S. T. Coelho. 2003. “Estimation of distributed pressure-dependent leakage and consumer demand in water supply networks.” In Advance in water supply management. London: CRC Press.
Araujo, L. S., H. Ramos, and S. T. Coelho. 2006. “Pressure control for leakage minimisation in water distribution systems management.” Water Resour. Manage. 20 (1–2): 133–149. https://doi.org/10.1007/s11269-006-4635-3.
Blinco, L. J., A. R. Simpson, M. F. Lambert, C. A. Auricht, N. E. Hurr, S. M. Tiggemann, and A. Marchi. 2014. “Genetic algorithm optimization of operational costs and greenhouse gas emissions for water distribution systems.” Procedia Eng. 89: 509–516. https://doi.org/10.1016/j.proeng.2014.11.246.
Carravetta, A., G. Del Giudice, O. Fecarotta, and H. M. Ramos. 2012. “Energy production in water distribution networks: A PAT design strategy.” Water Resour. Manage. 26 (13): 3947–3959. https://doi.org/10.1007/s11269-012-0114-1.
Carravetta, A., G. del Giudice, O. Fecarotta, and H. M. Ramos. 2013. “PAT design strategy for energy recovery in water distribution networks by electrical regulation.” Energies 6 (1): 411–424. https://doi.org/10.3390/en6010411.
Carravetta, A., S. Derakhshan Houreh, and H. M. Ramos. 2018. Application of PAT technology, 189–218. New York: Springer.
Carravetta, A., O. Fecarotta, M. Sinagra, and T. Tucciarelli. 2014. “Cost-benefit analysis for hydropower production in water distribution networks by a pump as turbine.” J. Water Resour. Plann. Manage. 140 (6): 04014002. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000384.
Deb, K., A. Pratap, S. Agarwal, and T. Meyarivan. 2002. “A fast and elitist multiobjective genetic algorithm: NSGA-II.” IEEE Trans. Evol. Comput. 6 (2): 182–197. https://doi.org/10.1109/4235.996017.
Enerdata. 2017. “World energy consumption statistics.” Global Energy Statistical Yearbook 2017. Accessed February 14, 2018. https://yearbook.enerdata.net/total-energy/world-consumption-statistics.html.
European Commission. 2018. Proposal for a directive of the European Parliament and of the Council on the quality of water intended for human consumption (recast). Brussels, Belgium: European Commission.
Fecarotta, O., C. Aricò, A. Carravetta, R. Martino, and H. M. Ramos. 2015. “Hydropower potential in water distribution networks: Pressure control by PATs.” Water Resour. Manage. 29 (3): 699–714. https://doi.org/10.1007/s11269-014-0836-3.
Fecarotta, O., and A. McNabola. 2017. “Optimal location of pump as turbines (PATs) in water distribution networks to recover energy and reduce leakage.” Water Resour. Manage. 31 (15): 5043–5059. https://doi.org/10.1007/s11269-017-1795-2.
Fontana, N., M. Giugni, L. Glielmo, G. Marini, and R. Zollo. 2018. “Real-time control of pressure for leakage reduction in water distribution network: Field experiments.” J. Water Resour. Plann. Manage. 144 (3): 04017096. https://doi.org/10.1061/(ASCE)WR.1943-5452.0000887.
Gallagher, J., I. M. Harris, A. J. Packwood, A. McNabola, and A. P. Williams. 2015. “A strategic assessment of micro-hydropower in the UK and Irish water industry: Identifying technical and economic constraints.” Renewable Energy 81: 808–815. https://doi.org/10.1016/j.renene.2015.03.078.
Goldberg, D. E. 1989. Genetic algorithms in search, optimization, and machine learning. Boston: Addison-Wesley Longman.
IEA (International Energy Agency). 2016. “Water energy nexus—Excerpt from the world energy outlook 2016.” International Energy Agency, France. Accessed January 22, 2018. https://www.iea.org/publications/freepublications/publication/WorldEnergyOutlook2016ExcerptWaterEnergyNexus.pdf.
Lydon, T., P. Coughlan, and A. McNabola. 2017. “Pressure management and energy recovery in water distribution networks: Development of design and selection methodologies using three pump-as-turbine case studies.” Renewable Energy 114: 1038–1050. https://doi.org/10.1016/j.renene.2017.07.120.
Marchi, A., A. R. Simpson, and M. F. Lambert. 2017. “Pump operation optimization using rule-based controls.” Procedia Eng. 186: 210–217. https://doi.org/10.1016/j.proeng.2017.03.229.
McNabola, A., P. Coughlan, L. Corcoran, C. Power, A. Prysor Williams, I. Harris, J. Gallagher, and D. Styles. 2014a. “Energy recovery in the water industry using micro-hydropower: An opportunity to improve sustainability.” Water Policy 16 (1): 168–183. https://doi.org/10.2166/wp.2013.164.
McNabola, A., P. Coughlan, and A. P. Williams. 2014b. “Energy recovery in the water industry: An assessment of the potential of micro-hydropower.” Water Environ. J. 28 (2): 294–304. https://doi.org/10.1111/wej.12046.
Meirelles, G., E. Luvizotto, and B. M. Brentan. 2017. “Selection of pumps as turbines substituting pressure reducing valves.” Renewable Energy 109: 392–405. https://doi.org/10.1016/j.renene.2017.03.056.
NFGWS (National Federation of Group Water Schemes). 2016. “National federation of group water schemes: Annual report 2016.” Accessed January 23, 2018. http://www.nfgws.ie/f//2016%20Annual%20Report.pdf.
Novara, D., A. Carravetta, S. Derakhshan, A. McNabola, and H. M. Ramos. 2017. “A cost model for pumps as turbines and a comparison of design strategies for their use as energy recovery devices in water supply systems.” In Proc., 10th Int. Conf. on Energy Efficiency in Motor Driven Systems (EEMODS), 1–8. Rome.
Novara, D., and A. McNabola. 2018. “A model for the extrapolation of the characteristic curves of pumps as turbines from a datum best efficiency point.” Energy Convers. Manage. 174: 1–7. https://doi.org/10.1016/j.enconman.2018.07.091.
Pratap, R. 2010. Getting started with Matlab: A quick introduction for scientist and engineers. New York: Oxford University Press.
Power, C., P. Coughlan, and A. McNabola. 2017. “Microhydropower energy recovery at wastewater-treatment plants: Turbine selection and optimization.” J. Energy Eng. 143 (1): 04016036. https://doi.org/10.1061/(ASCE)EY.1943-7897.0000383.
Ramos, H., and A. Borga. 1999. “Pumps as turbines: An unconventional solution to energy production.” Urban Water 1 (3): 261–263. https://doi.org/10.1016/S1462-0758(00)00016-9.
Rossman, L. 2000. EPANET 2: Users manual. Washington, DC: USEPA.
Sammartano, V., M. Sinagra, P. Filianoti, and T. Tucciarelli. 2017. “A Banki-Michell turbine for in-line water supply systems.” J. Hydraul. Res. 55 (5): 686–694. https://doi.org/10.1080/00221686.2017.1335246.
Samora, I., P. Manso, M. Franca, A. Schleiss, and H. Ramos. 2016. “Energy recovery using micro-hydropower technology in water supply systems: The case study of the city of Fribourg.” Water 8 (8): 344. https://doi.org/10.3390/w8080344.
SEAI (Sustainable Energy Authority of Ireland). 2017. “Electricity and gas prices in Ireland: 1st Semester (January–June) 2017.” Sustainable Energy Authority of Ireland. Accessed May 10, 2018. https://www.seai.ie/resources/publications/Electricity_Gas_Prices_January_June_2017.
Sinagra, M., V. Sammartano, G. Morreale, and T. Tucciarelli. 2017. “A new device for pressure control and energy recovery in water distribution networks.” Water 9 (5): 309. https://doi.org/10.3390/w9050309.
Tricarico, C., M. S. Morley, R. Gargano, Z. Kapelan, D. Savić, S. Santopietro, F. Granata, and G. de Marinis. 2018. “Optimal energy recovery by means of pumps as turbines (PATs) for improved WDS management.” Water Sci. Technol. Water Supply 18 (4): 1365–1374. https://doi.org/10.2166/ws.2017.202.
United Nations. 2015. Transforming our world: The 2030 agenda for sustainable development. New York: United Nations.
Yang, S.-S., S. Derakhshan, and F.-Y. Kong. 2012. “Theoretical, numerical and experimental prediction of pump as turbine performance.” Renewable Energy 48: 507–513. https://doi.org/10.1016/j.renene.2012.06.002.
Information & Authors
Information
Published In
Journal of Water Resources Planning and Management
Volume 145 • Issue 3 • March 2019
Copyright
©2019 American Society of Civil Engineers.
History
Received: Mar 13, 2018
Accepted: Sep 7, 2018
Published online: Jan 2, 2019
Published in print: Mar 1, 2019
Discussion open until: Jun 2, 2019
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.