Response and Modeling of Steel Tubes Filled with Recycled Fine and Coarse Aggregate Concretes under Long-Term Loading
Publication: Journal of Structural Engineering
Volume 147, Issue 11
Abstract
The engineering properties of concrete with recycled aggregates (RAC) can vary more widely than normal aggregate concretes (NAC). Because concrete-filled steel tubes do not rely solely on the concrete in compression, using RAC in a concrete-filled steel tube (RACFST) is a sustainable structural solution. Most work has focused on using only coarse recycled aggregate (CRA), but with virgin sand supplies decreasing, there is a need to use fine recycled aggregate (FRA). Meanwhile, the long-term deformation of RACFST may be notably affected by FRA. A research program was undertaken to investigate the impact of FRA on the time-dependent behavior for the RACFST. Study parameters included CRA replacement ratio (), FRA replacement ratio (), and concrete strength (). The experimental results showed that the FRA and CRA had a modest compounding effect (i.e., the FRA effect depends on ) in RACFST, but this effect can be more pronounced for lower-strength concretes. Using RAC increases the scatter in the deformability but does not affect the rate of creep development. A creep model for NAC was then modified to predict the long-term deformation of RACFST. A parametric study was carried out to evaluate the time-dependent effects of the RACFST with other untested parameters.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
Data are available upon request from the authors. Some or all data, models, or code that support the findings of this study are available from the corresponding author upon reasonable request.
Acknowledgments
The authors acknowledge the National Key R&D Program of China (2018YFC0705700); the research work in this paper was supported by the National Natural Science Foundation of China (No. 51708158).
References
Abbas, A., G. Fathifazl, O. B. Isgor, A. G. Razaqpur, B. Fournier, and S. Foo. 2008. “Proposed method for determining the residual mortar content of re-cycled concrete aggregates.” J. ASTM Int. 5 (1): 1–12.
Bai, G., H. Qi, and C. Liu. 2016. “Study on creep test and prediction model of recycled aggregate concrete.” [In Chinese.] Supplement, J. Build. Struct. 37 (S2): 121–126.
Bravo, M., J. Pontes, J. Brito, and L. Evangelista. 2017. “Shrinkage and creep performance of concrete with recycled aggregates from CDW plants.” Mag. Concr. Res. 69 (19): 974–995. https://doi.org/10.1680/jmacr.17.00031.
Brito, J., and R. Robles. 2010. “Recycled aggregate concrete (RAC) methodology for estimating its long-term properties.” Indian J. Eng. Mater. Sci. 17 (6): 449–462.
BSI (British Standard Institution). 2001. Metallic materials-Tensile testing. Part 1: Method of test at ambient temperature. BS EN 10002-1:2001. London: BSI.
BSI (British Standard Institution). 2002a. Concrete-complementary British Standard to BS EN 206-1. Part 2: Specification for constituent materials and concrete. BS 8500-2. London: BSI.
BSI (British Standard Institution). 2002b. Specification for aggregates from natural sources for concrete. BS 882:1992. London: BSI.
BSI (British Standards Institution). 2004. Eurocode 2: Design of concrete structures. Part 1-1: General rules and rules for buildings. BS EN 1992. London: BSI.
BSI (British Standards Institution). 2012. BS EN 933-1:2012: Tests for geometrical properties of aggregates. Part 1: Determination of particle size distribution–sieving method. BS EN 933-1:2012. London: BSI.
CEB (Comité Euro-International du Béton). 1984. CEB design manual on structural effects of time-dependent behaviour of concrete. Edited by M. A. Chiorino, P. Napoli, F. Mola, and M. Koprna. Saint-Saphorin, Switzerland: Georgi.
CEB-FIP (Comité Euro-International du Béton/Federation Internationale de la Pre-Contrainte). 2013. CEB-FIP model code 2010. London: Thomas Telford.
Choi, W. C., and H. D. Yun. 2012. “Compressive behavior of reinforced concrete columns with recycled aggregate under uniaxial loading.” Eng. Struct. 41 (8): 285–293. https://doi.org/10.1016/j.engstruct.2012.03.037.
Domingo-Cabo, A., C. Lázaro, F. López-Gayarre, M. A. Serrano-López, P. Serna, and J. O. Castaño-Tabares. 2009. “Creep and shrinkage of recycled aggregate concrete.” Constr. Build. Mater. 23 (7): 2545–2553. https://doi.org/10.1016/j.conbuildmat.2009.02.018.
Evangelista, L., M. Guedes, J. Brito, A. C. Ferro, and M. F. Pereira. 2015. “Physical, chemical and mineralogical properties of fine recycled aggregates made from concrete waste.” Constr. Build. Mater. 86 (Jul): 178–188. https://doi.org/10.1016/j.conbuildmat.2015.03.112.
Fan, Y. H., J. Z. Xiao, and V. W. Y. Tam. 2014. “Effect of old attached mortar on the creep of recycled aggregate concrete.” Struct. Concr. 15 (2): 169–178. https://doi.org/10.1002/suco.201300055.
Fathifazl, G., A. G. Ghani Razaqpur, O. B. Isgor, A. Abbas, B. Fournier, and S. Foo. 2011. “Creep and drying shrinkage characteristics of concrete produced with coarse recycled concrete aggregate.” Cem. Concr. Compos. 33 (10): 1026–1037. https://doi.org/10.1016/j.cemconcomp.2011.08.004.
Fathifazl, G., and A. G. Razaqpur. 2013. “Creep rheological models for recycled aggregate concrete.” ACI Mater. J. 110 (2): 115–126.
Geng, Y., Y. Y. Wang, and J. Chen. 2015. “Time-dependent behavior of recycled aggregate concrete-filled steel tubular columns.” J. Struct. Eng. 141 (10): 04015011. https://doi.org/10.1061/(ASCE)ST.1943-541X.0001241.
Geng, Y., Y. Y. Wang, and J. Chen. 2016a. “Creep behaviour of concrete using recycled coarse aggregates obtained from source concrete with different strengths.” Constr. Build. Mater. 128 (Dec): 199–213. https://doi.org/10.1016/j.conbuildmat.2016.10.086.
Geng, Y., Y. Y. Wang, and J. Chen. 2016b. “Time-dependent behaviour of steel tubular columns filled with recycled coarse aggregate concrete.” J. Constr. Steel Res. 122 (Jul): 455–468. https://doi.org/10.1016/j.jcsr.2016.04.009.
Geng, Y., Y. Y. Wang, J. Chen, and M. Z. Zhao. 2020. “Time-dependent behaviour of 100% recycled coarse aggregate concrete filled steel tubes subjected to high sustained load level.” Eng. Struct. 210 (May): 110353. https://doi.org/10.1016/j.engstruct.2020.110353.
Geng, Y., M. Z. Zhao, H. Yang, and Y. Y. Wang. 2019. “Creep model of concrete with recycled coarse and fine aggregates that accounts for creep development trend difference between recycled and natural aggregate concrete.” Cem. Concr. Compos. 103 (Oct): 303–317. https://doi.org/10.1016/j.cemconcomp.2019.05.013.
Gilbert, R. I., and G. Ranzi. 2010. Time-dependent behaviour of concrete structures. London: Taylor and Francis.
Gómez Soberón, J. M. V. 2002. “Creep of concrete with substitution of normal aggregate by recycled concrete aggregate.” ACI Spec. Publ. 209 (Sep): 461–474.
Jiang, Y. L., H. M. Tang, and J. Chen. 2019. “Review of China’s sand and gravel market in 2019 and prospect in 2020.” Accessed June 27, 2021. https://www.100njz.com/19/1224/14/3E39ED5FAA5C0106.html.
Kim, S. W., and H. D. Yun. 2013. “Influence of recycled coarse aggregates on the bond behavior of deformed bars in concrete.” Eng. Struct. 48 (3): 133–143. https://doi.org/10.1016/j.engstruct.2012.10.009.
Lehman, D. E., K. G. Kuder, A. K. Gunnarrson, C. W. Roeder, and J. W. Berman. 2015. “Circular concrete-filled tubes for improved sustainability and seismic resilience.” J. Struct. Eng. 141 (3): B4014008. https://doi.org/10.1061/(ASCE)ST.1943-541X.0001103.
Limbachiya, M. C., T. Leelawat, and R. K. Dhir. 2000. “Use of recycled concrete aggregate in high-strength concrete.” Mater. Struct. 33 (9): 574–580. https://doi.org/10.1007/BF02480538.
Luo, S., H. Huang, and J. Zheng. 2016. “Experimental study on creep property of recycled aggregate concrete.” [In Chinese.] Supplement, J. Build. Struct. 37 (S2): 115–120.
Manzi, S., C. Mazzotti, and M. C. Bignozzi. 2013. “Short and long-term behavior of structural concrete with recycled concrete aggregate.” Cem. Concr. Compos. 37 (Mar): 312–318. https://doi.org/10.1016/j.cemconcomp.2013.01.003.
Manzi, S., C. Mazzotti, and M. C. Bignozzi. 2017. “Self-compacting concrete with recycled concrete aggregate: Study of the long-term properties.” Constr. Build. Mater. 157 (Dec): 582–590. https://doi.org/10.1016/j.conbuildmat.2017.09.129.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2002. Standard for test method of performance on ordinary fresh concrete. [In Chinese.] GB/T 50080-2002. Beijing: China Architecture & Building Press.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2006. Standard for technical requirements and test method of sand and crushed stone (or gravel) for ordinary concrete. [In Chinese.] JGJ 52-2006. Beijing: China Architecture & Building Press.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2010. Code for design of concrete structures. [In Chinese.] GB 50010-2010. Beijing: Architecture and Building.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2011a. Pebble and crushed stone for construction. [In Chinese.] GB/T 14685-2011. Beijing: China Architecture & Building Press.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2011b. Sand for construction. [In Chinese.] GB/T 14684-2011. Beijing: China Architecture & Building Press.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2011c. Technical specification for application of recycled aggregate. [In Chinese.] JGJ/T 240-2011. Beijing: China Architecture & Building Press.
MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China). 2019. Standard for test methods of concrete physical and mechanical properties. [In Chinese.] GB/T 50081-2019. Beijing: China Architecture & Building Press.
Neville, A. M. 2011. Properties of concrete. New York: Pearson.
Pedro, D., J. Brito, and L. Evangelista. 2017. “Structural concrete with simultaneous incorporation of fine and coarse recycled concrete aggregates: Mechanical, durability and long-term properties.” Constr. Build. Mater. 154 (Nov): 294–309. https://doi.org/10.1016/j.conbuildmat.2017.07.215.
Pereira, P., L. Evangelista, and J. Brito. 2012. “The effect of supersplasticisers on the workability and compressive strength of concrete made with fine recycled concrete aggregates.” Constr. Build. Mater. 28 (1): 722–729. https://doi.org/10.1016/j.conbuildmat.2011.10.050.
Seara-Paz, S., B. González-Fonteboa, F. Martínez-Abella, and I. González-Taboada. 2016. “Time-dependent behaviour of structural concrete made with recycled coarse aggregates. Creep and shrinkage.” Constr. Build. Mater. 122 (Sep): 95–109. https://doi.org/10.1016/j.conbuildmat.2016.06.050.
Silva, R. V., J. Brito, and R. K. Dhir. 2016. “Establishing a relationship between modulus of elasticity and compressive strength of recycled aggregate concrete.” J. Cleaner Prod. 112 (Jan): 2171–2186. https://doi.org/10.1016/j.jclepro.2015.10.064.
Sri Ravindrarajah, R., and C. T. Tam. 1985. “Properties of concrete made with crushed concrete as coarse aggregate.” Mag. Concr. Res. 37 (130): 29–38. https://doi.org/10.1680/macr.1985.37.130.29.
Tam, V. W. Y., D. Kotrayothar, and J. Z. Xiao. 2015. “Long-term deformation behaviour of recycled aggregate concrete.” Constr. Build. Mater. 100 (Dec): 262–272. https://doi.org/10.1016/j.conbuildmat.2015.10.013.
Wang, Y. Y., J. Chen, and Y. Geng. 2015. “Testing and analysis of axially loaded normal-strength recycled aggregate concrete filled steel tubular stub columns.” Eng. Struct. 86 (Mar): 192–212. https://doi.org/10.1016/j.engstruct.2015.01.007.
Wang, Y. Y., P. Chen, C. Y. Liu, and Y. Zhang. 2017. “Size effect of circular concrete-filled steel tubular short columns subjected to axial compression.” Thin Walled Struct. 120 (Nov): 397–407. https://doi.org/10.1016/j.tws.2017.09.010.
Wang, Y. Y., Y. Geng, Y. C. Chang, and C. J. Zhou. 2018. “Time-dependent behaviour of recycled concrete filled steel tubes using RCA from different parent waste material.” Constr. Build. Mater. 193 (Dec): 230–243. https://doi.org/10.1016/j.conbuildmat.2018.10.201.
Wang, Y. Y., Y. Geng, J. Chen, and M. Z. Zhao. 2019a. “Testing and analysis on nonlinear creep behaviour of concrete-filled steel tubes with circular cross-section.” Eng. Struct. 185 (Apr): 26–46. https://doi.org/10.1016/j.engstruct.2019.01.065.
Wang, Y. Y., Y. Geng, G. Ranzi, and S. M. Zhang. 2011. “Time-dependent behaviour of expansive concrete filled steel tubular columns.” J. Constr. Steel Res. 67 (3): 471–483. https://doi.org/10.1016/j.jcsr.2010.09.007.
Wang, Y. Y., H. Zhang, Y. Geng, Q. H. Wang, and S. M. Zhang. 2019b. “Prediction of the elastic modulus and the splitting tensile strength of concrete incorporation both fine and coarse recycled aggregate.” Constr. Build. Mater. 215 (Aug): 332–346. https://doi.org/10.1016/j.conbuildmat.2019.04.212.
Yang, Y. F. 2011. “Behaviour of recycled aggregate concrete-filled steel tubular columns under long-term sustained loads.” Adv. Struct. Eng. 14 (2): 189–206. https://doi.org/10.1260/1369-4332.14.2.189.
Yang, Y. F., and L. H. Han. 2006. “Compressive and flexural behaviour of recycled aggregate concrete filled steel tubes (RACFST) under short-term loadings.” Steel. Compos. Struct. 6 (3): 257–284. https://doi.org/10.12989/scs.2006.6.3.257.
Yang, Y. F., L. H. Han, and X. Wu. 2008. “Concrete shrinkage and creep in recycled aggregate concrete-filled steel tubes.” Adv. Struct. Eng. 11 (4): 383–396. https://doi.org/10.1260/136943308785836772.
Yang, Y. F., and G. L. Ma. 2013. “Experimental behaviour of recycled aggregate concrete filled stainless steel tube stub columns and beams.” Thin Walled Struct. 66 (May): 62–75. https://doi.org/10.1016/j.tws.2013.01.017.
Zhang, H., Y. Y. Wang, D. E. Lehman, and Y. Geng. 2020a. “Autogenous-shrinkage model for concrete with coarse and fine recycled aggregate.” Cem. Concr. Compos. 111 (Aug): 103600. https://doi.org/10.1016/j.cemconcomp.2020.103600.
Zhang, H., Y. Y. Wang, D. E. Lehman, Y. Geng, and K. Kuder. 2020b. “Time-dependent drying shrinkage model for concrete with coarse and fine recycled aggregate.” Cem. Concr. Compos. 105 (Jan): 103426. https://doi.org/10.1016/j.cemconcomp.2019.103426.
Information & Authors
Information
Published In
Copyright
© 2021 American Society of Civil Engineers.
History
Received: Jan 21, 2021
Accepted: May 10, 2021
Published online: Aug 17, 2021
Published in print: Nov 1, 2021
Discussion open until: Jan 17, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Wisal Ahmed, C. W. Lim, Effective Utilization of Chopped Basalt Fiber and Pozzolana Slurry TRCA for Sustainable Recycled Structural Concrete with Improved Fire Resistance, Journal of Materials in Civil Engineering, 10.1061/(ASCE)MT.1943-5533.0004613, 35, 3, (2023).
- Huan Zhang, Yue Geng, Yu-Yin Wang, Xiao-Zhong Li, Experimental study and prediction model for bond behaviour of steel-recycled aggregate concrete composite slabs, Journal of Building Engineering, 10.1016/j.jobe.2022.104585, 53, (104585), (2022).