Monotonic Behavior of Reinforced Concrete Columns Confined with High-Performance Ferrocement
Publication: Journal of Structural Engineering
Volume 139, Issue 4
Abstract
In this study, a method of strengthening circular columns using high-performance ferrocement (HPF) is proposed. This is achieved by replacing the concrete cover by HPF (i.e., comprising rendering material and wire mesh). Direct tensile tests were carried out on HPF specimens. For rendering material with high tensile strength, it is necessary to incorporate its tensile strength in the estimation of the tensile strength of HPF. Nineteen full-scale circular plain or RC columns were tested under monotonic compression. Eleven were detailed with a volumetric ratio of transverse reinforcement at 0.230%. HPF, having three different rendering materials and with one or three layers of wire mesh, was used to confine eight of these columns. Test variables included volume fraction of wire mesh and tensile strength of rendering material. Plain-concrete columns strengthened with HPF have peak strengths at 30–59% higher than control specimens. RC columns having a low at 0.230% and strengthened with HPF can achieve peak strengths comparable with columns having a high at 0.918%. A set of empirical equations for predicting the peak strength of plain-concrete or RC columns strengthened with HPF is derived, showing good agreement with the test data. Lastly, a design procedure for strengthening a RC column by replacing the concrete cover using HPF is proposed.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors are grateful to the financial support from the Hong Kong Polytechnic University and the Research Grants Council of Hong Kong (RGC No. PolyU 5206/08E). The authors thank the Heavy Structure Laboratory of the Department of Civil and Environmental Engineering, Hong Kong Polytechnic University, for conducting the experiments.
References
Abdullah and Takiguchi, K. (2003). “An investigation into the behavior and strength of reinforced concrete columns strengthened with ferrocement jackets.” Cement Concr. Compos., 25(2), 233–242.
Ahmad, S. M., and Shah, S. P. (1982). “Stress-strain curves of concrete confined by spiral reinforcement.” ACI J., 79(6), 484–490.
American Cement Institute (ACI) Committee 549. (1993). “Guide for the design, construction, and repair of ferrocement.” ACI 549.1R-93, Detroit.
Bu, L. T. (2007). New technology on strengthening reinforced concrete structures using high performance ferrocement, China Architecture and Building Press, Beijing (in Chinese).
Building Authority of Hong Kong. (1987). Code of practice for structural use of concrete 1987, Building Authority of Hong Kong, Kowloon, Hong Kong.
China Association for Engineering Construction Standardization. (2008). “Technical specification for strengthening concrete structures with grid rebar and mortar.” CECS 242:2008, China Association for Engineering Construction Standardization, Beijing (in Chinese).
Ganesan, N., and Anil, J. (1993). “Strength and behavior of RC columns confined by ferrocement.” J. Ferrocement, 23(2), 99–108.
Government of the Hong Kong Special Administrative Region. (2004). Code of practice for structural use of concrete 2004, 2nd Ed., Government of the Hong Kong Special Administrative Region, Hong Kong.
Ho, I. F. Y., and Lam, E. S. S. (2011). “Axial load carrying capacity of circular reinforced concretecolumns.” Proc., 5th Cross-strait Conf. on Structural and Geotechnical Engineering (SGE-5), Hong Kong.
Hoshikuma, J., Kawashima, K., Nagaya, K., and Taylor, A. W. (1997). “Stress-strain model for confined reinforced concrete in bridge piers.” J. Struct. Eng., 123(5), 624–633.
Ilki, A., Kumbasar, N., Ozdemir, P., and Fukuta, T. (2004). “A trilinear stress-strain model for confined concrete.” Struct. Eng. Mech., 18(5), 541–563.
Jiang, L., and Cao, H. (2011). “Study on the axially compressed behavior of RC square columns strengthened by high performance ferrocement laminates.” 2011 Int. Conf. on Consumer Electronics, Communications and Networks (CECNet), IEEE, New York, 3620–3624 (in Chinese).
Jiang, L., and Liu, F. (2011). “Research on the axially compressed behavior of RC columns strengthened by high performance ferrocement laminates.” Proc., Consumer Electronics, Communications and Networks (CECNet), IEEE, New York, 4396–4400 (in Chinese).
Jiang, L., Shang, S., and Liu, F. (2009). “Research on axially compressed behavior of RC strengthening round columns using high performance composite cement mortar reinforced with mesh reinforcements.” J. Hunan Univ. Technol., 23(1), 12–18 (in Chinese).
Kazemi, M. T., and Morshed, R. (2005). “Seismic shear strengthening of R/C columns with ferrocement jacket.” Cement Concr. Compos., 27(7–8), 834–842.
Kim, S. H., and Choi, J. H. (2010). “Repair of earthquake damaged RC columns with stainless steel wire mesh composite.” Adv. Struct. Eng., 13(2), 393–402.
Kondraivendhan, B., and Pradhan, B. (2009). “Effect of ferrocement on behavior of concrete.” Construct. Build. Mater., 23(3), 1218–1222.
Kumar, P. R., Oshima, T., and Mikami, S. (2004). “Ferrocement confinement of plain and reinforced concrete.” Prog. Struct. Eng. Mater., 6(4), 241–251.
Kumar, P. R., Oshima, T., Mikami, S., and Yamazaki, T. (2007). “Studies on RC and ferrocement jacketed columns subjected to simulated seismic loading.” Asian J. Civil Eng. (Building and Housing), 8(2), 215–225.
Li, B. (1994). “Strength and ductility of reinforced concrete members and frames constructed using high strength concrete.” Research Rep. 94-5, Dept. of Civil Engineering, Univ. of Canterbury, Christchurch, New Zealand.
Mander, J. B., Priestley, M. J. N., and Park, R. (1988a). “Theoretical stress strain model of confined concrete.” J. Struct. Eng., 114(8), 1804–1826.
Mander, J. B., Priestley, M. J. N., and Park, R. (1988b). “Observed stress strain behavior of confined concrete.” J. Struct. Eng., 114(8), 1827–1849.
Matthys, S., Toutanji, H., and Taerwe, L. (2006). “Stress-strain behavior of large-scale circular columns confined with FRP composites.” J. Struct. Eng., 132(1), 123–133.
Mourad, S. E. M. (2006). “Performance of plain concrete specimens externally confined with welded wire fabric.” Final Research Rep. No. 47/426, King Saud Univ. College of Engineering Riyadh, Kingdom of Saudi Arabia.
Naaman, A. E. (2000). Ferrocement and laminated cementitious composites. Techno Press 3000, Ann Arbor, MI.
Park, R., Priestly, M. J. N., and Gill, W. D. (1982). “Ductility of square confined concrete columns.” J. Struct. Div., 108(4), 929–951.
Pessiki, S., and Pieroni, A. (1997). “Axial load behavior of large scale spirally reinforced high strength concrete column.” ACI Struct. J., 94(3), 304–314.
Rajasekaran, A., Raghunath, P. N., and Suguna, K. (2008). “Effect of confinement on the axial performance of fiber reinforced polymer wrapping RC column.” Am. J. Eng. Appl. Sci., 1(2), 110–117.
Shah, S. P., Lub, K. B., and Ronzoni, E. (1986). “A summary of ferrocement construction and a survey of its durability. RILEM Committee 48-FC.” Mater. Struct., 19(4), 297–321.
Sharma, U. K., Bhargava, P., and Kaushik, S. K. (2005). “Behavior of confined high strength concrete columns under axial compression.” J. Adv. Concrete Techn., 3(2), 267–281.
Sheikh, S. A., and Toklucu, M. T. (1993). “Reinforced concrete columns confined by circular spirals and hoops.” ACI Struct. J., 90(5), 542–553.
Sheikh, S. A., and Uzumeri, S. M. (1980). “Strength and ductility of tied concrete columns.” J. Struct. Div., 106(5), 1079–1102.
Xiong, G. J., Wu, X. Y., Li, F. F., and Yan, Z. (2011). “Load carrying capacity and ductility of circular concrete columns confined by ferrocement including steel bars.” Construct. Build. Mater., 25(5), 2263–2268.
Information & Authors
Information
Published In
Copyright
© 2013 American Society of Civil Engineers.
History
Received: Sep 25, 2011
Accepted: Jul 24, 2012
Published online: Mar 15, 2013
Published in print: Apr 1, 2013
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.