Technical Challenges and Design Features of the 247-m DaShiXia Concrete-Faced Sand-Gravel Dam
Publication: Practice Periodical on Structural Design and Construction
Volume 27, Issue 1
Abstract
The 247-m DaShiXia (DSX) concrete-faced sand-gravel dam (CFSGD) is currently the highest structure of its type under construction in the world. By reviewing the specific conditions of this dam and common problems that have occurred in other comparable cases, this paper analyzes the technical issues that undermine the safety of the dam. Measures for controlling dam deformation and seepage, improving its aseismic performance, and reinforcing its concrete slabs are explained with the aid of experimental and numerical results and previous experience. The results of the analysis demonstrate that the deformation of the dam under static and dynamic loads is within the range of existing successful cases, thus providing fundamental confidence that the design is feasible. The use of L-shaped drainage within the dam is emphasized because of the vulnerability of sand and gravel material to seepage erosion, uncertainties in the results obtained from laboratory seepage tests, and the need to lower the phreatic surface. Numerical results show that the acceleration response is strong within the upper 4/5 part of the dam, which leads to confined aseismic measures within this particular portion. Reinforcing schemes for concrete-faced slabs and their joints are outlined, and some special design features, including the use of a high toe retaining wall, a stepwise toe plinth, and a deep empty tunnel in this dam, are also explained. The measures adopted are expected to result in acceptable performance of the dam and its impermeable system.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
The three-dimensional finite-element model of the DSX CFSGD and the source code for the constitutive models that were used in this study are available from the corresponding author upon reasonable request.
Acknowledgments
This work is supported by the National Key Research and Development Program of China (No. 2017YFC0404806) and the National Natural Science Foundation of China (Nos. 51779152 and U1765203).
References
Bolzon, G., D. Sterpi, G. Mazzà, and A. Frigerio. 2020. “Numerical analysis of dams.” In Proc., 15th ICOLD Int. Benchmark Workshop. Berlin: Springer.
Cao, K. M., Y. S. Wang, J. J. Xu, and S. H. Liu. 2008. Concrete face rockfill dam. Beijing: China Water Power Press.
Chen, S. S., Z. Z. Fu, B. X. Shi, and J. Yuan. 2019a. “Elastoplasticity constitutive model considering loading-induced deformation and creep behavior of coarse granular soils and its application.” Chin. J. Geotech. Eng. 41 (4): 601–609. https://doi.org/10.11779/CJGE201904001.
Chen, S. S., Z. Z. Fu, K. M. Wei, and H. Q. Han. 2016. “Seismic responses of high concrete face rockfill dams: A case study.” Water Sci. Eng. 9 (3): 195–204. https://doi.org/10.1016/j.wse.2016.09.002.
Chen, S. S., J. P. Huo, and W. M. Zhang. 2008. “Analysis of effects of ‘5.12’ Wenchuan earthquake on Zipingpu concrete face rock-fill dam.” Chin. J. Geotech. Eng. 30 (6): 795–801.
Chen, S. S., H. Ling, Z. K. Mi, Z. Miao, and S. A. Mei. 2019b. “Experimental study on permeability and its influencing factors for sandy gravel of DaShiXia dam.” Chin. J. Geotech. Eng. 41 (1): 26–31. https://doi.org/10.11779/CJGE201901002.
Chen, S. S., Z. K. Yan, Z. Z. Fu, and G. Y. Li. 2017. “Evaluation of safety performance of extremely high slab-faced gravel dams.” Chin. J. Geotech. Eng. 39 (11): 1949–1958. https://doi.org/10.11779/CJGE201711001.
Chen, S. S., and Q. M. Zhong. 2019. Dam breach models and their application. Beijing: China Water Power Press.
Cooke, J. B. 1984. “Progress in rockfill dams.” J. Geotech. Eng. 110 (10): 1381–1414. https://doi.org/10.1061/(ASCE)0733-9410(1984)110:10(1381).
Fu, Z. Z., S. S. Chen, and E. Y. Ji. 2018. “Practices in constructing high rockfill dams on thick overburden layers.” In Dam engineering, 1–21. London: IntechOpen.
Fu, Z. Z., S. S. Chen, and G. Y. Li. 2019a. “Hydrodynamic pressure problems in concrete face rockfill dams subjected to earthquakes.” J. Hydrodyn. 31 (1): 152–168. https://doi.org/10.1007/s42241-018-0145-z.
Fu, Z. Z., S. S. Chen, and T. B. Wang. 2017. “Predicting the earthquake-induced permanent deformation of concrete face rockfill dams using the strain-potential concept in the finite-element method.” Int. J. Geomech. 17 (11): 04017100. https://doi.org/10.1061/(ASCE)GM.1943-5622.0001010.
Fu, Z. Z., S. S. Chen, and K. M. Wei. 2019b. “A generalized plasticity model for the stress-strain and creep behavior of rockfill materials.” Sci. China Technol. Sci. 62 (4): 649–664. https://doi.org/10.1007/s11431-018-9362-3.
Fu, Z. Z., T. B. Wang, and S. S. Chen. 2015. “Field observations made on four concrete face rockfill dams.” In Proc., 4th Int. Conf. on Civil Engineering and Urban Planning, 589–595. Beijing: CRC Press.
Gao, J. Z., and J. Guo. 2013. “Discussions on emptying tunnel in CFRD dam.” J. Hydroelectric Eng. 32 (5): 179–183.
ICOLD (International Commission on Large Dams). 2010. “Concrete face rockfill dams.” In Concepts for design and construction. Beijing: China Water Power Press.
Kong, J. X., F. H. Liu, and J. Liu. 2012. “Shaking table model tests on face-slab dislocation of concrete face rock-fill dams under earthquakes.” Chin. J. Geotech. Eng. 34 (2): 258–267.
Li, J. C. 1995. “A research for break of Gouhou face dam.” Hydro-Sci. Eng. 17 (4): 425–434.
Mitchell, J. K., and K. Soga. 2005. Fundamentals of soil behavior. 3rd ed. New York: Wiley.
Peng, C., Z. L. Zhang, B. Y. Zhang, and Y. R. Yuan. 2013. “Deformation gradient finite element method for analyzing cracking in high earth-rack dam and its application.” Rock Soil Mech. 34 (5): 1453–1458. https://doi.org/10.16285/j.rsm.2013.05.032.
Seed, H. B. 1979. “Considerations in the earthquake-resistant design of earth and rockfill dams.” Géotechnique 29 (3): 215–263. https://doi.org/10.1680/geot.1979.29.3.215.
Shen, Z. J. 1995. “Some issues in stress and strain analyses of concrete faced rockfill dams.” In Proc., 10th Anniversary of Concrete Faced Rockfill Dams, 43–50. Reston, VA: ASCE.
Sobrinho, J. A., L. V. Xavier, S. C. Albertoni, C. Correa, and R. Fernandes. 2007. “Performance and concrete face repair at Campos Novos.” Int. J. Hydropower Dams 14 (2): 39–42.
USACE. 1995. Construction control for earth and rock-fill dams. Engineering manual. Washington, DC: USACE.
USBR (US Bureau of Reclamation). 2012a. Design standards No. 13 embankment dams. Chapter 2: Embankment design. Denver: USBR.
USBR (US Bureau of Reclamation). 2012b. Design standards No. 13 embankment dams. Chapter 10: Embankment construction. Denver: USBR.
Xavier, L. V., S. C. Albertoni, R. F. Pereira, and J. Antunes. 2008. “Behaviour and treatment of Campos Novos dam during second impounding.” Int. J. Hydropower Dams 15 (4): 53–58.
Zhang, B. Y., J. G. Wang, and R. F. Shi. 2004. “Time-dependent deformation in high concrete-faced rockfill dam and separation between concrete face slabs and cushion layer.” Comput. Geotech. 31 (7): 559–573. https://doi.org/10.1016/j.compgeo.2004.07.004.
Zhou, H., Z. Miao, and C. J. Deng. 2018. Key technical issues in the Dashixia water conservancy project and the countermeasures. Xi’an, China: Northwest Engineering Cooperation Limited.
Zienkiewicz, O. C., A. H. C. Chan, M. Pastor, B. A. Schrefler, and T. Shiomi. 1999. Computational geomechanics with special reference to earthquake engineering. New York: Wiley.
Information & Authors
Information
Published In
Practice Periodical on Structural Design and Construction
Volume 27 • Issue 1 • February 2022
Copyright
© 2021 American Society of Civil Engineers.
History
Received: Apr 20, 2021
Accepted: Oct 8, 2021
Published online: Nov 8, 2021
Published in print: Feb 1, 2022
Discussion open until: Apr 8, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.