Microstructural Changes of Lime Putty during Aging
Publication: Journal of Materials in Civil Engineering
Volume 25, Issue 10
Abstract
The microstructural development of lime putty is widely recognized and commonly associated with an increase in quality. Many heritage institutions encourage the systematic application of lime putties in conservation; however, all the issues associated with age are not fully understood. Changes occur during storage underwater, which traditionally took place in pits to prevent carbonation. The properties of mortars, plasters, and decorative finishes formed from lime putties are intimately linked to manufacturing parameters such as storage time. The hydration of calcium oxide was investigated using an environmental scanning electron microscope with particular attention to the nucleation of calcium hydroxide crystals on the surface of calcium oxide. Crystal modifications were monitored. The results obtained confirm and quantify the influence of slaking time in the microstructure of lime putties that is also reflected in the current referred special characteristics of the mortars produced with them, such as greater plasticity, water retention, and reactivity of mortars. The results also emphasize that the most significant microstructural changes of the lime putties start to consolidate after 8 months of slaking and appear to continue to develop, even though at a slower rate, until at least 5 years.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The writers thankfully acknowledge the support of the National Laboratory of Civil Engineering, in Lisbon, where the experimental work presented in this paper was performed; ICIST Research Institute from IST; Technical University of Lisbon; and Interface Analysis Center, University of Bristol. The writers also thank the support of the Portuguese Foundation for Science and Technology (FCT), which partially financed this paper, within Research Project PTDC/ECM/100234/2008 (Limecontech) Conservation and durability of historical renders, compatible techniques, and materials; and Portuguese Foundation Calouste Gulbenkian, which supported the Ph.D. scholarship of the first author.
References
Agaki, T., Imashiro, F., Terao, T., Hirota, N., and Hayashi, S. (1987). “A study of hydrogen-bond dynamics in carboxylic acids by NMR T1 measurements: Isotope effects and hydrogen-bond length dependence.” Chem. Phys. Lett., 139(3–4), 331–335.
Balksten, K., and Steenari, B.-M. (2010). “The influence of particle size and structure in hydrated lime on the properties of the lime putty and lime mortar.” Int. J. Architect. Herit., 4(2), 86–101.
Boynton, R. S. (1980). Chemistry and technology of lime and limestone, 2nd Ed., Wiley, New York.
British Standards Institute. (2010). “Building lime. Definitions, specifications and conformity criteria.” BS EN 459-1, London.
Cazalla, O., Rodriguez-Navarro, C., Sebastian, E., Cultrone, G., and de la Torre, M. J. (2000). “Ageing of lime putty: Effects on traditional lime mortar carbonation.” J. Am. Ceram. Soc., 83(5), 1071–1076.
Djikaev, Y. S., and Ruckenstein, E. (2011). “The variation of the number of hydrogen bonds per water molecule in the vicinity of a hydrophobic surface and its effect on hydrophobic interactions.” Curr. Opin. Colloid Interface Sci., 16(4), 272–284.
Duquesnay, M. (1883). Encyclopédie chimique–Calcaires, chaux, ciments, mortier, Dunod, Paris (in French).
El-Turki, A., Ball, R. J., and Allen, G. C. (2006). “Simulated ageing of lime mortars–A mechanical property, structural and composition study.” Proc., Int. Conf. on Heritage, Weathering and Conservation, Taylor and Francis, London, 51–56.
Elert, K., Rodriguez-Navarro, C., Pardo, E. S., Hansen, E., and Cazalla, O. (2002). “Lime mortars for the conservation of historic buildings.” Stud. Conserv., 47(1), 62–75.
Guimarães, J. E. P. (2002). Lime–Fundaments and applications in civil engineering, 2nd Ed., Brazilian Association of Lime Producers, São Paulo, Brazil (in Portuguese).
Hansen, E. F., et al. (2000). “Effects of ageing on lime putty.” Proc., Int. RILEM Workshop on Historic Mortars: Characterization and Tests, C. J. W. P. Groot, and J. J. Hughes, Ed., RILEM, Paris, 197–206.
Hansen, E. F., Van Balen, K., and Rodriguez-Navarro, C. (2008). “Lime putties and mortars insights into fundamental properties.” Stud. Conserv., 53(1), 9–16.
Hansen, E. F., Van Balen, K., and Rodriguez-Navarro, C. (2005). “Variations in high-calcium lime putty and mortar and properties resulting from the use of freshly-slaked quicklime and commercial dry hydrated lime.” Proc., Int. Building Lime Symp. (CD-ROM), National Lime Association, Arlington, VA, 9–11.
Margalha, M. G. (2010). “Mineral air binders. The influence of slaking process and curing time on their quality.” Ph.D. thesis in civil engineering, Instituto Superior Técnico, Technical Univ. of Lisbon, Lisbon, Portugal (in Portuguese).
Margalha, M. G., Veiga, M. R., and de Brito, J. (2006). “The maturation time factor on the lime putty quality.” Int. Masonry Conf., British Masonry Society, Surrey, UK, 1–6.
Margalha, M. G., Veiga, R., Silva, A. S., and Brito, J. (2011). “Traditional methods of mortar preparation: The hot lime mix method.” Cement Concr. Compos., 33(8), 796–804.
Mascolo, G., Mascolo, M. C., Vitale, A., and Marino, O. (2010). “Microstructure evolution of lime putty upon ageing.” J. Cryst. Growth, 312(16), 2363–2368.
Millar, W. (1899). Plastering, plain and decorative, Batsford, London.
Moropoulou, A., Bakolas, A., Moundoulas, P., Aggelakopoulou, E., and Anagnostopoulou, S. (2005). “Strength development and lime reaction in mortars for repairing historic masonries.” Cement Concr. Compos., 27(2), 289–294.
Paiva, H., Velosa, A., Veiga, R., and Ferreira, V. M. (2010). “Effect of maturation time on the fresh and hardened properties of an air lime mortar.” Cement Concr. Compos., 40(3), 447–451.
Rattazzi, A. (2007). Conosci il grassello di calce? Origine, produzione e impiego del grassello di calce in architettura, nell’arte e nel restauro, EdicomEdizioni Gorizia, Italy (in Italian).
Rodriguez-Navarro, C., Hansen, E., and Ginell, W. S. (1998). “Calcium hydroxide crystal evolution upon aging of lime putty.” J. Am. Ceram. Soc., 81(11), 3032–3034.
Rodriguez-Navarro, C., Ruiz-Agudo, E., Ortega-Huertas, M., and Hansen, E. (2005). “Nanostructure and irreversible colloidal behavior of : Implications in cultural heritage conservation.” Langmuir, 21(24), 10948–10957.
Vitrivius. (2006). On architecture, Trans. M. J. Maciel, Instituto Superior Técnico, Technical Univ. of Lisbon, Lisbon, Portugal (in Portuguese).
Information & Authors
Information
Published In
Copyright
© 2013 American Society of Civil Engineers.
History
Received: May 30, 2012
Accepted: Sep 16, 2012
Published online: Sep 18, 2012
Discussion open until: Feb 18, 2013
Published in print: Oct 1, 2013
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.