Chloride Ion Penetration in Stressed Concrete
Publication: Journal of Materials in Civil Engineering
Volume 23, Issue 8
Abstract
Steel corrosion owing to chloride ion penetration is one of the most common problems related to the durability of concrete structures. Although previous studies of this phenomenon have produced useful results, they primarily focused on unstressed concrete. To study the effect of stress on the resistance of concrete to chloride ion penetration, tests of stressed specimens exposed to salt solution immersion and salt spray were performed. The chloride contents in uncracked concrete specimens with different water-cement ratios, states and levels of stress, and environmental conditions are analyzed in this article. The results show that the resistance of concrete to chloride ion penetration can be improved by reducing the water-cement ratio. The content of chloride ions is higher in concrete stressed in tension than in unstressed concrete. For concrete stressed in compression, chloride content depends on stress level. Salt solution immersion is more severe than salt spray.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This work was supported by Doctoral Fund of Ministry of Education of China (UNSPECIFIED20090072110045). The experimental work was performed by the third author in the Key Laboratory of Advanced Civil Engineering Materials of Tongji University. The authors would like to thank Associate Professor P. Gauvreau (Departmental of Civil Engineering, University of Toronto, Canada) for his help in improving the paper in English. Finally, the authors wish to thank the reviewers of this paper for their comments and suggestions.
References
Al-Khaja, W. A. (1997). “Influence of temperature, cement type and level of concrete consolidation on chloride ingress in conventional and high-strength concretes.” Constr. Build. Mater., 11(1), 9–13.
Ann, K. Y., Ahn, J. H., and Ryou, J. S. (2009). “The importance of chloride content at the concrete surface in assessing the time to corrosion of steel in concrete structures.” Constr. Build. Mater., 23(1), 239–245.
Bader, M. A. (2003). “Performance of concrete in a coastal environment.” Cem. Concr. Compos., 25(4-5), 539–548.
Basheer, L., Kropp, J., and Cleland, D. J. (2001). “Assessment of the durability of concrete from its permeation properties: A review.” Constr. Build. Mater., 15(2-3), 93–103.
Boddy, A., Bentz, E., Thomas, M. D. A., and Hooton, R. D. (1999). “An overview and sensitivity study of a multimechanistic chloride transport model.” Cem. Concr. Res., 29(6), 827–837.
Care, S. (2003). “Influence of aggregates on chloride diffusion coefficient into mortar.” Cem. Concr. Res., 33(7), 1021–1028.
Castro, P., De Rincon, O. T., and Pazini, E. J. (2001). “Interpretation of chloride profiles from concrete exposed to tropical marine environments.” Cem. Concr. Res., 31(4), 529–537.
Chee, B. S., and Eun, K. K. (2002). “Modeling of chloride ion ingress in coastal concrete.” Cem. Concr. Res., 32(5), 757–762.
China Association for Engineering Construction Standardization (CECS). (2007). “Standard for durability assessment of concrete structures.” CECS 220: 2007, Beijing (in Chinese).
Costa, A., and Appleton, J. (2002). “Case studies of concrete deterioration in a marine environment in Portugal.” Cem. Concr. Compos., 24(1), 169–179.
Ghanem, H., Phelan, S., Senadheera, S., and Pruski, K. (2008). “Chloride ion transport in bridge deck concrete under different curing durations.” J. Bridge Eng., 13(3), 218–225.
Gowripalan, N., Sirivivantnanon, V., and Lim, C. C. (2000). “Chloride diffusivity of concrete cracked in flexure.” Cem. Concr. Res., 30(5), 725–730.
Haque, N., and Al-Khaiat, H. (1999). “Strength and durability of lightweight concrete in hot marine exposure conditions.” Mater. Struct., 32(7), 533–538.
Haque, M. N., Kayyali, O. A., and Gopalan, M. K. (1992). “Fly ash reduces harmful chloride ions in concrete.” ACI Mater. J., 89(3), 238–241.
He, S. Q. (2004). “Experimental studies on durability of reinforced concrete members in chloride environment.” Ph.D. dissertation, School of Civil and Hydraulic Engineering, Dalian Univ. of Technology, Dalian, China (in Chinese).
Hillier, S. R., Sangha, C. M., Plunktt, B. A., and Waden, P. J. (2000). “Effect of concrete curing on chloride ion ingress.” Mag. Concr. Res., 52(5), 321–327.
Hobbs, D. W. (1999). “Aggregate influence on chloride ion diffusion into concrete.” Cem. Concr. Res., 29(12), 1995–1998.
Hong, K., and Hooton, R. D. (2000). “Effects of fresh water exposure on chloride contaminated concrete.” Cem. Concr. Res., 30(8), 1199–1207.
Huang, S. H. (2007). “Study on the chloride erosion resistance of prestressed concrete structure.” Master’s dissertation, School of Civil Engineering and Architecture, Central South Univ., Changsha, China (in Chinese).
Jau, W. C., and Tsay, D. S. (1998). “A study of the basic engineering properties of slag cement concrete and its resistance to seawater corrosion.” Cem. Concr. Res., 28(10), 1363–1371.
Kaushik, S. K., and Islam, S. (1995). “Suitability of sea water for mixing structural concrete exposed to a marine environment.” Cem. Concr. Compos., 17(3), 177–185.
Kong, J., Ababneh, A. N., Frangopol, D. M., and Xi, Y. (2002). “Reliability analysis of chloride penetration in saturated concrete.” Prob. Eng. Mech., 17(3), 305–315.
Konin, A., Francois, R., and Ariliguie, G. (1998). “Penetration of chlorides in relation to the microcracking state into reinforced ordinary and high strength concrete.” Mater. Struct., 31(5), 310–316.
Leng, F. G., Feng, N. Q., and Lu, X. Y. (2000). “An experimental study on the properties of resistance to diffusion of chloride ions of fly ash and blast furnace slag concrete.” Cem. Concr. Res., 30(6), 989–992.
Lin, Y. M., and Feng, L. (1995). “Experimental investigation corrosion of concrete in sea water under stress.” J. Hydrol. Eng. (China), 2, 40–45 (in Chinese).
Mackechnie, J. R., and Alexander, M. G. (1997). “Exposure of concrete in different marine environments.” J. Mater. Civ. Eng., 9(1), 41–44.
Mangat, P. S., Khatib, J. M., and Molloy, B. T. (1994a). “Microstructure, chloride diffusion and reinforcement corrosion in blended cement paste and concrete.” Cem. Concr. Compos., 16(2), 73–81.
Mangat, P. S., and Molloy, B. T. (1994b). “Prediction of long term chloride concentration in concrete.” Mater. Struct., 27(6), 338–346.
Ministry of Transport of the People’s Republic China. (2004). “Code for design of highway reinforced concrete and prestressed concrete bridge and culverts.” JTG D62-2004, Beijing (in Chinese).
Neville, A. (1995). “Chloride attack of reinforced concrete: An overview.” Mater. Struct., 28(2), 63–70.
Page, C. L., Short, N. R., and Holden, W. R. (1986). “The influence of different cement on chloride-induced corrosion of reinforcing steel.” Cem. Concr. Res., 16(1), 79–86.
Poupard, O., Hostis, V. L., Catinaud, S., and Petre-Lazar, I. (2006). “Corrosion damage diagnosis of a reinforced concrete beam after 40 years’ natural exposure in marine environment.” Cem. Concr. Res., 36(3), 504–520.
Puatatsananon, W., and Saouma, V. E. (2005). “Nonlinear coupling of carbonation and chloride diffusion in concrete.” J. Mater. Civ. Eng., 17(3), 264–275.
Sandberg, P., Tang, L., and Andersen, A. (1998). “Recurrent studies of chloride ingress in uncracked marine concrete at various exposure times and elevations.” Cem. Concr. Res., 28(10), 1489–1503.
Smith, B. G. (2001). “Durability of silica fume concrete exposed to chloride in hot climates.” J. Mater. Civ. Eng., 13(1), 41–48.
Thomas, M. D. A., and Bamforth, P. B. (1999). “Modeling chloride diffusion in concrete effect of fly ash and slag.” Cem. Concr. Res., 29(4), 487–495.
Tu, Y. M. (2002). “Study on the durability mechanism of modern prestressed concrete structure.” Master’s dissertation, School of Civil Engineering, Southeast Univ., Nanjing, China (in Chinese).
Val, D. V., and Trapper, P. A. (2008). “Probabilistic evaluation of initiation time of chloride-induced corrosion.” Reliab. Eng. Syst. Saf., 93(3), 364–372.
Zhang, J., and Lounis, Z. (2009). “Nonlinear relationships between parameters of simplified diffusion-based model for service life design of concrete structures exposed to chlorides.” Cem. Concr. Compos., 31(8), 591–600.
Information & Authors
Information
Published In
Copyright
© 2011 American Society of Civil Engineers.
History
Received: Sep 21, 2009
Accepted: Jan 25, 2011
Published online: Jan 28, 2011
Published in print: Aug 1, 2011
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.