Biogrouting Method for Stronger Bond Strength for Aggregates
Publication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 146, Issue 11
Abstract
Microbial-induced carbonate precipitation (MICP) methods have been developed in recent years for soil improvement to simultaneously increase the shear strength and reduce the permeability of soil or aggregate. However, this method is difficult to use for aggregate because many more injections are required. This technical note proposes a new biogrouting method for aggregates. In this method, biogrout solution containing bioslurry is injected before injection of cementation solution alone into aggregate, which is kept in an unsaturated state. Due to the capillary effect, more calcium carbonate crystals in the bioslurry are retained around the contact points of the particles, rather than in the pores. As a result, this method can achieve a higher shear strength (2.98 MPa) for biogrouted aggregate compared with that using other MICP methods (0.78 MPa) at the same level of calcium carbonate content. Therefore, the permeability reduction also is smaller using this method. The proposed method can be used for applications which require only an increase in strength, such as for granular base for pavement or the toe drainage of a slope.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The financial support from the Ministry of National Development, Singapore (No. SUL2013-1) and the Ministry of Education, Singapore (No. MOE2015-T2-2-142) is greatly acknowledged.
References
Al Qabany, A., and K. Soga. 2013. “Effect of chemical treatment used in MICP on engineering properties of cemented soils.” Géotechnique 63 (4): 331. https://doi.org/10.1680/geot.SIP13.P.022.
Al-Thawadi, S. M. 2008. “High strength in situ biocementation of soil by calcite precipitating locally isolated ureolytic bacteria.” Ph.D. thesis, School of Biological Sciences and Biotechnology, Murdoch Univ.
Cheng, L., R. Cord-Ruwisch, and M. A. Shahin. 2013. “Cementation of sand soil by microbially induced calcite precipitation at various degrees of saturation.” Can. Geotech. J. 50 (1): 81–90. https://doi.org/10.1139/cgj-2012-0023.
Cheng, L., and M. A. Shahin. 2016. “Urease active bioslurry: A novel soil improvement approach based on microbially induced carbonate precipitation.” Can. Geotech. J. 53 (9): 1376–1385. https://doi.org/10.1139/cgj-2015-0635.
Chu, J., V. Ivanov, V. Stabnikov, and B. Li. 2013. “Microbial method for construction of aquaculture pond in sand.” Géotechnique 63 (10): 871–875. https://doi.org/10.1680/geot.SIP13.P.007.
Cui, M. J., J.-J. Zheng, R.-J. Zhang, H.-J. Lai, and J. Zhang. 2017. “Influence of cementation level on the strength behaviour of bio-cemented sand.” Acta Geotech. 12 (5): 971–986.
DeJong, J. T., M. B. Fritzges, and K. Nüsslein. 2006. “Microbially induced cementation to control sand response to undrained shear.” J. Geotech. Geoenviron. Eng. 132 (11): 1381–1392. https://doi.org/10.1061/(ASCE)1090-0241(2006)132:11(1381).
DeJong, J. T., B. M. Mortensen, B. C. Martinez, and D. C. Nelson. 2010. “Bio-mediated soil improvement.” Ecol. Eng. 36 (2): 197–210. https://doi.org/10.1016/j.ecoleng.2008.12.029.
El Mountassir, G. E., R. J. Lunn, H. Moir, and E. MacLachlan. 2014. “Hydrodynamic coupling in microbially mediated fracture mineralization: Formation of self-organized groundwater flow channels.” Water Resour. Res. 50 (1): 1–16. https://doi.org/10.1002/2013WR013578.
Hong, Y., L. Z. Wang, J. F. Zhang, and Z. W. Gao. 2020. “3D elastoplastic model for fine-grained gassy soil considering the gas-dependent yield surface shape and stress-dilatancy.” J. Eng. Mech. 146 (5): 04020037. https://doi.org/10.1061/(ASCE)EM.1943-7889.0001760.
Ismail, M. A., H. A. Joer, M. F. Randolph, and A. Meritt. 2002. “Cementation of porous materials using calcite.” Géotechnique 52 (5): 313–324. https://doi.org/10.1680/geot.52.5.313.38709.
Ivanov, V., and J. Chu. 2008. “Applications of microorganisms to geotechnical engineering for bioclogging and biocementation of soil in situ.” Rev. Environ. Sci. Biotechnol. 7 (2): 139–153. https://doi.org/10.1007/s11157-007-9126-3.
Jiang, N.-J., and K. Soga. 2016. “The applicability of microbially induced calcite precipitation (MICP) for internal erosion control in gravel–sand mixtures.” Géotechnique 67 (1): 42–55. https://doi.org/10.1680/jgeot.15.P.182.
Jiang, N.-J., H. Yoshioka, K. Yamamoto, and K. Soga. 2016. “Ureolytic activities of a urease-producing bacterium and purified urease enzyme in the anoxic condition: Implication for subseafloor sand production control by microbially induced carbonate precipitation (MICP).” Ecol. Eng. 90 (May): 96–104. https://doi.org/10.1016/j.ecoleng.2016.01.073.
Kim, J., R. Salgado, and J. Lee. 2002. “Stability analysis of complex soil slopes using limit analysis.” J. Geotech. Geoenviron. Eng. 128 (7): 546–557. https://doi.org/10.1061/(ASCE)1090-0241(2002)128:7(546).
Mahawish, A., A. Bouazza, and W. P. Gates. 2016. “Biogrouting coarse materials using soil-lift treatment strategy.” Can. Geotech. J. 53 (12): 2080–2085. https://doi.org/10.1139/cgj-2016-0167.
Mahawish, A., A. Bouazza, and W. P. Gates. 2018. “Effect of particle size distribution on the bio-cementation of coarse aggregates.” Acta Geotech. 13 (4): 1019–1025. https://doi.org/10.1007/s11440-017-0604-7.
Manzur, T., F. Rahman, S. Afroz, R. S. Huq, and I. H. Efaz. 2017. “Potential of a microbiologically induced calcite precipitation process for durability enhancement of masonry aggregate concrete.” J. Mater. Civ. Eng. 29 (5): 04016290. https://doi.org/10.1061/(ASCE)MT.1943-5533.0001799.
Minto, J. M., E. MacLachlan, G. El Mountassir, and R. J. Lunn. 2016. “Rock fracture grouting with microbially induced carbonate precipitation.” Water Resour. Res. 52 (11): 8827–8844. https://doi.org/10.1002/2016WR018884.
Phillips, A. J., et al. 2016. “Fracture sealing with microbially-induced calcium carbonate precipitation: A field study.” Environ. Sci. Technol. 50 (7): 4111–4117. https://doi.org/10.1021/acs.est.5b05559.
Phillips, A. J., E. Lauchnor, J. Eldring, R. Esposito, A. C. Mitchell, R. Gerlach, A. B. Cunningham, and L. H. Spangler. 2013. “Potential CO2 leakage reduction through biofilm-induced calcium carbonate precipitation.” Environ. Sci. Technol. 47 (1): 142–149. https://doi.org/10.1021/es301294q.
Stocks-Fischer, S., J. K. Galinat, and S. S. Bang. 1999. “Microbiological precipitation of .” Soil Biol. Biochem. 31 (11): 1563–1571. https://doi.org/10.1016/S0038-0717(99)00082-6.
van Paassen, L. A., R. Ghose, T. J. van der Linden, W. R. van der Star, and M. C. van Loosdrecht. 2010. “Quantifying biomediated ground improvement by ureolysis: Large-scale biogrout experiment.” J. Geotech. Geoenviron. Eng. 136 (12): 1721–1728. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000382.
Whiffin, V. S., L. A. van Paassen, and M. P. Harkes. 2007. “Microbial carbonate precipitation as a soil improvement technique.” Geomicrobiol. J. 24 (5): 417–423. https://doi.org/10.1080/01490450701436505.
Wu, C., J. Chu, L. Cheng, and S. Wu. 2019a. “Biogrouting of aggregates using premixed injection method with or without pH adjustment.” J. Mater. Civ. Eng. 31 (9): 06019008. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002874.
Wu, C., J. Chu, S. Wu, L. Cheng, and L. A. van Paassen. 2019b. “Microbially induced calcite precipitation along a circular flow channel under a constant flow condition.” Acta Geotech. 14 (3): 673–683. https://doi.org/10.1007/s11440-018-0747-1.
Wu, C., J. Chu, S. Wu, and Y. Hong. 2019c. “3D characterization of the microbially induced carbonate precipitation within rock fracture and the resulted permeability reduction.” Eng. Geol. 249 (Jan): 23–30. https://doi.org/10.1016/j.enggeo.2018.12.017.
Information & Authors
Information
Published In
Copyright
© 2020 American Society of Civil Engineers.
History
Received: Jun 26, 2019
Accepted: Jun 22, 2020
Published online: Aug 31, 2020
Published in print: Nov 1, 2020
Discussion open until: Jan 31, 2021
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.