Rehabilitation of Overdeformed Metro Tunnel in Shanghai by Multiple Repair Measures
Publication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 145, Issue 11
Abstract
This paper presents a case study describing the effectiveness of multiple measures implemented to repair overdeformed metro shield tunnels in Shanghai. The changes in horizontal diameter were up to 3.6% of the tunnels’ diameters due to unexpected surcharge at the ground surface. The surcharge was removed, and then structural reinforcements were added. The tunnel sections that had extremely large convergences were reinforced by bonding aromatic fiber–reinforced plastic sheets to the tunnel crown and bonding steel plates to the inner surface of the full lining rings. The tunnel sections that had relatively large convergences were reinforced only by bonding fiber-reinforced plastic sheets. In addition, instead of installing steel plates at these sections, cement-sodium silicate grouting was performed at the two sides of the tunnel springline three years after reinforcement by fiber-reinforced plastic sheets, because a gradual increase in convergence was observed at these sections. The grouting resulted in a 30% reduction in horizontal convergence. However, less than 5% of the grouted volume contributed to the horizontal movement of the tunnel cross sections. Cone penetration tests were conducted at the grouted sections as well as at green field sections. The results showed an increase in cone tip resistance of about 110%–130% in the grouted zones compared to the nongrouted zones. However, the increase was localized and had a high coefficient of variance, indicating that the improvement from grouting was highly variable.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study was substantially supported by the Natural Science Foundation Committee Program (Grant Nos. 51608380 and 51538009) and by the Shanghai Rising-Star Program (Grant No. 17QC1400300). The authors are grateful to these programs. Special thanks also go to the anonymous peer reviewers, whose comments greatly improved the rigorousness and quality of this paper.
References
Asakura, T., and Y. Kojima. 2003. “Tunnel maintenance in Japan.” Tunnelling Underground Space Technol. 18 (2): 161–169. https://doi.org/10.1016/S0886-7798(03)00024-5.
Au, S. K. A., K. Soga, M. R. Jafari, M. D. Bolton, and K. Komiya. 2003. “Factors affecting long-term efficiency of compensation grouting in clays.” J. Geotech. Geoenviron. Eng. 129 (3): 254–262. https://doi.org/10.1061/(ASCE)1090-0241(2003)129:3(254).
Chai, J. C., N. Miura, and H. Koga. 2005. “Lateral displacement of ground caused by soil-cement column installation.” J. Geotech. Geoenviron. Eng. 131 (5): 623–632. https://doi.org/10.1061/(ASCE)1090-0241(2005)131:5(623).
Chang, C. T., C. W. Sun, S. Duann, and R. N. Hwang. 2001a. “Response of a Taipei rapid transit system (TRTS) tunnel to adjacent excavation.” Tunneling Underground Space Technol. 16 (3): 151–158. https://doi.org/10.1016/S0886-7798(01)00049-9.
Chang, C. T., M.-J. Wang, C. T. Chang, and C. W. Sun. 2001b. “Repair of displaced shield tunnel of the Taipei rapid transit system.” Tunnelling Underground Space Technol. 16 (3): 167–173. https://doi.org/10.1016/S0886-7798(01)00050-5.
Huang, H., H. Shao, D. Zhang, and F. Wang. 2016. “Deformational responses of operated shield tunnel to extreme surcharge: A case study.” Struct. Infrastruct. Eng. 13 (3): 345–360. https://doi.org/10.1080/15732479.2016.1170156.
Huang, H. W., and D. M. Zhang. 2016. “Resilience analysis of shield tunnel lining under extreme surcharge: Characterization and field application.” Tunnelling Underground Space Technol. 51 (Jan): 301–312. https://doi.org/10.1016/j.tust.2015.10.044.
Huang, H. W., Y. J. Zhang, D. M. Zhang, and B. M. Ayyub. 2017. “Field data-based probabilistic assessment on degradation of deformational performance for shield tunnel in soft clay.” Tunnelling Underground Space Technol. 67 (Aug): 107–119. https://doi.org/10.1016/j.tust.2017.05.005.
Kiriyama, K., M. Kakizaki, T. Takabayashi, N. Hirosawa, T. Takeuchi, H. Hajohta, Y. Yano, and K. Imafuku. 2005. Structure and construction examples of tunnel reinforcement method using thin steel panels. Tokyo: Nippon Steel.
Liu, X., Y. Bai, Y. Yuan, and H. A. Mang. 2016a. “Experimental investigation of the ultimate bearing capacity of continuously jointed segmental tunnel linings.” Struct. Infrastruct. Eng. 12 (10): 1364–1379. https://doi.org/10.1080/15732479.2015.1117115.
Liu, X., Z. J. Jiang, and L. L. Zhang. 2017. “Experimental investigation of the ultimate bearing capacity of deformed segmental tunnel linings strengthened by epoxy-bonded filament wound profiles.” Struct. Infrastruct. Eng. 13 (10): 1268–1283. https://doi.org/10.1080/15732479.2016.1260601.
Liu, X., C. G. Zhang, C. Zhang, and Z. J. Jiang. 2016b. “Experimental study on the longitudinal joint in shield tunnel reinforced with FRP material.” [In Chinese.] J. Railway Sci. Eng. 13 (2): 316–324. https://doi.org/10.19713/j.cnki.43-1423/u.2016.02.018.
Masini, L., S. Rampello, and K. Soga. 2014. “An approach to evaluate the efficiency of compensation grouting.” J. Geotech. Geoenviron. Eng. 140 (12): 04014073. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001180.
Meshgin, P., K. K. Choi, and M. M. R. Taha. 2009. “Experimental and analytical investigations of creep of epoxy adhesive at the concrete-FRP interfaces.” Int. J. Adhes. Adhes. 29 (1): 56–66. https://doi.org/10.1016/j.ijadhadh.2008.01.003.
Nicolini, E., and R. Nova. 2000. “Modelling of a tunnel excavation in a non-cohesive soil improved with cement mix injections.” Comput. Geotech. 27 (4): 249–272. https://doi.org/10.1016/S0266-352X(00)00003-3.
Richards, J. 1998. “Inspection, maintenance and repair of tunnels: International lessons and practice.” Tunnelling Underground Space Technol. 13 (4): 369–375. https://doi.org/10.1016/S0886-7798(98)00079-0.
Ryumin, A. 2004. “On hydrogeomechanical causes of accident in the subway of Saint Petersburg.” J. Mining Sci. 40 (1): 11–23. https://doi.org/10.1023/B:JOMI.0000041523.83043.2b.
Shanghai Rural and Urban Construction and Transportation Committee. 2010. Shanghai foundation design code. DGJ08-11. Shanghai, China: Shanghai Rural and Urban Construction and Transportation Committee.
Shi, J. W., Z. S. Wu, X. Wang, and M. Noori. 2015. “Reliability analysis of intermediate crack-induced debonding failure in FRP-strengthened concrete members.” Struct. Infrastruct. Eng. 11 (12): 1651–1671. https://doi.org/10.1080/15732479.2014.987302.
Shilin, A. A., A. M. Kirilenko, and P. A. Znajchenko. 2016. “Complex reconstruction project of Mayakovskaya metro station in the centre of Moscow.” In Structural Analysis of Historical Constructions—Anamnesis, diagnosis, therapy, controls. London: Taylor & Francis.
Soga, K., S. K. A. Au, M. R. Jafari, and M. D. Bolton. 2004. “Laboratory investigation of multiple injection into clay.” Géotechnique 54 (2): 81–90. https://doi.org/10.1680/geot.2004.54.2.81.
Wisser, C., C. E. Augarde, and H. J. Burd. 2005. “Numerical modelling of compensation grouting above shallow tunnels.” Int. J. Numer. Anal. Methods Geomech. 29 (5): 443–471. https://doi.org/10.1002/nag.421.
Yuan, Y., Y. Bai, and J. Liu. 2012. “Assessment service state of tunnel structure.” Tunnelling Underground Space Technol. 27 (1): 72–85. https://doi.org/10.1016/j.tust.2011.07.002.
Yuan, Y., X. Jiang, and X. Liu. 2013. “Predictive maintenance of shield tunnels.” Tunnelling Underground Space Technol. 38 (Sep): 69–86. https://doi.org/10.1016/j.tust.2013.05.004.
Zhang, D. M., X. L. Gu, Q. Q. Yu, H. W. Huang, B. L. Wan, and C. Jiang. 2018. “Fully probabilistic design of FRP-to-concrete bonded joints considering model uncertainty.” Compos. Struct. 185 (Feb): 786–806. https://doi.org/10.1016/j.compstruct.2017.11.058.
Zhang, D. M., Z. S. Liu, R.-L. Wang, and D. Zhang. 2019. “Influence of soil grouting on resilience of an over-deformed running shield tunnel lining in soft clay.” Acta Geotech. 14 (4): 1227–1247. https://doi.org/10.1007/s11440-018-0696-8.
Zhang, D. M., K. K. Phoon, Q. F. Hu, and H. W. Huang. 2017. “Nonlinear subgrade reaction solution for circular tunnel lining design based on mobilized strength of undrained clay.” Can. Geotech. J. 55 (2): 155–170. https://doi.org/10.1139/cgj-2017-0006.
Zhao, H., X. Liu, Y. Bao, Y. Yuan, and Y. Bai. 2016. “Simplified nonlinear simulation of shield tunnel lining reinforced by epoxy bonded steel plates.” Tunnelling Underground Space Technol. 51 (Jan): 362–371. https://doi.org/10.1016/j.tust.2015.10.004.
Information & Authors
Information
Published In
Copyright
©2019 American Society of Civil Engineers.
History
Received: Apr 4, 2018
Accepted: Jul 9, 2019
Published online: Sep 11, 2019
Published in print: Nov 1, 2019
Discussion open until: Feb 11, 2020
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.