Assessment of Sulfate-Induced Swell in Stabilized Dredged Material: Is Ettringite Always a Problem?
Publication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 138, Issue 3
Abstract
This paper is the last in a series related to pozzolanically stabilizing dredged material (DM) using up to 20 different combinations of lime, cement kiln dust (CKD), fly ash (FA), Portland cement (PC), and slag cement. The fine-grained nature of the DM and the presence of high sulfate concentrations (0.6–3.25% by weight) in the stabilized dredged material (SDM) blends derived from the raw materials themselves posed concern for potential ettringite formation and swell. The sulfate contents of the SDM blends were well in excess of the National Lime Association’s thresholds for mitigating against swell ( by weight ). The quantitative mineralogical results showed that the lime and lime/FA SDM blends showed moderate to high ettringite formation (1.6–4.6% by weight) up to 6 months of curing, with all available sulfate bound to ettringite. The lime and lime/FA SDM blends consistently maintained the highest pHs through 6 months, which caused continued release of alumina and increases in strength. The CKD and CKD/FA SDM blends showed the highest ettringite contents through 28 days of curing (up to 5%), but with little additional formation of ettringite through 6 months of curing. The total sulfate content of the SDM blends was not a good predictor of ettringite formation potential, because of decreases in pH below the ettringite stability threshold and, even more importantly, the apparent limited availability of soluble alumina in the SDM blends. Swell tests performed on six SDM blends showed slight consolidation, and no ettringite was detected in the two specimens that swelled.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This work was performed via Schnabel Engineering, LLC, the former affiliation of Dr. D. G.Grubb (former senior associate) and Dr. N. Malasavage (former engineering intern). Dominion Virginia Power provided the Type F fly ash to support this research. The authors thank David Bristow (Dominion) and Ron Birckhead (Dominion, retired) for their support and involvement. Sam McGee and Carlos M. Quinones of USACE Craney Island facilitated the DM sample collection. The lime, CKD, Type IE PC, and NewCem were provided by Jeff Fair of Lafarge North America (Whitehall, PA). David Cinsavich, Matt Farley, and Dennis Stevens of Schnabel (Blacksburg, VA) assisted with the geotechnical testing program. Any opinions, findings, and conclusions or recommendations expressed in this material are those of the author(s) and do not necessarily reflect the views of the project sponsors.
References
Adams, A. G., Dukes, O. M., Tabet, W., Cerato, A., and Miller, G. A. (2008). “Sulfate induced heave in Oklahoma soils due to lime stabilization.” Proc., Geocongress 2008 Conf., ASCE, Reston, VA, 444–451.
ASTM. (2000). “Standard test methods for sulfur in the analysis sample of coal and coke using high temperature tube furnace combustion methods.” D4239-05, West Conshohocken, PA.
ASTM. (2008). “Standard test methods for one-dimensional swell or collapse of cohesive soils.” D4546-08, West Conshohocken, PA.
Buisman, C., Uspeert, P., Janssen, A., and Lettinga, G. (1990). “Kinetics of chemical and biological sulphide oxidation in aqueous solutions.” Water Res., 24(5), 667–671.
Chen, D.-H., Harris, P., Scullion, T., and Bilyeu, J. (2005). “Forensic investigation of a sulfate heaved project in Texas.” J. Perform. Constr. Facil., 19(4), 324–330.
Chrysochoou, M., and Dermatas, D. (2006). “Evaluation of ettringite and hydrocalumite formation for heavy metal immobilization: literature review and experimental study.” J. Hazard. Mater., 136(1), 20–33.
Chrysochoou, M., Grubb, D. G., Drengler, K., and Malasavage, N. (2010). “Stabilized dredged material III: A mineralogical perspective.” J. Geotech. Geoenviron. Eng., 136(8), 1037–1050.
Columbia Analytical Services (CAS). (2005). “Acid digestion for sulfate.” Rochester, NY.
Dermatas, D. (1995). “Ettringite-induced swelling in soils: State-of-the-art.” Appl. Mech. Rev., 48(10), 659–673.
Dermatas, D., Chrysochoou, M., Pardali, S., and Grubb, D. G. (2007). “Influence of X-ray diffraction sample preparation on quantitative mineralogy: Implications for chromate waste treatment.” J. Environ. Qual., 36(2), 487–497.
Grubb, D. G., Chrysochoou, M., Smith, C. J., and Malasavage, N. (2010a). “Stabilized dredged material I: A parametric study.” J. Geotech. Geoenviron. Eng., 136(8), 1011–1024.
Grubb, D. G., Malasavage, N., Smith, C. J., and Chrysochoou, M. (2010b). “Stabilized dredged material II: Geomechanical behavior.” J. Geotech. Geoenviron. Eng., 136(8), 1025–1036.
Harris, P., Von Holdt, J., Sebesta, S., and Scullion, T. (2006). “Recommendations for stabilization of high-sulfate soils in Texas.” Transportation Research Record 1952, Transportation Research Washington, DC, 71–79.
Hewlett, P. C., ed. (1998). Lea’s chemistry of cement and concrete, 4th Ed., Elsevier Butterworth-Heinemann, Oxford, UK.
Hunter, D. (1989). “Geochemistry of lime induced heave in sulfate bearing clay soils.” Ph.D. dissertation, Univ. of Reno, Reno, NV.
Little, D., and Graves, R. (1993). Investigation of sulfate levels and expansive properties of subgrade soils along Route 86 Project, Imperial County, CA.
Little, D. N., Herbert, B., and Kunagalli, S. C. (2005). “Ettringite formation in lime-treated soils.” Transportation Research Record 1936, Transportation Reseasrch Board, Washington, DC, 51–59.
Little, D. N., Nair, S., and Herbert, B. (2010). “Addressing sulfate-induced heave in lime-treated soil.” J. Geotech. Geoenviron. Eng., 136(1), 110–118.
Louisiana Transport Research Center (LTRC). (2003). “Stabilization techniques for reactive aggregate in soil-cement base course: technical summary.” Report No. 366, Baton Rouge, LA.
Lee, H., Cody, R. D., Cody, A. M., and Spry, P. G. (2005). “The formation and role of ettringite in Iowa highway concrete deterioration.” Cem. Concr. Res., 35(2), 332–343.
Mitchell, J. K. (1986). “Practical problems from surprising soil behavior.” J. Geotech. Eng., 112(3), 255–289.
Mitchell, J. K., and Dermatas, D. (1992). “Clay soil heave caused by lime-sulfate reactions.” ASTM Special Publ. 1135, ASTM, West Conshohoken, PA, 41–64.
Myneni, S. C. B., Traina, S. J., and Logan, T. J. (1998). “Ettringite solubility and geochemistry of the system at 1 atm pressure and 298 K.” Chem. Geol., 148(1–2), 1–19.
National Lime Association (NLA). (2000). “Technical memorandum: Guidelines for stabilization of soils containing sulfates, Austin white lime, chemical lime, Texas lime.” 〈http://www.lime.org/documents/publications/free_downloads/technical-memorandum.pdf〉.
Puppala, A. J., and Cerato, A. (2009). “Heave distress problems in chemically-treated sulfate laden materials.” Geo-Strata, 10(2), 28–32.
Puppala, A. J., Intharasombat, N., and Vempati, R. K. (2005). “Experimental studies on ettringite-induced heaving in soils.” J. Geotech. Geoenviron. Eng., 131(3), 325–337.
Taylor, H. F. W., Famy, C., and Scrivener, K. L. (2001). “Review: Delayed ettringite formation.” Cem. Concr. Res., 31(5), 683–693.
Texas Department of Transportation (TxDOT). (2005). “Test procedure for determining chloride and sulfate contents in soil.” TxDOT Designation: Tex-620-J, Austin, TX.
Wang, E., Roy, A., Seals, R. K., and Metcalf, J. B. (2003). “Stabilization of sulfate-containing soil by cementitious mixtures mechanical properties.” Transportation Research Record 1837, Transportation Research Board, Washington, DC, 12–19.
Information & Authors
Information
Published In
Copyright
© 2012 American Society of Civil Engineers.
History
Received: May 28, 2009
Accepted: Jun 18, 2011
Published online: Jun 21, 2011
Published in print: Mar 1, 2012
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.