Vacuum Preloading on Structured Clay: Field, Laboratory, and Numerical Studies
Publication: International Journal of Geomechanics
Volume 21, Issue 10
Abstract
A full-scale vacuum preloading test was performed for an embankment construction on a Canadian structured clay deposit at Saint-Roch-de-l’Achingan. Accordingly, extensive instrumentation was used to monitor field behavior over eight months. A multidrain finite-element analysis was also carried out using a plane strain configuration with which the structured soft clay behavior was simulated using the S-CLAY1S constitutive model. The numerical analyses were then compared with the field measurements in terms of settlements, horizontal displacements of the clayey foundation, and pore pressure developments in the soft clay deposit. The results showed that compression curves obtained numerically at two different depths compared reasonably well with both field and laboratory curves. Effective stress paths at different points in the clay layer clearly demonstrated the benefit of vacuum preloading in comparison with traditional embankment construction (i.e., without vacuum preloading). In addition, the results suggested that the finite-element approach was consistent with laboratory and field behavior.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors thank the following for their support: Eletrobras, CAPES Agency; Professor Serge Leroueil, Laval University; Professor Minna Karstunen, Chalmers University; and PLAXIS.
References
Almeida, M. S. S., A. M. Britto, and R. H. G. Parry. 1986. “Numerical modelling of a centrifuged embankment on soft clay.” Can. Geotech. J. 23 (2): 103–114. https://doi.org/10.1139/t86-020.
Almeida, M. S. S., and M. E. S. Marques. 2013. Design and performance of embankment on very soft soils. Boca Raton, FL: CRC Press.
Almeida, M. S. S., H. M. Oliveira, D. Dias, and L. O. G. Deotti. 2011. “Behavior of three test embankments taken to failure on soft clay.” Soils Rocks 34 (4): 389–404.
Almeida, M. S. S., P. E. L. Santa Maria, I. S. M. Martins, A. P. Spotti, and L. B. M. Coelho. 2001. “Consolidation of a very soft clay with vertical drains.” Géotechnique 50 (6): 633–643. https://doi.org/10.1680/geot.2000.50.6.633.
Barron, R. A. 1948. “Consolidation of fine-grained soils by drain wells.” J. Soil Mech. Found. Div. 73 (6): 811–835.
Baudet, B., and S. Stallebrass. 2004. “A constitutive model for structured clays.” Géotechnique 54 (4): 269–278. https://doi.org/10.1680/geot.2004.54.4.269.
Bergado, D. T., and P. V. Long. 1994. “Numerical analysis of embankment on subsiding ground by vertical drains and granular piles.” In Proc., 13th Int. Conf. on Soil Mechanics and Foundation Engineering, 1361–1366. Rotterdam, Netherlands: A. A. Balkema.
Biot, M. A. 1941. “General theory of three-dimensional consolidation.” J. Appl. Phys. 12 (2): 155–164. https://doi.org/10.1063/1.1712886.
Briaud, J. L. 2013. Geotechnical engineering, unsaturated and saturated soils. Hoboken, NJ: Wiley.
Brinkgreve, R. B. J., S. Kmarswamy, and W. M. Swolfs. 2015. PLAXIS: Finite element code for soil and rock analyses. Delft, The Netherlands: PLAXIS.
Chai, J., and J. P. Carter. 2011. Deformation analysis in soft ground improvement. Berlin: Springer.
Chai, J.-C., and N. Miura. 1999. “Investigation of factors affecting vertical drain behavior.” J. Geotech. Geoenviron. Eng. 125 (3): 216–226. https://doi.org/10.1061/(ASCE)1090-0241(1999)125:3(216).
Chai, J. C., N. Miura, and D. T. Bergado. 2008. “Preloading clayey deposit by vacuum pressure with cap-drain: Analyses versus performance.” Geotext. Geomembr. 26 (3): 220–230. https://doi.org/10.1016/j.geotexmem.2007.10.004.
Chai, J. C., C. Y. Ong, J. P. Carter, and D. T. Bergado. 2013. “Lateral displacement under combined vacuum pressure and embankment loading.” Géotechnique 63 (10): 842–856. https://doi.org/10.1680/geot.12.P.060.
Chai, J. C., S. L. Shen, N. Miura, and D. T. Bergado. 2001. “Simple method of modeling PVD-improved subsoil.” J. Geotech. Geoenviron. Eng. 127 (11): 965–972. https://doi.org/10.1061/(ASCE)1090-0241(2001)127:11(965).
Chu, J., S. W. Yan, and H. Yang. 2000. “Soil improvement by the vacuum preloading method for an oil storage station.” Géotechnique 50 (6): 625–632. https://doi.org/10.1680/geot.2000.50.6.625.
Cognon, J. M., I. Juran, and S. Thevanayagam. 1994. “Vacuum consolidation technology—Principles and field experience.” In Conf. on Vertical and Horizontal Deformations of Foundations and Embankments Deformation, 1237–1248. Reston, VA: ASCE.
Deotti, L. O. G., M. Karstunen, M. C. F. Almeida, and M. S. S. Almeida. 2017. “Modeling of laboratory tests on Saint-Roch-de-l’Achigan clay with S-CLAY1S model.” Int. J. Geomech. 17 (2): 06016018. https://doi.org/10.1061/(ASCE)GM.1943-5622.0000701.
Fu, H., Y. Cai, J. Wang, and P. Wang. 2017. “Experimental study on the combined application of vacuum preloading—Variable-spacing electro-osmosis to soft ground improvement.” Geosynth. Int. 24 (1): 72–81. https://doi.org/10.1680/jgein.16.00016.
Gens, A., and R. Nova. 1993. “Conceptual bases for a constitutive model for bonded soils and weak rocks.” In Symp. of Hard Soils—Soft Rocks, 485–494. Rotterdam, Netherlands: A.A. Balkema.
González, N. G., A. Gens, M. Arroyo, and M. Rouainia. 2011. “A structured constitutive model for simulating the behaviour of an overconsolidated bonded clay.” In Proc., 11th Int. Conf. on Computational Plasticity: Fundamentals and Applications, edited by E. Oñate, D. R. J. Owen, D. Peric, and B. Suárez, 2–12. Barcelona, Spain: CIMNE.
Hansbo, S. 1981. “Consolidation of fine-grained soils by prefabricated drains.” In Vol. 3 of Proc., 10th Int. Conf. on Soil Mechanics and Foundation Engineering, 677–682. Rotterdam, Netherlands: Balkema.
Hird, C. C., I. C. Pyrah, and D. Russell. 1992. “Finite element modelling of vertical drains beneath embankments on soft ground.” Géotechnique 42 (3): 499–511. https://doi.org/10.1680/geot.1992.42.3.499.
Holtz, R. D., M. B. Jamiolkowski, R. Lancellotta, and R. Pedroni. 1991. Prefabricated vertical drains: Design and performance, 1–131. London: CIRIA.
Hosseinpour, I., M. S. S. Almeida, and M. Riccio. 2017. “Verification of a plane strain model for the analysis of encased granular columns.” J. GeoEng. 12 (4): 137–145. https://doi.org/10.6310/jog.2017.12(4).1.
Hosseinpour, I., C. Soriano, and M. S. S. Almeida. 2019. “A comparative study for the performance of encased granular columns.” J. Rock Mech. Geotech. Eng. 11 (2): 379–388. https://doi.org/10.1016/j.jrmge.2018.12.002.
Hu, L., Y. Wang, and Z. Liu. 2019. “Centrifuge modelling on soft soil subjected to underwater vacuum preloading.” Proc. Inst. Civ. Eng. Ground Improv. 172 (3): 167–178. https://doi.org/10.1680/jgrim.18.00011.
Indraratna, B. 2010. “Recent advances in the application of vertical drains and vacuum preloading in soft soil stabilization.” Aust. Geomech. J. 45 (2): 1–43.
Indraratna, B., C. Bamunawita, and H. Khabbaz. 2004. “Numerical modeling of vacuum preloading and field applications.” Can. Geotech. J. 41 (6): 1098–1110. https://doi.org/10.1139/t04-054.
Indraratna, B., M. E. Kan, D. Potts, C. Rujjkiatkamjorn, and S. W. Sloan. 2016. “Analytical solution and numerical simulation of vacuum consolidation by vertical drains beneath circular embankments.” Comput. Geotech. 80: 83–96. https://doi.org/10.1016/j.compgeo.2016.06.008.
Indraratna, B., and I. W. Redana. 2000. “Numerical modeling of vertical drains with smear and well resistance installed in soft clay.” Can. Geotech. J. 37 (1): 132–145. https://doi.org/10.1139/t99-115.
Indraratna, B., C. Rujikiatkamjorn, J. Ameratunga, and P. Boyle. 2011. “Performance and prediction of vacuum combined surcharge consolidation at port of Brisbane.” J. Geotech. Geoenviron. Eng. 137 (11): 1009–1018. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000519.
Indraratna, B., C. Rujikiatkamjorn, A. S. Bal-Asubramaniam, and V. Wijeyakulasuriya. 2005. “Predictions and observations of soft clay foundations stabilized with geosynthetic drains and vacuum surcharge.” In Vol. 3 of Ground improvement: Case histories, edited by B. Indraratna and J. Chu, 199–229. Amsterdam, Netherlands: Elsevier.
Jacob, A., S. Thevanayagam, and E. Kavajian. 1994. “Vacuum-assisted consolidation of a hydraulic landfill.” In Conf. on Vertical and Horizontal Deformations of Foundations and Embankments, edited by A. T. Yeung and G. Y. Felio, 1249–1261. Reston, VA: ASCE.
Karstunen, M., H. Krenn, S. J. Wheeler, M. Koskinen, and R. Zentar. 2005. “Effect of anisotropy and destructuration on the behavior of Murro test embankment.” Int. J. Geomech. 5 (2): 87–97. https://doi.org/10.1061/(ASCE)1532-3641(2005)5:2(87).
Karstunen, M., Z. Y. Yin, M. Koskinen, M. Leoni, and P. Vermeer. 2008. “Some recent developments in constitutive modelling of soft clays.” In Proc., 12th Int. Conf. of Int. Association for Computer Methods and Advances in Geomechanics, 966–975. Goa, India: International Association for Computer Methods and Advances in Geomechanics (IACMAG).
Kjellman, W. 1952. “Consolidation of clayey soils by atmospheric pressure.” In Conf. on Soil Stabilization, 258–263. Cambridge, MA: Massachussets Institute of Technology.
Koskinen, M., M. Karstunen, and S. J. Wheeler. 2002. “Modelling destructuration and anisotropy of a soft natural clay.” In Proc., 5th European Conf. on Numerical Methods in Geotechnical Engineering, 11–20. Paris, France: Presses de l'ENPC.
Leroueil, S., F. Tavenas, and J. P. Le Bihan. 1983. “Propriétés caractéristiques des argiles de l’est du Canada.” Can. Geotech. J. 20 (4): 681–705. https://doi.org/10.1139/t83-076.
Liu, J., H. Lei, G. Zheng, H. Zhou, and X. Zhang. 2017. “Laboratory model study of newly deposited dredger fills using improved multiple-vacuum preloading technique.” J. Rock Mech. Geotech. Eng. 9 (5): 924–935. https://doi.org/10.1016/j.jrmge.2017.03.003.
Long, P. V., L. V. Nguyen, and A. S. Balasubramaniam. 2016. “Performance and analyses of thick soft clay deposit improved by PVD with surcharge preloading and vacuum consolidation—A case study at CMIT.” In Proc., 19th Southeast Asian Geotechnical Conf. & 2nd AGSSEA Conf., 61–70. Kuala Lumpur, Malaysia: 19SEAGC & 2AGSSEA.
Long, P. V., L. V. Nguyen, D. T. Bergado, and A. S. Balasubramaniam. 2015. “Performance of PVD improved soft ground using vacuum consolidation methods with and without airtight membrane.” Geotext. Geomembr. 43 (6): 473–483. https://doi.org/10.1016/j.geotexmem.2015.05.007.
López-Acosta, N. P., A. L. Espinosa-Santiago, V. M. Pineda-Núñez, A. Ossa, M. J. Mendoza, E. Ovando-Shelley, and E. Botero. 2019. “Performance of a test embankment on very soft clayey soil improved with drain-to-drain vacuum preloading technology.” Geotext. Geomembr. 47 (5): 618–631. https://doi.org/10.1016/j.geotexmem.2019.103459.
Marques, M. E. S., and S. Leroueil. 2015. “Vacuum consolidation and vacuum consolidation with heating.” In Vol. 3 of Ground improvement series—Chemical, electrokinetic, thermal and bioengineering, edited by B. Indraratna, J. Chu, and C. Rujikiatkamjorn, 537–554. Amsterdam, Netherlands: Elsevier.
Marques, M. E. S., S. Leroueil, and M. S. S. Almeida. 2003. “Performance of instrumentation under vacuum consolidation and vacuum consolidation and heating.” In Proc., 12th Panamerican Conf. on Soil Mechanics and Geotechnical Engineering, edited by P. J. Culligan, H. H. Einstein, and A. J. Whittle, 2641–2648. Essen, Germany: Verlag Glückauf.
Marques, M. E. S., S. Leroueil, and M. S. S. Almeida. 2004. “Viscous behaviour of St-Roch-de-l’Achigan clay, Quebec.” Can. Geotech. J. 41 (1): 25–38. https://doi.org/10.1139/t03-068.
Mesri, G., and A. Q. Khan. 2012. “Ground improvement using vacuum loading together with vertical drains.” J. Geotech. Geoenviron. Eng. 138 (6): 680–689. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000640.
Ni, P., K. Xu, G. Mei, and Y. Zhao. 2019. “Effect of vacuum removal on consolidation settlement under a combined vacuum and surcharge preloading.” Geotext. Geomembr. 47 (1): 12–22. https://doi.org/10.1016/j.geotexmem.2018.09.004.
Oliveira, P. J. V., R. F. P. M. L. Cruz, L. J. L. Lemos, and J. N. V. Almeida e Souza. 2015. “Numeric modelling of vertical drains: Two- and three-dimensional analyses.” Proc. Inst. Civ. Eng. Ground Improv. 168 (2): 144–156. https://doi.org/10.1680/grim.13.00033.
Parsa-Pajouh, A., B. Fatahi, P. Vincent, and H. Khabbaz. 2014. “Trial embankment analysis to predict smear zone characteristics induced by prefabricated vertical drain installation.” Geotech. Geol. Eng. 32 (5): 1187–1210. https://doi.org/10.1007/s10706-014-9789-9.
Roscoe, K. H., and J. H. Burland. 1968. “On the generalized stress–strain behavior of wet clay.” In Engineering plasticity, edited by J. Heyman and F. A. Leckie, 535–609. Cambridge, UK: Cambridge University Press.
Rujikiatkamjorn, C., B. Indraratna, and J. Chu. 2007. “Numerical modelling of soft soil stabilized by vertical drains, combining surcharge and vacuum preloading for a storage yard.” Can. Geotech. J. 44 (3): 326–342. https://doi.org/10.1139/t06-124.
Saowapakpiboon, J., D. T. Bergado, P. Voottipruex, L. G. Lam, and K. Nakakuma. 2011. “PVD improvement combined with surcharge and vacuum preloading including simulations.” Geotext. Geomembr. 29 (1): 74–82. https://doi.org/10.1016/j.geotexmem.2010.06.008.
Sathananthan, I., and B. Indraratna. 2006. “Laboratory evaluation of smear zone and correlation between permeability and moisture content.” J. Geotech. Geoenviron. Eng. 132 (7): 942. https://doi.org/10.1061/(ASCE)1090-0241(2006)132:7(942).
Sathananthan, I., B. Indraratna, and C. Rujikiatkamjorn. 2008. “Evaluation of smear zone extent surrounding mandrel driven vertical drains using the cavity expansion theory.” Int. J. Geomech. 8 (6): 355–365. https://doi.org/10.1061/(ASCE)1532-3641(2008)8:6(355).
Sivasithamparam, N. 2012. “Development and implementation of advanced soft soil models in finite elements.” Ph.D. thesis, Dept. of Civil Engineering, Univ. of Strathclyde.
Stapelfeldt, T., P. Vepsäläinen, and Z. Y. Yin. 2008. “Numerical modelling of a test embankment on soft clay improved with vertical drains.” In Proc., 2nd Int. Workshop on Geotechnics of Soft Soils, 173–179. London: Taylor & Francis Group.
Sun, L., X. Gao, D. Zhuang, W. Guo, J. Hou, and X. Liu. 2018. “Pilot tests on vacuum preloading method combined with short and long PVDs.” Geotext. Geomembr. 46 (2): 243–250. https://doi.org/10.1016/j.geotexmem.2017.11.010.
Tavenas, F., P. Jean, P. Leblond, and S. Leroueil. 1983. “The permeability of natural soft clays. Part II: Permeability characteristics.” Can. Geotech. J. 20 (4): 645–660. https://doi.org/10.1139/t83-073.
Tavenas, F., and S. Leroueil. 1977. “Effects of stresses and time on yielding of clays.” In Proc., 9th Int. Conf. on Soil Mechanics and Foundation Engineering, 319–326. Tokyo, Japan: Japanese Society of Soil Mechanics and Foundation Engineering.
Tavenas, F., and S. Leroueil. 1980. “The behaviour of embankments on clay foundations.” Can. Geotech. J. 17 (2): 236–260. https://doi.org/10.1139/t80-025.
Vu, V., and Y. Yang. 2016. “Numerical modelling of soft ground improvement by vacuum preloading considering the varying coefficient of permeability.” Int. J. Geotech. Eng. 12 (3): 258–266. https://doi.org/10.1080/19386362.2016.1270793.
Wang, J., J. Ni, Y. Cai, H. Fu, and P. Wang. 2017. “Combination of vacuum preloading and lime treatment for improvement of dredged fill.” Eng. Geol. 227: 149–158. https://doi.org/10.1016/j.enggeo.2017.02.013.
Wheeler, S. J., A. Näätänen, M. Karstunen, and M. Lojander. 2003. “An anisotropic elastoplastic model for soft clays.” Can. Geotech. J. 40 (2): 403–418. https://doi.org/10.1139/t02-119.
Xu, Y., G. B. Ye, and Z. Zhang. 2018. “Consolidation analysis of soft soil by vacuum preloading considering groundwater table change.” In GeoShanghai 2018 Int. Conf.: Ground Improvement and Geosynthetics, 30–40. Singapore: Springer.
Yildiz, A., M. Karstunen, and H. Krenn. 2009. “Effect of anisotropy and destructuration on behavior of Haarajoki test embankment.” Int. J. Geomech. 9 (4): 153–168. https://doi.org/10.1061/(ASCE)1532-3641(2009)9:4(153).
Zhang, Z., G. B. Ye, and Y. Xu. 2018. “Comparative analysis on performance of vertical drain improved clay deposit under vacuum or surcharge loading.” Geotext. Geomembr. 46 (2): 146–154. https://doi.org/10.1016/j.geotexmem.2017.11.002.
Zheng, G., J. Liu, H. Lei, M. S. Rahman, and Z. Tan. 2017. “Improvement of very soft ground by a high-efficiency vacuum preloading method: A case study.” Mar. Georesour. Geotechnol. 35 (5): 631–642. https://doi.org/10.1080/1064119X.2016.1215363.
Zhou, W.-H., T. M. H. Lok, L.-S. Zhao, G. Mei, and X. B. Li. 2017. “Analytical solutions to the axisymmetric consolidation of a multi-layer soil system under surcharge combined with vacuum preloading.” Geotext. Geomembr. 45 (5): 487–449. https://doi.org/10.1016/j.geotexmem.2017.06.003.
Information & Authors
Information
Published In
International Journal of Geomechanics
Volume 21 • Issue 10 • October 2021
Copyright
© 2021 American Society of Civil Engineers.
History
Received: Nov 11, 2020
Accepted: Jun 4, 2021
Published online: Aug 9, 2021
Published in print: Oct 1, 2021
Discussion open until: Jan 9, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Xiaolei Wang, Zeyuan Wang, Changfeng Yuan, Libo Liu, Study on the Horizontal Bearing Characteristic of a New Type of Offshore Rubber Airbag Branch Pile, Sustainability, 10.3390/su14127331, 14, 12, (7331), (2022).