Adaptive Greenhouse with Thermochromic Material: Performance Evaluation in Cold Regions
Publication: Journal of Energy Engineering
Volume 146, Issue 4
Abstract
The intensive energy requirement is a major challenge for greenhouse producers, especially those located in cold regions. An adaptive greenhouse with thermochromic (TC) material has the potential to intelligently regulate solar radiation gain of the greenhouse in response to the outdoor environment, therefore abating energy demand of the greenhouse. This study evaluates the energy performance of an adaptive greenhouse with covering materials (TC glazing, TC film, TC film–TC glazing). The simulation results reveal that compared with normal glass, energy savings reaches up to 5%, 6%, and 13% with the application of TC glazing, TC film, and TC film–TC glazing to the greenhouse, respectively; the energy cost is correspondingly reduced by 7%, 17%, and 22% respectively; and the emission is reduced by 6%, 14%, and 20%, respectively. In comparison with low-emissivity glass, the total energy saving of the greenhouse reaches up to 3%, 3%, and 11% by employing TC glazing, TC film, and TC film–TC glazing, respectively. Moreover, the increase in envelope thickness increases energy efficiency of the adaptive greenhouse to 17%. TC film–TC glazing is recommended for use in heating energy–dominated scenarios. This research framework allows designers to optimize overall energy performance of the proposed adaptive greenhouse for different climates.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
The data sets generated or analyzed in the current study are available from the corresponding author on reasonable request, including the model for energy analysis, the annual and monthly energy consumption, energy-associated cost, and equivalent carbon emission.
Acknowledgments
This work was supported by the National Science Foundation (No. 1537289).
References
ANSI and ASHRAE (American National Standards Institute and American Society of Heating, Refrigerating and Air-Conditioning Engineers). 2002. Measurement of energy and demand savings. ASHRAE Guideline 14. Atlanta: ASHRAE.
ANSI, ASHRAE, USGBC, and IES (American National Standards Institute, American Society of Heating, Refrigerating and Air-Conditioning Engineers, US Green Building Council, and Illuminating Engineering Society). 2010. Standard for the design of high-performance green buildings. ASHRAE 189.1. Atlanta: ASHRAE.
ASTM. 2000. Standard solar constant and zero air mass solar spectral irradiance tables. ASTM E490. West Conshohocken, PA: ASTM.
Bamfield, P., and M. G. Hutchings. 2020. Chromic phenomena-technological applications of colour chemistry. 2nd ed., 47–58. Cambridge, UK: Royal Society of Chemistry.
Both, A. J. 2004. “Greenhouse temperature management: Temperature and scheduling.” Greenhouse Manage. Prod. (Apr): 38–42.
Cerny, T., J. Faust, D. Layne, and N. Rajapakse. 2003. “Influence of photoselective films and growing season on stem growth and flowering of six plant species.” J. Am. Soc. Hortic. Sci. 128 (4): 486–491. https://doi.org/10.21273/JASHS.128.4.0486.
Cook, R., and L. Calvin. 2005. “Greenhouse tomatoes change the dynamics of the North American fresh tomato industry.” Accessed May 13, 2011. https://www.ers.usda.gov/webdocs/publications/45465/15302_err2c_1_.pdf?v=41879.
Cuce, E., D. Harjunowibowo, and P. Cuce. 2016. “Renewable and sustainable energy saving strategies for greenhouse systems: A comprehensive review.” Renewable Sustainable Energy Rev. 64 (Oct): 34–59. https://doi.org/10.1016/j.rser.2016.05.077.
Cuce, E., C.-H. Young, and S. Riffat. 2015. “Thermal performance investigation of heat insulation solar glass: A comparative experimental study.” Energy Build. 86 (Jan): 595–600. https://doi.org/10.1016/j.enbuild.2014.10.063.
Emekli, N., K. Büyüktaş, and A. Başçetinçelik. 2016. “Changes of the light transmittance of the LDPE films during the service life for greenhouse application.” J. Build. Eng. 6 (Jun): 126–132. https://doi.org/10.1016/j.jobe.2016.02.013.
Fabrizio, E. 2012. “Energy reduction measures in agricultural greenhouses heating: Envelope, systems and solar energy collection.” Energy Build. 53 (Oct): 57–63. https://doi.org/10.1016/j.enbuild.2012.07.003.
Favoino, F., M. Overend, and Q. Jin. 2015. “The optimal thermo-optical properties and energy saving potential of adaptive glazing technologies.” Appl. Energy 156 (Oct): 1–15. https://doi.org/10.1016/j.apenergy.2015.05.065.
Halleux, D., J. Deltour, J. Nijskens, A. Nisen, and S. Coutisse. 1985. “Dynamic simulation of heat fluxes and temperature in horticultural and low emissivity glass-covered greenhouse.” Acta Hortic. 170 (9): 91–96. https://doi.org/10.17660/ActaHortic.1985.170.9.
Hassanien, R., M. Li, and F. Yin. 2018. “The integration of semi-transparent photovoltaics on greenhouse roof for energy and plant production.” Renewable Energy 121 (Jun): 377–388. https://doi.org/10.1016/j.renene.2018.01.044.
Hoffmann, S., E. Lee, and C. Clavero. 2014. “Examination of the technical potential of near-infrared switching thermochromic windows for commercial building applications.” Sol. Energy Mater. Sol. Cells 123 (Apr): 65–80. https://doi.org/10.1016/j.solmat.2013.12.017.
Hu, J. Y., Q. Goa, and X. Yu. 2015. “Characterization of the optical and mechanical properties of innovative multifunctional thermochromic asphalt binders.” J. Mater. Civ. Eng. 27 (5): 04014171. https://doi.org/10.1061/(ASCE)MT.1943-5533.0001132.
Hu, J. Y., and X. Yu. 2013. “Experimental study of sustainable asphalt binder: Influence of thermochromic materials.” Transp. Res. Rec. 2372 (1): 108–115. https://doi.org/10.3141/2372-12.
Hu, J. Y., and X. Yu. 2019. “Adaptive thermochromic roof system: Assessment of performance under different climates.” Energy Build. 192 (Jun): 1–14. https://doi.org/10.1016/j.enbuild.2019.02.040.
Karlessi, T., M. Santamouris, K. Apostolakis, A. Synnefa, and I. Livada. 2009. “Development and testing of thermochromic coatings for buildings and urban structures.” Sol. Energy 83 (4): 538–551. https://doi.org/10.1016/j.solener.2008.10.005.
Kavga, A., M. Souliotis, E. Koumoulos, P. Fokaides, and C. Charitidis. 2018. “Environmental and nanomechanical testing of an alternative polymer nanocomposite greenhouse covering material.” Sol. Energy 159 (Jan): 1–9. https://doi.org/10.1016/j.solener.2017.10.073.
Kempkes, F. L. K., and S. Hemming. 2012. “Calculation of NIR effect on greenhouse climate in various conditions.” Acta Hortic. 927 (66): 543–550. https://doi.org/10.17660/ActaHortic.2012.927.66.
Kittas, C., A. Baille, and P. Giaglaras. 1999. “Influence of covering material and shading on the spectral distribution of light in greenhouses.” J. Agric. Eng. Res. 73 (4): 341–351. https://doi.org/10.1006/jaer.1999.0420.
Kittas, C., M. Tchamitchian, N. Katsoulas, P. Karaiskou, and C. Papaioannou. 2006. “Effect of two UV-absorbing greenhouse-covering films on growth and yield of an eggplant soilless crop.” Sci. Hortic. 110 (1): 30–37. https://doi.org/10.1016/j.scienta.2006.06.018.
Li, S., N. C. Rajapakse, R. E. Young, and R. Oi. 2000. “Growth responses of chrysanthemum and bell pepper transplants to photoselective plastic films.” Sci. Hortic. 84 (3–4): 215–225. https://doi.org/10.1016/S0304-4238(99)00136-3.
Liang, R., Y. Sun, M. Aburas, R. Wilson, and Y. Wu. 2018. “Evaluation of the thermal and optical performance of thermochromic windows for office buildings in China.” Energy Build. 176 (Oct): 216–231. https://doi.org/10.1016/j.enbuild.2018.07.009.
Liu, C.-H., C. Ay, J.-C. Kan, and M.-T. Lee. 2018. “The effect of radiative cooling on reducing the temperature of greenhouses.” Materials 11 (7): 1166. https://doi.org/10.3390/ma11071166.
Oyaert, E., E. Volckaert, and P. Debergh. 1999. “Growth of chrysanthemum under coloured plastic films with different light qualities and quantities.” Sci. Hortic. 79 (3–4): 195–205. https://doi.org/10.1016/S0304-4238(98)00207-6.
Paço, A. D., and L. Varejão. 2010. “Factors affecting energy saving behaviour: A prospective research.” J. Environ. Plann. Manage. 53 (8): 963–976. https://doi.org/10.1080/09640568.2010.495489.
Rosencrantz, T., H. Bülow-Hübe, B. Karlsson, and A. Roos. 2005. “Increased solar energy and daylight utilisation using anti-reflective coatings in energy-efficient windows.” Sol. Energy Mater. Sol. Cells 89 (2–3): 249–260. https://doi.org/10.1016/j.solmat.2004.12.007.
Runkle, E., and A. Both. 2011. Greenhouse energy conservation strategies. East Lansing, MI: Michigan State Univ.
Saeli, M., C. Piccirillo, I. Parkin, R. Binions, and I. Ridley. 2010a. “Energy modelling studies of thermochromic glazing.” Energy Build. 42 (10): 1666–1673. https://doi.org/10.1016/j.enbuild.2010.04.010.
Saeli, M., C. Piccirillo, I. Parkin, I. Ridley, and R. Binions. 2010b. “Nano-composite thermochromic thin films and their application in energy-efficient glazing.” Sol. Energy Mater. Sol. Cells 94 (2): 141–151. https://doi.org/10.1016/j.solmat.2009.08.010.
Sonneveld, P. J., G. L. A. M. Swinkels, J. Campen, B. A. J. Tuijl, H. J. J. Janssen, and G. P. A. Bot. 2010. “Performance results of a solar greenhouse combining electrical and thermal energy production.” Biosyst. Eng. 106 (1): 48–57. https://doi.org/10.1016/j.biosystemseng.2010.02.003.
Tsormpatsidis, E., R. G. C. Henbest, F. J. Davis, N. H. Battey, P. Hadley, and A. Wagstaffe. 2008. “UV irradiance as a major influence on growth, development and secondary products of commercial importance in Lollo Rosso lettuce ‘Revolution’ grown under polyethylene films.” Environ. Exp. Bot. 63 (1–3): 232–239. https://doi.org/10.1016/j.envexpbot.2007.12.002.
Warwick, M., I. Ridley, and R. Binions. 2014. “The effect of transition gradient in thermochromic glazing systems.” Energy Build. 77 (Jul): 80–90. https://doi.org/10.1016/j.enbuild.2014.03.044.
Ye, H., L. Long, H. Zhang, B. Xu, Y. Gao, L. Kang, and Z. Chen. 2013. “The demonstration and simulation of the application performance of the vanadium dioxide single glazing.” Sol. Energy Mater. Sol. Cells 117 (Oct): 168–173. https://doi.org/10.1016/j.solmat.2013.05.061.
Yildirim, N., and L. Bilir. 2017. “Evaluation of a hybrid system for a nearly zero energy greenhouse.” Energy Convers. Manage. 148 (Sep): 1278–1290. https://doi.org/10.1016/j.enconman.2017.06.068.
Information & Authors
Information
Published In
Copyright
©2020 American Society of Civil Engineers.
History
Received: Aug 31, 2019
Accepted: Mar 13, 2020
Published online: May 31, 2020
Published in print: Aug 1, 2020
Discussion open until: Oct 31, 2020
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.