Impact of Inherent Magnesium in Biochar for Phosphate Removal from Reclaimed Water Streams
Publication: Journal of Environmental Engineering
Volume 148, Issue 2
Abstract
In water treatment processes, the use of biochars has risen due to their relative abundance, sustainability, and low cost compared with conventional technologies. The objective of this work was to investigate the physical and chemical properties of six chars that promote phosphate removal. The chars were further engineered with magnesium chloride (engineering biochars) prior to heat treatment to increase removal of phosphate. The impregnated magnesium was converted to magnesium oxide (MgO) under inert conditions at temperatures greater than 450°C. The solutions were analyzed using an ultraviolet visible spectrophotometer at 810 nm for phosphate concentration. To simulate real-world municipal water reuse applications, reclaimed wastewater was used as the source water for the experiments. Thermally treated sugar beet pellets were converted to biochar with inherent magnesium content, and demonstrated removal of more than 85% when pyrolyzed at greater than or equal to 550°C for 15 min. Dosing of MgO increased the solution pH, thus having phosphate species as and , and bound the hydrated as and . The porosity of biochar is not solely responsible for phosphate removal but is required after impregnation of magnesium for increasing accessibility. Contact pH is a good indicator of biochar performance. MgO was shown to be an excellent sorbent for phosphate removal in reclaimed water when impregnated as and dosed separately with biochar.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
All data that support the findings of this study are available from the corresponding author upon reasonable request.
Acknowledgments
This material is based upon work supported by Progressive Water in partnership with Braden River Utilities. We also thank the Southwest Water Management District for supporting the goals of this research.
References
ASTM. 2014. Standard test method for volatile matter content of activated carbon samples. ASTM D5832-98. Reston, VA: ASCE.
ASTM. 2018a. Standard test method for mechanically tapped density of activated carbon (powdered and fine mesh). ASTM D8176-18. Reston, VA: ASCE.
ASTM. 2018b. Standard test method for total ash content of activated carbon. ASTM D2866-11. Reston, VA: ASCE.
ASTM. 2020. Standard test method for determination of contact pH with activated carbon. ASTM D6851-20. Reston, VA: ASCE.
Benjamin, M. M. 2014. Water chemistry. Long Grove, IL: Waveland Press.
Bunce, J. T., E. Ndam, I. D. Ofiteru, A. Moore, and D. W. Graham. 2018. “A review of phosphorus removal technologies and their applicability to small-scale domestic wastewater treatment systems.” Front. Environ. Sci. 6 (Feb): 8. https://doi.org/10.3389/fenvs.2018.00008.
Cakmak, I., and A. M. Yazici. 2010. “Magnesium: A forgotten element in crop production.” Better Crops 94 (2): 23–25.
Farhat, N., A. Elkhouni, W. Zorrig, A. Smaoui, C. Abdelly, and M. Rabhi. 2016. “Effects of magnesium deficiency on photosynthesis and carbohydrate partitioning.” Acta Physiologiae Plant. 38 (6): 145. https://doi.org/10.1007/s11738-016-2165-z.
Giaquinta, R. T. 1979. “Sucrose translocation and storage in the sugar beet.” Plant Physiol. 63 (5): 828–832. https://doi.org/10.1104/pp.63.5.828.
Heisler, J., et al. 2008. “Eutrophication and harmful algal blooms: A scientific consensus.” Harmful Algae 8 (1): 3–13. https://doi.org/10.1016/j.hal.2008.08.006.
Hermans, C., G. N. Johnson, R. J. Strasser, and N. Verbruggen. 2004. “Physiological characterisation of magnesium deficiency in sugar beet: Acclimation to low magnesium differentially affects photosystems I and II.” Planta 220 (2): 344–355. https://doi.org/10.1007/s00425-004-1340-4.
Huang, Q., G. Lu, J. Wang, and J. Yu. 2011. “Thermal decomposition mechanisms of and .” J. Anal. Appl. Pyrolysis 91 (1): 159–164. https://doi.org/10.1016/j.jaap.2011.02.005.
Li, R., J. J. Wang, B. Zhou, Z. Zhang, S. Liu, S. Lei, and R. Xiao. 2017. “Simultaneous capture removal of phosphate, ammonium and organic substances by MgO impregnated biochar and its potential use in swine wastewater treatment.” J. Cleaner Prod. 147 (Mar): 96–107. https://doi.org/10.1016/j.jclepro.2017.01.069.
Lowell, S., J. E. Shields, M. A. Thomas, and M. Thommes. 2004. Vol. 16 of Characterization of porous solids and powders: Surface area, pore size and density. Dordrecht, Netherlands: Springer.
Magdum, S., and V. Kalyanraman. 2017. “Existing biological nitrogen removal processes and current scope of advancement.” Res. J. Chem. Environ. 21 (7): 43–53.
Maroušek, J., et al. 2020. “Modified biochars present an economic challenge to phosphate management in wastewater treatment plants.” J. Cleaner Prod. 272 (Nov): 123015. https://doi.org/10.1016/j.jclepro.2020.123015.
Maroušek, J., L. Kolář, M. Vochozka, V. Stehel, and A. Maroušková. 2018. “Biochar reduces nitrate level in red beet.” Environ. Sci. Pollut. Res. Int. 25 (18): 18200–18203. https://doi.org/10.1007/s11356-018-2329-z.
Maroušek, J., O. Strunecký, and V. Stehel. 2019. “Biochar farming: Defining economically perspective applications.” Clean Technol. Environ. Policy 21 (7): 1389–1395. https://doi.org/10.1007/s10098-019-01728-7.
Maroušek, J., M. Vochozka, J. Plachý, and J. Žák. 2017. “Glory and misery of biochar.” Clean Technol. Environ. Policy 19 (2): 311–317. https://doi.org/10.1007/s10098-016-1284-y.
Muo, I., and A. A. Azeez. 2019. “Green entrepreneurship: Literature review and agenda for future research.” Int. J. Entrep. Knowl. 7 (2): 17–29. https://doi.org/10.37335/ijek.v7i2.90.
Németh, Z., L. Gáncs, G. Gémes, and A. Kolics. 1998. “pH dependence of phosphate sorption on aluminum.” Corros. Sci. 40 (12): 2023–2027. https://doi.org/10.1016/S0010-938X(98)00089-4.
Novais, S. V., M. D. O. Zenero, J. Tronto, R. F. Conz, and C. E. P. Cerri. 2018. “Poultry manure and sugarcane straw biochars modified with for phosphorus adsorption.” J. Environ. Manage. 214 (May): 36–44. https://doi.org/10.1016/j.jenvman.2018.02.088.
Ren, J., N. Li, L. Li, J.-K. An, L. Zhao, and N.-Q. Ren. 2015. “Granulation and ferric oxides loading enable biochar derived from cotton stalk to remove phosphate from water.” Bioresour. Technol. 178 (Feb): 119–125. https://doi.org/10.1016/j.biortech.2014.09.071.
Rodriguez-Reinoso, F., M. Molina-Sabio, and M. A. Munecas. 1992. “Effect of microporosity and oxygen surface groups of activated carbon in the adsorption of molecules of different polarity.” J. Phys. Chem. 96 (6): 2707–2713. https://doi.org/10.1021/j100185a056.
Stávková, J., and J. Maroušek. 2021. “Novel sorbent shows promising financial results on P recovery from sludge water.” Chemosphere 276 (Aug): 130097. https://doi.org/10.1016/j.chemosphere.2021.130097.
Su, Y., H. Cui, Q. Li, S. Gao, and J. K. Shang. 2013. “Strong adsorption of phosphate by amorphous zirconium oxide nanoparticles.” Water Res. 47 (14): 5018–5026. https://doi.org/10.1016/j.watres.2013.05.044.
Tan, X., Y. Liu, G. Zeng, X. Wang, X. Hu, Y. Gu, and Z. Yang. 2015. “Application of biochar for the removal of pollutants from aqueous solutions.” Chemosphere 125 (Apr): 70–85. https://doi.org/10.1016/j.chemosphere.2014.12.058.
Tanada, S., M. Kabayama, N. Kawasaki, T. Sakiyama, T. Nakamura, M. Araki, and T. Tamura. 2003. “Removal of phosphate by aluminum oxide hydroxide.” J. Colloid Interface Sci. 257 (1): 135–140. https://doi.org/10.1016/S0021-9797(02)00008-5.
Tang, J., W. Zhu, R. Kookana, and A. Katayama. 2013. “Characteristics of biochar and its application in remediation of contaminated soil.” J. Biosci. Bioeng. 116 (6): 653–659. https://doi.org/10.1016/j.jbiosc.2013.05.035.
Yang, X., X. Wu, H. Hao, and Z. He. 2008. “Mechanisms and assessment of water eutrophication.” J. Zhejiang Univ. Sci. B 9 (3): 197–209. https://doi.org/10.1631/jzus.B0710626.
Yao, Y., B. Gao, J. Chen, M. Zhang, M. Inyang, Y. Li, A. Alva, and L. Yang. 2013. “Engineered carbon (biochar) prepared by direct pyrolysis of Mg-accumulated tomato tissues: Characterization and phosphate removal potential.” Bioresour. Technol. 138 (Jun): 8–13. https://doi.org/10.1016/j.biortech.2013.03.057.
Yao, Y., B. Gao, M. Zhang, M. Inyang, and A. R. Zimmerman. 2012. “Effect of biochar amendment on sorption and leaching of nitrate, ammonium, and phosphate in a sandy soil.” Chemosphere 89 (11): 1467–1471. https://doi.org/10.1016/j.chemosphere.2012.06.002.
Yin, Q., B. Zhang, R. Wang, and Z. Zhao. 2017. “Biochar as an adsorbent for inorganic nitrogen and phosphorus removal from water: A review.” Environ. Sci. Pollut. Res. Int. 24 (34): 26297–26309. https://doi.org/10.1007/s11356-017-0338-y.
Zhang, M., B. Gao, Y. Yao, Y. Xue, and M. Inyang. 2012. “Synthesis of porous MgO-biochar nanocomposites for removal of phosphate and nitrate from aqueous solutions.” Chem. Eng. J. 210 (Nov): 26–32. https://doi.org/10.1016/j.cej.2012.08.052.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 148 • Issue 2 • February 2022
Copyright
© 2021 American Society of Civil Engineers.
History
Received: Apr 11, 2021
Accepted: Aug 19, 2021
Published online: Dec 11, 2021
Published in print: Feb 1, 2022
Discussion open until: May 11, 2022
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.
Cited by
- Yifan Ding, David A. Sabatini, Elizabeth C. Butler, Effects of pH and Soil Minerals on Phosphorus Release from Agricultural Waste–Based Sorbents: A Continuous-Flow Column Study, Journal of Environmental Engineering, 10.1061/JOEEDU.EEENG-7102, 149, 4, (2023).
- Jihoon Kang, Jason Parsons, Sampath Gunukula, Dat T. Tran, Iron and Magnesium Impregnation of Avocado Seed Biochar for Aqueous Phosphate Removal, Clean Technologies, 10.3390/cleantechnol4030042, 4, 3, (690-702), (2022).