Biodegradation of TCP in a Sequencing Batch-Fluidized Bed Bioreactor with Waste Coke Particles as the Carrier
Publication: Journal of Environmental Engineering
Volume 139, Issue 9
Abstract
This study investigated the biodegradation of synthetic wastewater containing 2,4,6-trichlorophenol (TCP) in a sequencing batch-fluidized bed bioreactor (SBFBBR) with waste coke particles (WCPs) as the biofilm carrier. The irregular surfaces of WCPs (diameter range from 0.6 to 2.3 mm) rendered them ideal biomass carriers. The attached biomass was 4.0–4.5 mg volatile suspended solids WCPs 3 weeks after reactor start-up, and the biofilm thicknesses were 35–110 μm. Biodegradation, not adsorption-degradation or volatilization-degradation, was found to be the main TCP removal mechanism. At the initial chemical oxygen demand (COD) concentration of , removal of COD was more efficient and faster than that of TCP. The air-water ratio (ranging from 0.280 to ) exerted negligible effects at dissolved oxygen (DO) concentrations above . Maximum TCP degradation (62.1% after 3 h retention time and 75.8% after 6 h) occurred at initial COD concentration of . TCP can be removed by biofilm as a sole source of carbon and energy. Furthermore, the TCP biodegradation follows zero-order reaction kinetics, with the zero-order specific biodegradation rate dependent on initial COD concentration.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This research was supported by the National Science and Technology Pillar Program of China (2009BAA20B02) and Zhejiang Province Environmental Pollution Control Technology Research Laboratory (D1091105).
References
Androulaki, E., et al. (2000). “Light induced elimination of mono- and polychlorinated phenols from aqueous solutions by . The case of 2,4,6-trichlorophenol.” Environ. Sci. Technol., 34(10), 2024–2028.
Atta, A., Razzak, S. A., Nigam, K. D. P., and Zhu, J. X. (2009). “(Gas)-liquid-solid circulating fluidized bed reactors: Characteristics and applications.” Ind. Eng. Chem. Res., 48(17), 7876–7892.
Baban, A., Yediler, A., Avaz, G., and Hostede, S. S. (2010). “Biological and oxidative treatment of cotton textile dye-bath effluents by fixed and fluidized bed reactors.” Bioresour. Technol., 101(4), 1147–1152.
Benitez, F. J., Beltran-Heredia, J., Acero, J. L., and Rubio, F. J. (1999). “Chemical decomposition of 2,4,6-trichlorophenol by ozone, Fenton’s reagent, and UV radiation.” Ind. Eng. Chem. Res., 38(4), 1341–1349.
Chaliha, S., and Bhattacharyya, K. G. (2008). “Wet oxidative method for removal of 2,4,6-trichlorophenol in water using Fe(III), Co(II), Ni(II) supported MCM41 catalysts.” J. Hazard. Mater., 150(3), 728–736.
Chen, G. C., et al. (2009). “Adsorption of 2,4,6-trichlorophenol by multi-walled carbon nanotubes as affected by Cu(II).” Water Res., 43(9), 2409–2418.
Chinese National Standard. (1989). “Water quality-determination of the chemical oxygen demand-Dichromate method.” GB 11914-89, 280–283.
Choi, J. H., Kim, Y. H., and Choi, S. J. (2007). “Reductive dechlorination and biodegradation of 2,4,6-trichlorophenol using sequential permeable reactive barriers: Laboratory studies.” Chemosphere, 67(8), 1551–1557.
Chowdhury, N., Nakhla, G., Zhu, J., and lslam, M. (2010). “Pilot-scale experience with biological nutrient removal and biomass yield reduction in a liquid-solid circulating fluidized bed bioreactor.” Water Environ. Res., 82(9), 772–781.
Chowdhury, N., Zhu, J., Nakhla, G., Patel, A., and Islam, M. (2009). “A novel liquid-solid circulating fluidized-bed bioreactor for biological nutrient removal from municipal wastewater.” Chem. Eng. Technol., 32(3), 364–372.
Claudio, G. O., Elvira, R. L., Jaime, G. M., and Héctor, M. P. V. (2005). “2,4,6-Trichlorophenol and phenol removal in methanogenic and partically-aerated methanogenic conditions in a fluidized bed bioreactor.” J. Chem. Technol. Biotechnol., 80, 1180–1187.
Clesceri, L. S., Greenberg, A. E., and Eaton, A. D. (1998). Standard methods for examination of water and wastewater, 20th Ed., American Public Health Association, Washington, DC.
Eker, S., and Kargi, F. (2008). “COD, 2,4,6-trichlorophenol (TCP) and toxicity removal from synthetic wastewater in a rotating perforated-tubes biofilm reactor.” J. Hazard. Mater., 159(2–3), 306–312.
Gallego, A., et al. (2009). “Detoxification of 2,4,6-trichlorophenol by an indigenous bacterial community.” Int. Biodeterior. Biodegrad., 63(8), 1073–1078.
Gardin, H., Lebeault, J. M., and Pauss, A. (2001). “Degradation of 2,4,6-trichlorophenol (2,4,6-TCP) by co-immobilization of anaerobic and aerobic microbial communities in an upflow reactor under air-limited conditions.” Appl. Microbiol. Biotechnol., 56(3–4), 524–530.
Hidalgo, M. D., and García-Encina, P. A. (2002). “Biofilm development and bed segregation in a methanogenic fluidized bed reactor.” Water Res., 36(12), 3083–3091.
Islam, M., Nakhla, G., Zhu, J., and Chowdhury, N. (2009). “Impact of carbon to nitrogen ratio on nutrient removal in a liquid-solid circulating fluidized bed bioreactor (LSCFB).” Process Biochem., 44(5), 578–583.
Kharoune, L., Kharoune, M., and Lebeault, J. M. (2002). “Aerobic degradation of 2,4,6-trichlorophenol by a microbial consortium-selection and characterization of microbial consortium.” Appl. Microbiol. Biotechnol., 59(1), 112–117.
Kim, J., et al. (2011). “Anaerobic fluidized bed membrane bioreactor for wastewater treatment.” Environ. Sci. Technol., 45(2), 576–581.
Kiyohara, H., Hatta, T., Ogawa, Y., Kakuda, T., Yokoyama, H., and Takizawa, N. (1992). “Isolation of Pseudomonas pickettii strains that degrade 2,4,6-trichlorophenol and their dechlorination of chlorophenols.” Appl. Environ. Microbiol., 58(4), 1276–1283.
Lendenmann, U., Spain, J. C., and Smets, B. F. (1998). “Simultaneous biodegradation of 2,4-dinitrotoluene and 2,6-dinitrotoluene in an aerobic fluidized-bed biofilm reactor.” Environ. Sci. Technol., 32(1), 82–87.
Li, D. Y., Eberspächer, J., Wagner, B., Kuntzer, J., and Lingens, F. (1991). “Degradation of 2,4,6-trichlorophenol by Azotobacter sp. strain GP1.” Appl. Environ. Microbiol., 57(7), 1920–1928.
Montalvo, S., Guerrero, L., Borja, R., Cortés, I., Sánchez, E., and Colmenarejo, M. F. (2010). “Effect of the influent COD concentration on the anaerobic digestion of winery wastewaters from grape-red and tropical fruit (guava) wine production in fluidized bed reactors with Chilean natural zeolite for biomass immobilization.” Chem. Biochem. Eng. Q., 24(2), 219–226.
Pamukoglu, M. Y., and Kargi, F. (2008). “Biodegradation kinetics of 2,4,6-trichlorophenol by Rhodococcus rhodochrous in batch culture.” Enzyme Microb. Technol., 43(1), 43–47.
Pandit, A. B., Gogate, P. R., and Mujumdar, S. (2001). “Ultrasonic degradation of trichlorophenol in presence of catalyst.” Ultrason. Sonochem., 8(3), 227–231.
Papazi, A., and Kotzabasis, K. (2007). “Bioenergetic strategy for the biodegradation of phenolic compounds-Exogenously supplied energy and carbon sources adjust the level of biodegradation.” J. Biotechnol., 129(4), 706–716.
Patel, A., Zhu, J., and Nakhla, G. (2006). “Simultaneous carbon, nitrogen and phosphorous removal from municipal wastewater in a circulating fluidized bed bioreactor.” Chemosphere, 65(7), 1103–1112.
Patel, A., Zuo, G., Lehman, S. G., Badruzzaman, M., Clifford, D. A., and Roberts, D. J. (2008). “Fluidized bed reactor for the biological treatment of ion-exchange brine containing perchlorate and nitrate.” Water Res., 42(16), 4291–4298.
Sevillano, X., Isasi, J. R., and Peñas, F. J. (2008). “Feasibility study of degradation of phenol in a fluidized bed bioreactor with a cyclodextrin polymer as biofilm carrier.” Biodegradation, 19(4), 589–597.
Sittig, M. (1981). Handbook of toxic and hazardous chemicals, Noyes Publications, Park Ridge, NJ.
Snyder, C. J. P., Asghar, M., Scharer, J. M., and Legge, R. L. (2006). “Biodegradation kinetics of 2,4,6-trichlorophenol by an acclimated mixed microbial culture under aerobic conditions.” Biodegradation, 17(6), 535–544.
Tan, I. A. W., Ahmad, A. L., and Hameed, B. H. (2008). “Preparation of activated carbon from coconut husk: Optimization study on removal of 2,4,6-trichlorophenol using response surface methodology.” J. Hazard. Mater., 153(1–2), 709–717.
Tan, I. A. W., Ahmad, A. L., and Hameed, B. H. (2009). “Adsorption isotherms, kinetics, thermodynamics and desorption studies of 2,4,6-trichlorophenol on oil palm empty fruit bunch-based activated carbon.” J. Hazard. Mater., 164(2–3), 473–482.
Tzou, Y. M., Wang, S. L., Liu, J. C., Huang, Y. Y., and Chen, J. H. (2008). “Removal of 2,4,6-trichlorophenol from a solution by humic acids repeatedly extracted from a peat soil.” J. Hazard. Mater., 152(2), 812–819.
Wiese, F. W., Chang, H. C., Lloyd, R. V., Freeman, J. P., and Samokyszyn, V. M. (1998). “Peroxidase-catalyzed oxidation of 2,4,6-trichlorophenol.” Arch. Environ. Contam. Toxicol., 34(3), 217–222.
Yao, B., Jin, Z. F., Hu, Z. C., Jin, Q., and Pan, Z. Y. (2011). “Biodegradation characteristics of 2,4,6-trichlorophenol by photosynthetic bacteria.” J. Environ. Sci. China, 31(10), 1669–1675.
Information & Authors
Information
Published In
Copyright
© 2013 American Society of Civil Engineers.
History
Received: May 12, 2012
Accepted: Apr 23, 2013
Published online: Apr 25, 2013
Published in print: Sep 1, 2013
Discussion open until: Sep 25, 2013
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.