Electron Beam Irradiation for Mercury Oxidation and Mercury Emissions Control
Publication: Journal of Environmental Engineering
Volume 136, Issue 5
Abstract
A variety of air pollution control strategies have been investigated to reduce mercury emissions from coal-fired sources. The most developed and deployed technologies are based on adsorption of mercury onto powdered activated carbon followed by carbon collection. Mercury oxidation over selective catalytic reduction catalysts followed by wet scrubbing is another potential technique, and tests suggest that emissions reductions of are possible, but test results are variable and ultrahigh removal is unusual. The objective of this study was to investigate the effectiveness of electron beam irradiation to oxidize mercury vapor, to improve mercury removal with wet scrubbers or wet electrostatic precipitators (ESPs). Metallic mercury vapor samples in air and other atmospheres were prepared at concentrations of approximately . Samples were electron irradiated at energy levels of 2.5–10 kGy, equivalent to stack gas. Results show that mercury oxidation rate was dependent on both the gaseous atmosphere composition and the irradiation energy level. At medium energy levels, approximately 98% of gaseous mercury vapor was readily oxidized. Electron beam irradiation demonstrated high levels of mercury oxidation at the bench scale, and the technology might help improve mercury removal in wet scrubbers or wet ESPs when employed as a primary or secondary mercury oxidation technique.
Get full access to this article
View all available purchase options and get full access to this article.
References
Albers, P. H., Koterba, M. T., Rossmann, R., Link, W. A., French, J. B., Bennett, R. S., and Bauer, W. C. (2007). “Effects of methylmercury on reproduction in american kestrels.” Envir. Toxicol. Chem., 26, 1856–1866.
Barboni, M. T., da Costa, M. F., Moura, A. L., Feitosa-Santana, C., Gualtieri, M., Lago, M., Medrado-Faria, M. D., Silveira, L. C., and Ventura, D. F. (2008). “Visual field losses in workers exposed to mercury vapor.” Environ. Res., 107, 124–131.
Blythe, G., Richardson, C., and Rhudy, D. (2002). “Pilot testing of mercury oxidation catalysts for upstream of wet FGD systems.” Quarterly Technical Progress Rep. No. DE-FC26–01NT41185, Department of Energy, Pittsburgh.
Burnett, J. K. (2006). “Clean air mercury rule: Multipollutant approach to power plant pollution.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Baltimore.
Chang, J., and Ghorishi, S. B. (2003). “Why does flue gas elemental mercury concentration increase across a wet scrubber?” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Washington, D.C.
Feeley, T. J. (2006). “U.S. DOE’s Hg control technology RD&D program—Making great strides, but more to be done.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Baltimore.
Feeley, T. J., Murphy, J. T., Hoffman, J. W., Granite, E. J., and Renninger, S. A. (2003). “DOE/NETL’s mercury control technology research program for coal-fired power plants.” Environ. Manage. (N.Y.), February, 16–23.
Ghorishi, S. B., Renninger, S. A., Farthing, G. A., Teets, C., Neureuter, J. A., Hastings, T. W., and DiFrancesco, C. E. (2005). “Effects of SCR catalyst and wet FGD Additive on the speciation and removal of mercury within a forced-oxidized limestone scrubber.” Proc., ICAC Forum ’05, ICAC, Baltimore.
Gopalakrishnan, S., Thilagam, H., and Raja, P. V. (2008). “Comparison of heavy metal toxicity in life stages (spermiotoxicity, egg toxicity, embryotoxicity and larval toxicity) of hydroides elegans.” Chemosphere, 71, 515–528.
Granite, E. J., King, W. P., Stanko, D. C., and Pennline, H. W. (2008). “Implications of mercury interactions with band-gap semiconductor oxides.” Main Group Chemistry, 7, 227–237.
Granite, E. J., and Pennline, H. W. (2002). “Photochemical removal of mercury from flue gas.” Ind. Eng. Chem. Res., 41, 5470–5476.
Hakoda, T., Yang, M., Hirota, K., and Hashimoto, S. (1998). “Decomposition of volatile organic compounds in air by electron beam and gamma ray irradiation.” J. Adv. Oxid. Technol., 3, 79–86.
Hocquel, M., Unterberger, S., and Hein, K. R. (2002). “Effect of mercury on SCR-catalysts.” Proc., Conf. on Selective Catalytic Reduction (SCR) and Non-Catalytic Reduction (SNCR) for Control, Department of Energy, Pittsburgh.
Hutson, N., Singer, C., Richardson, C., Karwowski, J., and Sedman, C. (2004). “Practical applications from observations of mercury oxidation and binding mechanisms.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Washington, D.C.
Jun, J., Kim, J. C., Shin, J. H., Lee, K. W., and Baek, Y. S. (2004). “Effect of electron beam irradiation on reforming or methane over catalysts.” Radiat. Phys. Chem., 71, 1095–1101.
Keeler, G., and Landis, M. (1994) “Standard operating procedure for analysis of vapor phase mercury.” EPA Laboratory Methods, 2-405-419, Research Triangle Park, N.C.
Kim, J., Han, B., Kim, Y., Lee, J. H., Park, C. R., Kim, J. C., Kim, J. C., and Kim, K. J. (2004). “Removal of VOCs by hybrid electron beam reactor with catalyst bed.” Radiat. Phys. Chem., 71, 429–432.
Kim, J. C. (2002). “Factors affecting aromatic VOC removal by electron beam treatment.” Radiat. Phys. Chem., 65, 429–435.
Kim, J. C., Getoff, N., and Jun, J. (2006). “Catalytic conversion of mixture into synthetic gas-effect of electron-beam radiation.” Radiat. Phys. Chem., 75, 243–246.
Kim, K. H., Ebinghaus, R., Schroeder, W. H., Blanchard, P., Kock, H. H., Steffen, A., Froude, F. A., Kim, M. Y., Hong, S., and Kim, J. H. (2005a). “Atmospheric mercury concentrations from several observatory sites in the Northern Hemisphere.” J. Atmos. Chem., 50, 1–24.
Kim, K. H., and Kim, M. Y. (1999). “The exchange of gaseous mercury across the soil-air interface in a residential area of Seoul, Korea.” Atmos. Environ., 33, 3153–3165.
Kim, K. H., and Kim, M. Y. (2001). “The temporal distribution characteristics of total gaseous mercury at an urban monitoring site in Seoul during 1999 to 2000.” Atmos. Environ., 35, 4253–4263.
Kim, K. H., and Lindberg, S. E. (1994). “High precision measurements of mercury vapor in air: Design of a six-port manifold mass flow controller system and evaluation of mass flow errors at atmospheric pressure.” J. Geophys. Res., 99(D3), 5379–5384.
Kim, K. J., Kim, J. C., Kim, J., and Sunwoo, Y. (2005b). “Development of hybrid technology using E-beam and catalyst for aromatic VOCs control.” Radiat. Phys. Chem., 73, 85–90.
Laudal, D. L., Thompson, J. S., Pavlish, J. H., Brickett, L., Chu, P., Srivastava, R. K., Lee, C. W., and Kilgore, J. (2003). “Mercury speciation at power plants using SCR and SNCR control technologies.” Environ. Manage. (N.Y.), 16–22.
Laudal, D. L., Thompson, J. S., and Wocken, C. A. (2004). “Selective catalytic reduction mercury field sampling project.” Final Rep. Prepared for DOE Cooperative Agreement, Department of Energy, Pittsburgh.
Lee, C. W., Serre, S. D., Zhao, Y., Lee, S. J., and Hastings, T. W. (2008). “Mercury oxidation promoted by a selective catalytic reduction catalyst under simulated powder river basin coal combustion conditions.” J. Air Waste Manage. Assoc., 58, 484–493.
Lee, C. W., Srivastava, R. K., Ghorishi, B., Karwowski, J., Hastings, T. W., and Hirschi, J. (2004). “Effect of SCR catalyst on mercury speciation.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Washington, D.C.
McLarnon, C. R., Granite, E. J., and Pennline, H. W. (2005). “The PCO process for photochemical removal of mercury from flue gas.” Fuel Process. Technol., 87, 85–89.
McLarnon, C. R., and Steen, D. (2003) “Combined SO2, NOx, PM, and Hg removal from coal fired boilers.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Washington, D.C.
Pavlish, J., Thompson, J., Martin, C., Wiemuth, B., and Pletcher, S. (2006). “Field testing of activated carbon injection options for mercury control at TXU’s Big Brown Station.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Baltimore.
Penetrante, B. M., Hsiao, M. C., Bardsley, J. N., Merritt, B. T., Vogtlin, A., Kuthi, G. E., Burkhart, C. P., and Bayless, J. R. (1998). “Primary decomposition mechanism in electron-beam and electrical discharge procession of volatile organic compounds.” Environmental applications of ionizing radiation, Wiley, New York, 305–323.
Senior, C. (2004) “Oxidation of mercury across SCR catalysts in coal-fired power Plants burning low rank fuels.” Quarterly Progress Rep. Prepared for DOE Cooperative Agreement, Department of Energy, Pittsburgh.
Spadaro, J. V., and Rabl, A. (2008). “Global health impacts and costs due to mercury emissions.” Risk Anal., 28, 603–613.
Srivastava, R. K. (2004). “Status of mercury control technologies for coal-fired power plants.” Proc., MIT Air Toxics Symp., Massachusetts Institute of Technology, Cambridge, Mass.
Srivastava, R. K., Lee, C. W., Ghorishi, B., Jozewicz, W., and Hastings, T. W. (2003). “Evaluation of SCR catalysts for combined control of NOx and mercury—Final technical report.” Project Rep. No. 02–1/2.2A–1, ICCI, Carterville, Ill.
Srivastava, R. K., Staudt, J. E., and Jozewicz, W. (2004) “Preliminary estimates of performance and cost of mercury emission control technology applications on electric utility boilers.” Proc., Joint EPRI-DOE-EPA Combined Utility Air Pollutant Control Symp., The MEGA Symp., EPRI-DOE-EPA, Washington, D.C.
Srivastava, R. K., Staudt, J. E., and Jozewicz, W. (2005). “Preliminary estimates of performance and cost of mercury emission control technology applications on electric utility boilers: An update.” Environ. Prog., 24, 198–213.
Yang, H. M., and Pan, W. P. (2007). “Transformation of mercury speciation through the SCR system in power plants.” J. Environ. Sci. (China), 19, 181–184.
Information & Authors
Information
Published In
Copyright
© 2010 ASCE.
History
Received: Nov 24, 2008
Accepted: Oct 26, 2009
Published online: Oct 31, 2009
Published in print: May 2010
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.