Ceramic Filter for Small System Drinking Water Treatment: Evaluation of Membrane Pore Size and Importance of Integrity Monitoring
Publication: Journal of Environmental Engineering
Volume 135, Issue 11
Abstract
Ceramic filtration has recently been identified as a promising technology for drinking water treatment in households and small communities. This paper summarizes the results of a pilot-scale study conducted at the U.S. Environmental Protection Agency’s (EPA) Test & Evaluation (T&E) Facility in Cincinnati on two ceramic filtration cartridges with pore sizes of 0.05 and to evaluate their ability to remove turbidity and microbiological contaminants such as bacteria [Bacillus subtilis and Escherichia coli ], Cryptosporidium oocysts , polystyrene latex (PSL) beads (a surrogate for Cryptosporidium), and MS2 bacteriophage (a surrogate for enteric viruses). The results demonstrated that the relatively tighter cartridge performed better than the cartridge in removing all the biological contaminants and surrogates. For turbidity removal, the cartridge performed slightly better than the cartridge; however, the permeate rate in the cartridge reduced rapidly at higher feed water turbidity levels indicating that a tighter membrane should only be used with adequate pretreatment or at a low feed water turbidity to prolong membrane life. Microbiological monitoring was identified as a more sensitive indirect integrity monitoring method than turbidity and particle count monitoring to ensure effective treatment of water by ceramic filtration. Both PSL beads and B. subtilis showed potential as effective surrogates for Cryptosporidium, with B. subtilis showing higher degree of conservatism. Any opinions expressed in this article are those of the writer(s) and do not necessarily reflect the official positions and policies of the EPA. Any mention of products or trade names does not constitute recommendation for use by EPA. This document has been reviewed in accordance with EPA’s peer and administrative review policies and approved for publication.
Get full access to this article
View all available purchase options and get full access to this article.
References
Adham, S. S., Jacangelo, J. G., and Laine, J. M. (1995). “Low-pressure membranes; assessing integrity.” J. AWWA, 99(3), 62–75.
Aiden, A., Mehrvar, M., Ibrahim, T. H., and Nanov, V. (2007). “Particulates and bacteria removal by ceramic microfiltration, UV photolysis, and their combination.” J. Environ. Sci. Health, Part A: Toxic/Hazard. Subst. Environ. Eng., 42(7), 895–901.
Amburgey, J. E., Amirtharajah, A., Arrowood, J., and Spivey, N. C. (2001). “Cryptosporidium and fluorescent microspheres surrogate removals by conventional and biological filters.” Proc., of AWWA Water Quality Technology Conf. (WQTC), American Water Works Association, Denver.
Brown, A. R., and Cornwell, D. A. (2007). “Using spore removal to monitor plant performance for Cryptosporidium removal.” J. AWWA, 99(3), 95–109.
Cabassud, C., Anselme, C., Bersillon, J. L., and Aptel, P. (1991). “Ultrafiltration as a nonpolluting alternative to traditional clarification in water treatment.” Filtr. Sep., 28(3), 194–198.
Ciora, R. J. and Liu, P. K. T. (2003). “Ceramic membrane for environmental related applications.” Fluid/Part Sep. J., 15(1), 51–60.
Clasen, T., Brown, J., Suntura, O., and Collin, S. (2004). “Safe household water treatment and storage using drip filters: A randomized controlled trial in Bolivia.” Water Sci. Technol., 50(1), 111–115.
Clasen, T., and Menon, S. (2007). “Microbiological performance of common water treatment devices for household use in India.” Int. J. Environ. Health Resour., 17(2), 83–93.
Clement, J., Milton, G., Abrahamsson, J., and Erisson, U. (2006). “Ceramic membranes and coagulation for TOC removal from surface waters.” Proc., AWWA 2006 Water Quality Technology Conf. (WQTC), American Water Works Association, Denver.
Cornwell, D. A., Macphee, M. J., Brown, R. A., and Via, S. H. (2003). “Demonstrating Cryptosporidium removal using spore monitoring at lime-softening plants.” J. AWWA, 95(5), 124–133.
Drozd, C., and Schwartzbrod, J. (1997). “Removal of Cryptosporidium from river water by crossflow microfiltration: A pilot scale study.” Water Sci. Technol., 35(11-12), 391–395.
Dugan, N. R., Fox, K. R., Owens, J. H., and Milter, R. J. (2001). “Cryptosporidium control through conventional treatment.” J. AWWA, 93(12), 64–76.
Emelko, M. B., and Huck, P. M. (2004). “Microspheres as surrogates for Cryptosporidium filtration.” J. AWWA, 96(3), 94–105.
Emelko, M. B., Huck, P. M., and Coffey, B. M. (2005). “A review of Cryptosporidium removal by granular media filtration.” J. AWWA, 97(12), 101–115.
Emelko, M. B., Huck, P. M., and Douglas, I. P. (2003). “Cryptosporidium and microspheres removal during late in-cycle filtration.” J. AWWA, 95(5), 173–182.
Fallon, K. S., Hargy, T. M., Mackey, E. D., Wright, H. B., and Clancy, J. L. (2007). “Development and characterization of nonpathogenic surrogates for UV reactor validation.” J. AWWA, 99(3), 73–82.
Fifield, C. W. and Leahy, T. J., and (1983). “Sterilization in filtration.” Disinfection, sterilization and preservation, S. S. Block, ed., Lea and Febiger, Philadelphia, 125–153.
Finley, J. (2005). “Ceramic membranes: A robust filtration alternative.” Filtr. Sep., 42(9), 34–37.
HACH. (1999). Instruction manual for coliforms using membrane filtration, HACH, Denver.
Harrington, W. G., Xagoraraki, I., Assavasilavasukul, P., and Standridge, J. H. (2003). “Effect of filtration conditions on removal of waterborne pathogens.” J. AWWA, 95(12), 95–104.
Huck, P. M., et al. (2002). “Filter Operations Effects on Cryptosporidium Removal.” J. AWWA, 94(6), 97–111.
Huck, P. M., Coffey, B. M., O’Melia, C. R., Emelko, M. B., and Maurizio, D. D. (2001). Filter operations effects on pathogen passage, AWWARF and AWWA, Denver.
IDEXX. (2002). Instruction manual for SimPlate for HPC multi dose, IDEXX, Westbrook, Me.
Jacangelo, J. G. (2002). “Control of microorganisms in drinking water by pressure-driven membrane process.” Control of microorganisms in drinking water, S. Lingireddy, ed., ASCE, Reston, Va.
Jacangelo, J. G., Adham, S., and Laine, J. M. (1997). “Membrane filtration for microbial removal.” Rep. No. 90715, AWWARF, Denver.
Jacangelo, J. G., Aleta, E. M., Carns, K. E., Cumming, E. W., and Mallevialle, J. (1989). “Assessing hollow-fiber ultrafiltration for particulate removal.” J. AWWA, 81(11), 68–75.
Leahy, T. J., and Sullivan, M. J. (1978). “Validation of Bacterial Retention Capabilities of Membrane Filters.” Pharm. Technol, 2, 65–75.
Lerch, A., et al. (2004). “Direct river water treatment using coagulation/ceramic membrane MF.” Proc., European Desalination Society (EDS) Conf. on Membranes, European Desalination Society, L’Aquila, Italy.
Li, S. Y., Goodrich, J. A., Owens, J. H., Willeke, G. E., Schaefer, F. W., III, and Clark, R. M. (1997). “Reliability of surrogates for determining Cryptosporidium removal.” J. AWWA, 89(5), 90–99.
Madaeni, S. S. (1999). “The application of membrane technology for water disinfection.” Water Res., 33(2), 301–308.
Matsushita, T., Matsui, Y., Shirasaki, N., and Kato, Y. (2005). “Effect of membrane pore size, coagulation time and dose on virus removal by coagulation-ceramic microfiltration hybrid system.” Desalination, 178(1-3), 21–26.
Muhammad, N., et al. (2008). “Evaluating surrogates for Cryptosporidium removal in point of use system.” J. AWWA, 100(12), 98–107.
Nieminski, E. C., and Ongerth, J. E. (1995). “Removing Giardia and Cryptosporidium by conventional treatment and direct filtration.” J. AWWA, 87(9), 96–106.
Parker, D. Y., Lepnard, M. J., Barbar, P., Bonic, G., Jones, W., and Leavell, K. L. (1999). “Microfiltration treatment of filter backwash recycle water from drinking water treatment facility.” Proc., AWWA Water Quality Conf., American Water Works Association, Denver.
Patterson, C. L., Aisha, T., Muhammad, N., and Duffie, J. (2008). “Assessment of a point of use ultrafiltration system for turbidity and microbial pathogen removal.” Proc., 2008 Environmental and Water Resources Institute (EWRI) Congress, ASCE, Reston, Va.
Rice, E. W., Fox, K. R., Miltner, R. J., Lytle, D. A., and Johnson, J. H. (1994). “A microbiological surrogate for evaluating treatment efficiency.” Proc., AWWA Water Quality Technology Conf. (WQTC), American Water Works Association, Denver.
Sinha, R., Krishnan, R., Muhammad, N., Patterson, C. L., and Haught, R. C. (2006). “Evaluation of ceramic filtration for drinking water treatment in small systems.” Proc., 2006 Environmental and Water Resources Institute (EWRI) Congress, ASCE, Reston, Va.
Sinha, R., Muhammad, N., Krishnan, R., Piao, H., Patterson, C. L., and Cotruvo, J. (2008). “Evaluation of point of use (POU) systems for microbiological removal in drinking water.” Proc., 2008 Environmental and Water Resources Institute (EWRI) Congress, ASCE, Reston, Va.
Swertfeger, J., Metz, D. H., DeMarco, J., Bragheeta, A., and Jacangelo, J. G. (1998). “Effect of filter media on cyst and oocyst removal.” J. AWWA, 91(9), 90–100.
U.S. Environmental Protection Agency (U.S. EPA). (2001a). “Method 1602 for detection and enumeration of MS2 bacteriophage in drinking water.” Rep. No. EPA 821-R-01-029, Washington, D.C.
U.S. Environmental Protection Agency (U.S. EPA). (2001b). “Method 1622: Cryptosporidium in water by filtration/IMS/FA.” Rep. No. EPA 821-R-01-026, Washington, D.C.
U.S. Environmental Protection Agency (U.S. EPA). (2003a). “Small drinking water systems handbook: A guide to “packaged” filtration and disinfection technologies with remote monitoring and control tools.” Rep. No. EPA/600/R-03/41, Washington, D.C.
U.S. Environmental Protection Agency (U.S. EPA). (2003b). “Small systems guide to safe drinking water act regulations.” Rep. No. EPA 816-R-03-017, Washington, D.C.
U.S. Environmental Protection Agency (U.S. EPA). (2004). “The long-term 1 enhanced surface water treatment rule (LT1ESWTR) implementation guidance.” Rep. No. EPA 816-R-04-008, Washington, D.C.
U.S. Environmental Protection Agency (U.S. EPA). (2005). “Membrane filtration guidance manual.” Rep. No. EPA 815-R-06-009, Washington, D.C.
U.S. Environmental Protection Agency (USEPA). (2006). “The long-term 2 enhanced surface water treatment rule (LT2ESWTR) implementation guidance.” Rep. No. EPA 816-F-06-005, Washington, D.C.
Yates, R., Scott, K., Green, J., Bruno, J., and De Leon, R. (1998). “Using aerobic spores to evaluate treatment plant performance.” Proc., AWWA Ann. Conf., American Water Works Association, Denver.
Information & Authors
Information
Published In
Copyright
© 2009 ASCE.
History
Received: Sep 24, 2008
Accepted: Mar 20, 2009
Published online: Jun 4, 2009
Published in print: Nov 2009
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.