Fault-Tolerant Attitude Determination and Control System Design of Nanosatellite 2
Publication: Journal of Aerospace Engineering
Volume 31, Issue 6
Abstract
Nanosatellite 2 (NS-2) is a science and technology experimental nanosatellite developed by Tsinghua University. Since it was launched, NS-2 has operated properly and has been used as a low-cost, rapid-response satellite platform for on-orbit experiments with microelectromechanical system devices. The design, mathematical model, numerical simulation, and on-orbit telemetry data analysis of the NS-2 attitude determination and control system (ADCS) are presented in this paper. A bias momentum wheel and three-axis magnetic torquers were used and an actuator fault-tolerance control algorithm was proposed. Flight data confirmed that NS-2 ADCS achieved a three-axis stabilized control with an accuracy of 2.5° and an angular rate within in each axis, which met the mission requirements. In addition, single event effects were detected during the NS-2 flight, which led to attitude control failures. A simple and practical fault processing method was uploaded to NS-2 ADCS by the ground station to solve this problem. On-orbit operation validated the efficacy of this method. This paper provided reference for the study and design of nanosatellites.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This work is financially supported by a grant from the National High Technology Research and Development Program of China (863 Program) (No. 2013AA122601). The laboratory experiments were performed at the State Key Laboratory of Precision Measurement Technology and Instruments in Tsinghua University. We gratefully acknowledge the support of both institutions.
References
Battagliere, M. L., F. Santoni, F. Piergentili, M. Ovehinnikov, and F. Graziani. 2010. “Passive magnetic attitude stabilization system of the EduSAT microsatellite.” Proc. Inst. Mech. Eng. G 224 (10): 1097–1106. https://doi.org/10.1243/09544100JAERO732.
Berkovitz, D., E. Kong, D. Miller 2003. “System identification of the SPHERES autonomous rendezvous and docking testbed.” In Vol. 49 of Proc., AIAA Space 2003 Conf. and Exposition, 135–139. Reston, VA: ASCE.
Bouwmeester, J., and J. Guo. 2010. “Survey of worldwide pico- and nanosatellite missions, distributions and subsystem technology.” Acta Astronaut. 67 (7–8): 854–862. https://doi.org/10.1016/j.actaastro.2010.06.004.
Caliskan, F., and C. Hajiyev. 2016. “Active fault-tolerant control of UAV dynamics against sensor-actuator failures.” J. Aerosp. Eng. 29 (4): 04016012. https://doi.org/10.1061/(ASCE)AS.1943-5525.0000579.
Finlay, C. C., et al. 2010. “International geomagnetic reference field: The eleventh generation.” Geophys. J. Int. 183 (3): 1216–1230. https://doi.org/10.1111/j.1365-246X.2010.04804.
Ghosh, A., and V. Coverstone. 2015. “Optimal cooperative CubeSat maneuvers obtained through parallel computing.” Acta Astronaut. 107 (Feb–Mar): 130–149. https://doi.org/10.1016/j.actaastro.2014.10.042.
Heidt, H., J. Puig-Suari, A. S. Moore, S. Nakasuka, and R. J. Twiggs. 2000. “CubeSat: A new generation of picosatellite for education and industry low-cost space experimentation.” In Proc., 13th Annual AIAA/USU Small Satellite Conf., 1–19. Logan, UT: DigitalCommons@USU.
Inamori, T., N. Sako, and S. Nakasuka. 2011. “Attitude control system for the nano-astrometry satellite ‘Nano-JASMINE’.” Aircr. Eng. Aerosp. Technol. 83 (4): 221–228. https://doi.org/10.1108/00022661111138639.
Jin, J., S. Ko, and C. K. Ryoo. 2008. “Fault tolerant control for satellites with four reaction wheels.” Control Eng. Pract. 16 (10): 1250–1258. https://doi.org/10.1016/j.conengprac.2008.02.001.
Kulu, E. 2017. “World’s largest database of nanosatellites, more than 1700 nanosats and CubeSats.” Accessed July 30, 2017. http://www.nanosats.eu.
Li, Z., X. B. Yang, and H. J. Gao. 2013. “Autonomous impulsive rendezvous for spacecraft under orbital uncertainty and thruster faults.” J. Franklin Inst. 350 (9): 2455–2473. https://doi.org/10.1016/j.jfranklin.2012.07.002.
Nakasuka, S., N. Sako, H. Sahara, Y. Nakamura, T. Eishima, and M. Komatsu. 2010. “Evolution from education to practical use in University of Tokyo’s nano-satellite activities.” Acta Astronaut. 66 (7–8): 1099–1105. https://doi.org/10.1016/j.actaastro.2009.09.029.
Rievers, B., A. Milke, and D. Salden. 2015. “Cubesat in-situ degradation detector (CIDD).” Acta Astronaut. 112 (Jul–Aug): 69–76. https://doi.org/10.1016/j.actaastro.2015.03.015.
Roubache, R., M. Benyettou, A. M. S. Mohammed, A. Boudjemai, and A. Bellar. 2014. “Impact of the orbital eccentricity on the attitude performance before and after the deorbiting phase for Alsat-1.” Adv. Space Res. 53 (3): 474–489. https://doi.org/10.1016/j.asr.2013.11.030.
Ruiter, A. D. 2011. “A fault-tolerant magnetic spin stabilizing controller for the JC2Sat-FF mission.” Acta Astronaut. 68 (1–2): 160–171. https://doi.org/10.1016/j.actaastro.2010.07.012.
Selva, D., and D. Krejci. 2012. “A survey and assessment of the capabilities of CubeSats for Earth observation.” Acta Astronaut. 74 (May–Jun): 50–68. https://doi.org/10.1016/j.actaastro.2011.12.014.
Steyn, W. H. 1995. “A multi-mode attitude determination and control system for small satellites.” Ph.D. dissertation, Faculty of Engineering, Dept. of Electrical and Electronic Engineering, Stellenbosch Univ.
Thompson, R. H., G. F. Neal, and M. D. Shuster. 1984. “Magnetometer bias determination and spin-axis attitude estimation for the AMPTE mission.” J. Guid. Control Dyn. 7 (4): 505–507. https://doi.org/10.2514/3.19887.
Tseng, T. P., C. Hwang, and S. K. Yang. 2012. “Assessing attitude error of FORMOSAT-3/COSMIC satellites and its impact on orbit determination.” Adv. Space Res. 49 (9): 1301–1312. https://doi.org/10.1016/j.asr.2012.02.007.
Underwood, C., S. Pellegrino, V. J. Lappas, C. P. Bridges, and J. Baker. 2015. “Using CubeSat/micro-satellite technology to demonstrate the autonomous assembly of a reconfigurable space telescope (AAReST).” Acta Astronaut. 114 (Sep–Oct): 112–122. https://doi.org/10.1016/j.actaastro.2015.04.008.
Wertz, J. R. 1978. Spacecraft attitude determination and control. Dordrecht, Netherlands: Springer.
Woellert, K., P. Ehrenfreund, A. J. Ricco, and H. Hertzfeld. 2011. “CubeSats: Cost-effective science and technology platforms for emerging and developing nations.” Adv. Space Res. 47 (4): 663–684. https://doi.org/10.1016/j.asr.2010.10.009.
Xiao, B., Q. L. Hu, and D. W. Wang. 2015. “Spacecraft attitude fault tolerant control with a terminal sliding-mode observer.” J. Aerospace Eng. 28 (1): 04014055. https://doi.org/10.1061/(ASCE)AS.1943-5525.0000331.
Yamada, K., and H. Nagano. 2015. “Development of a heat storage panel for micro/nano-satellites and demonstration in orbit.” Appl. Therm. Eng. 91 (Dec): 894–900. https://doi.org/10.1016/j.applthermaleng.2015.08.073.
You, Z., S. Shi, K. C. Zhao, G. F. Zhang, F. Xing, and B. Zhou. 2017. “Nanosatellite-2 (NS-2): Demonstrating a flexible nano-spacecraft platform with self-developed MEMS devices.” Adv. Aerosp. Sci. Technol. 1 (1): 47–59.
Information & Authors
Information
Published In
Copyright
©2018 American Society of Civil Engineers.
History
Received: Nov 29, 2017
Accepted: Apr 10, 2018
Published online: Jul 17, 2018
Published in print: Nov 1, 2018
Discussion open until: Dec 17, 2018
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.