Fatigue Behavior of RC Beams Strengthened with NSM CFRP Rods
Publication: Journal of Composites for Construction
Volume 13, Issue 5
Abstract
This paper presents experimental results of reinforced concrete beams strengthened using near-surface mounted (NSM) carbon fiber-reinforced polymer (CFRP) reinforcement. A total of nine beam specimens were tested under fatigue loads. In addition, two specimens were tested for monotonic capacity. The beams were 3,500 mm long with a cross section of 254 mm deep by 152 mm wide. Different load ranges were considered in the fatigue tests to construct the fatigue life curves. The test results showed that under monotonic loading, the beam strengthened with NSM CFRP rod exhibited increases of 26 and 50% in the yield and ultimate load over the control beam, respectively. Under cyclic loading, the fatigue life for the strengthened beams was 24% higher than that of the control unstrengthened beams. An analytical model using sectional analysis and strain-life approach was developed to estimate the fatigue life of the specimens at various cyclic load ranges. A good agreement between the experimental results and analytical prediction of the fatigue life was obtained.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The research was conducted with the support by UNSPECIFIEDSaudi Cultural Bureau and NSERC. Special thanks are extended to Professor T. Topper for his help with the fatigue analysis.
References
Aidoo, J., Harries, K. A., and Petrou, M. F. (2004). “Behavior of reinforced concrete bridge retrofit with CFRP and subjected to monotonic and fatigue loading.” Proc., 4th Int. Conf. on Advanced Composite Materials in Bridges and Structures, Calgary, Canada.
Al-Hammoud, R. (2006). “Fatigue flexural behavior of corroded reinforced concrete beams repaired with CFRP sheets.” MS thesis, Univ. of Waterloo, Ont., Canada, 123.
American Concrete Institute. (2001). “Considerations for design of concrete structures subjected to fatigue loading.” ACI Committee 215, Farmington Hills, Mich.
American Concrete Institute. (2007). “Report on fiber reinforced polymer (FRP) reinforcement for concrete structure.” ACI 440R, Farmington Hills, Mich.
American Concrete Institute. (2008). “Guide for the design and construction of externally bonded FRP systems for strengthening concrete structures.” ACI 440.2R, Farmington Hills, Mich.
Asplund, S. O. (1949). “Strengthening bridge slabs with grouted reinforcement.” ACI Struct. J., 20(4), 397–406.
Badawi, M. (2007). “Monotonic and fatigue flexural behavior of RC beams strengthened with prestressed NSM CFRP rods.” Ph.D. thesis, Univ. of Waterloo, Ont., Canada, 256.
Bannantine, J. A., Comer, J. J., and Handrock, J. L. (1990). Fundamentals of metal fatigue analysis, 1st Ed., Prentice-Hall, N.J.
Barnes, R. A., and Mays, G. C. (1999). “Fatigue performance of concrete beams strengthened with CFRP plates.” J. Compos. Constr., 3(2), 63–72.
Blaschko, M., and Zilch, K. (1999). “Rehabilitation of concrete structures with strips glued into slits.” Proc., 12th Int. Conf. on Composite Materials, Paris, France.
Brena, S., Benouaich, M., Kreger, M., and Wood, S. (2005). “Fatigue tests of reinforced concrete beams strengthened using carbon fiber-reinforced polymer composites.” Struct. Eng., 102(2), 305–313.
De Lorenzis, L., and Nanni, A. (2002). “Bond between near-surface mounted FRP rods and concrete in structural strengthening.” ACI Struct. J., 99(2), 123–132.
De Lorenzis, L., Nanni, A., and La Tegola (2000). “Flexural and shear strengthening of reinforced concrete structures with near surface mounted FRP rods.” Proc., 3rd Int. Conf. on Advanced Composite Materials in Bridges and Structures (ACMBS III), Ottawa, 521–528.
Dowling, N. (2007). Mechanical behavior of materials: Engineering methods for deformation, fracture, and fatigue, 2nd Ed., Prentice-Hall, Upper Saddle River, N.J.
El Hacha, R., da Silva Filho, J. N., Melo, G. S., and Rizkalla, S. H. (2004). “Effectiveness of near surface mounted FRP reinforcement for flexural strengthening of reinforced concrete beams.” Proc., 4th Int. Conf. on Advanced Composite Materials in Bridges and Structures (ACMBS IV), Calgary, Canada.
Gheorghiu, C., Labossière, P., and Proulx, J. (2006). “Fatigue and monotonic strength of RC beams strengthened with CFRPs.” Composites, Part A, 37(8), 1111–1118.
Harries, K., and Aidoo, J. (2006). “Debonding and fatigue-related strain limits for externally bonded FRP.” J. Compos. Constr., 10(1), 87–90.
Harries, K. A., Reeve, B., and Zorn, A. (2007). “Experimental evaluation of factors affecting monotonic and fatigue behavior of fiber-reinforced polymer-to-concrete bond in reinforced concrete beams.” ACI Struct. J., 104(6), 667–674.
Harries, K. A., Zorn, A., Aidoo, J., and Quattlebaum, J. (2006). “Deterioration of FRP-to-concrete bond under fatigue loading.” Adv. Struct. Eng., 9(6), 779–789.
Hassan, T., and Rizkalla, S. (2002). “Flexural strengthening of prestressed bridges slabs with FRP systems.” PCI J., 47(1), 76–93.
Heffernan, P. J., and Erki, M. A. (2004). “Fatigue behavior of reinforced concrete beams strengthened with carbon fiber reinforced plastic laminates.” J. Compos. Constr., 8(2), 132–140.
ISIS Canada. (2008). “Reinforcing concrete structures with fiber reinforced polymers.” Design manual No. 4, ISIS Canada Corp., Manitoba, Canada.
Kim, Y., and Heffernan, P. (2008). “Fatigue behavior of externally strengthened concrete beams with fiber-reinforced polymers: State of the art.” J. Compos. Constr., 12(3), 246–256.
Rosenboom, O., and Rizkalla, S. (2006). “Behavior of prestressed concrete strengthened with various CFRP systems subjected to fatigue loading.” J. Compos. Constr., 10(6), 492–502.
Shahawy, M., and Beitelman, T. E. (1999). “Static and fatigue performance of RC beams strengthened with CFRP laminates.” J. Compos. Constr., 8(2), 613–621.
Yost, J. R., Gross, S. P., and Dinehart, D. W. (2004). “Near surface mounted CFRP reinforcement for structural retrofit of concrete flexural members.” Proc., 4th Int. Conf. on Advanced Composite Materials in Bridges and Structures, Calgary, Canada.
Information & Authors
Information
Published In
Copyright
© 2009 ASCE.
History
Received: Apr 2, 2007
Accepted: May 7, 2009
Published online: Sep 15, 2009
Published in print: Oct 2009
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.