Effect of Sulphur Concentration on Bioleaching of Cr(III) and Other Metals from Tannery Sludge by Indigenous Sulphur-Oxidizing Bacteria
Publication: Practice Periodical of Hazardous, Toxic, and Radioactive Waste Management
Volume 6, Issue 4
Abstract
An investigation on the effect of elemental sulphur concentration on bioleaching of Cr(III) and other metals from tannery sludge by sludge indigenous sulphur-oxidizing bacteria was performed. Elemental sulphur concentrations ranging from 5 to 40 g/L were tested during this study. The sludge solids concentration was fixed at 40 g/L. The results showed that the sludge pH decrease was faster and sharper with increased sulphur concentration. The time required to achieve the final pH (the lowest pH) was about 15 days irrespective of sulphur concentration. The leaching efficiencies of Cr(III), Al, and Fe, and production increased with increasing initial sulphur concentration. However, the leaching efficiencies of Zn, Ca, and Mg were less affected by the initial sulphur concentration. The preferred sulphur concentration for Cr leaching was 20 g/L, from an economic viewpoint. The total and volatile suspended solids decreased during the process. The measurements of sulphur-oxidizing bacteria showed that less-acidophilic thiobacilli as well as acidophilic thiobacilli contributed to the pH reduction in tannery sludge. The sulphur-oxidizing bacteria could survive in tannery sludge at a pH as low as 0.5 at 21°C
Get full access to this article
View all available purchase options and get full access to this article.
References
American Public Health Association (APHA). (1989). Standard Methods for the Examination of Water and Wastewater, 17th Ed., Washington, D.C.
Blais, J. F., Auclair, J. C., and Tyagi, R. D.(1992a). “Cooperation between two Thiobacillus strains for heavy-metal removal from municipal sludge.” Can. J. Microbiol., 38, 181–187.
Blais, J. F., Tyagi, R. D., and Auclair, J. C.(1993). “Bioleaching of metals from sewage sludge: Microorganisms and growth kinetics.” Water Res., 27(1), 101–110.
Blais, J. F., Tyagi, R. D., Auclair, J. C., and Lavoie, M. C.(1992b). “Indicator bacteria reduction in sewage sludge by a metal bioleaching process.” Water Res., 26(4), 487–495.
Chuan, M. C., and Liu, J. C.(1996). “Release behaviour of chromium from tannery sludge.” Water Res., 30(4), 932–938.
Jain, D. K., and Tyagi, R. D.(1992). “Leaching of heavy metals from anaerobic sewage sludge by sulphur-oxidizing bacteria.” Enzyme Microb. Technol., 14, 376–383.
Laishley, E. J., Rae, K., Dillman, A. M., and Bryant, R. D.(1988). “Characterization of a new less-acidophilic Thiobacillus isolate (Thiobacillus capsulatus).” Can. J. Microbiol., 34, 960–966.
Macchi, G., Pagano, M., Pettine, M., Santori, M., and Tiravanti, G.(1991). “A bench study on chromium recovery from tannery sludge.” Water Res., 25(8), 1019–1026.
Panswad, T., Chavalprit, O., Sucharrittham, Y., and Charoenwisedsin, S.(1995). “A bench-scale study on chromium recovery from tanning wastewater.” Water Res., 31(9), 73–81.
Reynolds, D. M., Laishley, E. J., and Costerton, J. W.(1981). “Physiological and ultrastructural characterization of a new acidophlilic Thiobacillus species (T. kabobis).” Can. J. Microbiol., 59, 151–161.
Shen, S. B., Tyagi, R. D., and Blais, J. F.(2001b). “Extraction of Cr(III) and other metals from tannery sludge by mineral acid.” Environ. Technol., 22, 1007–1014.
Shen, S. B., Tyagi, R. D., and Blais, J. F.(2001c). “Prediction of metal precipitates in tannery sludge leachate based on thermodynamic calculations.” Environ. Technol., 22, 961–970.
Shen, S. B., Tyagi, R. D., Surampalli, R. Y., and Blais, J. F.(2001a). “Chromium(III) isolation from acid extract of tannery sludge.” Pract. Period. Hazard., Toxic, Radioact. Waste Manage., 5(4), 185–193.
Skrypski-Mantele, S.and Bridle, T. R.(1995). “Environmentally sound disposal of tannery sludge.” Water Res., 29(4), 1033–1039.
Sreekrishnan, T. R., Tyagi, R. D., Blais, J. F., Meunier, N., and Campbell, P. G. C.(1996). “Effect of sulphur concentration on sludge acidification during the SSDML process.” Water Res., 30(11), 2728–2738.
Tiravanti, G., Petruzzelli, and Passino, R.(1997). “Pretreatment of tannery wastewater by an ion exchange process for Cr(III) removal and recovery.” Water Sci. Technol., 36(2–3), 197–207.
Tyagi, R. D., Blais, J. F., Meunier, N., and Benmoussa, H.(1997). “Simultaneous sewage sludge digestion and metal leaching—Effect of sludge solids concentration.” Water Res., 31(1), 105–118.
Tyagi, R. D., Blais, J. F., Meunier, N., and Kluepfel, D.(1993). “Biolixiviation des métaux lourds et stabilisation des boues d’épuration: Essai en bioréacteur opéré en mode cuvée.” Can. J. Civ. Eng., 20, 57–64.
Tyagi, R. D., Couillard, D., and Tran, F. T.(1988). “Heavy metal removal from anaerobically digested sludge by a chemical and microbiological methods.” Environ. Pollut., 50, 295–316.
Tyagi, R. D., Meunier, N., and Blais, J. F.(1996). “Simultaneous sewage sludge digestion and metal leaching—Effect of temperature.” Appl. Microbiol. Biotechnol., 46, 422–431.
Information & Authors
Information
Published In
Copyright
Copyright © 2002 American Society of Civil Engineers.
History
Received: Jun 13, 2002
Accepted: Jun 17, 2002
Published online: Sep 13, 2002
Published in print: Oct 2002
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.