Influence of Superplasticizers on Workability of Concrete
Publication: Journal of Materials in Civil Engineering
Volume 11, Issue 2
Abstract
This paper outlines the theoretical foundations governing the rheological properties of concrete. The rheological equation for fresh concrete is given as a modification of Bingham's equation. The shear resistance of the concrete mix is explained in terms of two constants—yield value and plastic viscosity. The complex nature of the yield value is described. It is pointed out that there are three different zones of rheological behavior of fresh concrete, which arise as a result of the relation between shear stress and yield value of the mix. This paper also describes an experimental study that measures the effects of superplasticizer, water-to-cement (w/c) ratio, condensed silica fume (CSF) and elapsed time on the rheological parameters for fresh concrete. The rheological tests were carried out on a ROD1E rotational rheometer. In total, 102 flow curves were obtained from which the yield values g and the plastic viscosities h for a wide range of concrete mixes were determined. The results showed that superplasticizers became less effective with increase in w/c ratio and that different superplasticizers have widely different effects on changes in g and h. It was also established that CSF additions generally reduce workability, although above a certain CSF content a sharp reduction in plastic viscosity occurs. In addition it was observed that superplasticizers generally extend the period over which a mix remains workable. The results are discussed in terms of the theoretical foundations.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Banfill, P. F. ( 1980). “Workability of flowing concrete.” Mag. of Concrete Res., 32, 17–27
2.
Banfill, P. F. G., and Tattersall, G. H. ( 1983). The rheology of fresh concrete. Pitman Publishing, Ltd., London.
3.
Chioccio, G., and Paolini, A. E. ( 1985). “Optimum time for adding superplasticisers to portland cement pastes.” Cement and Concrete Res., 15, 901.
4.
Collepardi, M., Corradi, M., Baldini, G., and Pauri, M. ( 1980). “Influence of sulfonated naphthalene formaldehyde on the fluidity of cement paste.” Proc., 7th Congr. Chem. Cem., Vol. III, 20.
5.
Faroug, F. ( 1994). “Influence of superplasticisers on rheological properties of fresh concrete,” PhD thesis, Silesian Technical University, Gliwice, Poland (in Polish).
6.
Kikukawa, H. ( 1990). “Rheological studies on fresh concrete using admixtures.” Proc., RILEM Symp., Admixtures for Concrete Improvement of Properties.
7.
Malhotra, M. ( 1990). “Superplasticisers and other chemical admixtures in concrete.” Proc., 3rd Int. Conf. Constr. Mat. Energy Mines and Resour., American Concrete Institute, Detroit.
8.
Mierzwa, J. ( 1989). “Modification of rheological properties of cement pastes influenced by betoplast.” Proc., Sci. and Technol. Conf. (in Polish).
9.
Roy, D., and Asaga, K. ( 1980a). “Rheological properties of cement mixes.” Cement and Concrete Res., 10, 287.
10.
Roy, D., and Asaga, K. ( 1980b). “The effects of superplasticisers on viscosity and yield stress and the effects of time on viscometric properties of mixes containing superplasticisers.” Cement and Concrete Res., 10, 287.
11.
Szwabowski, J. ( 1987). “Workability of fresh concrete, a rheological approach,” DSc thesis, Pub. Civ. Engrg. No. 65, Silesian Tech. Univ., Gliwice, Poland (in Polish).
12.
Szwabowski, J. ( 1990). “Influence of three-phase structure on the yield stress of fresh concrete.” Proc. Int. Conf. on Rheology of Fresh Cement and Concrete, Chapman & Hall, London.
13.
Szwabowski, J., , S., and Golaszewski, J. ( 1995). “Problem of workability measurement in high strength concrete. Concrete and Prefabrication.” Proc., 15th Conf. on Res. and Tech. in the Concrete Industry. Jadwisin 95, CEBET, Warsaw, Poland (in Polish).
14.
Tattersall, G. H. ( 1973). “The rationale of a two-point workability test.” Mag. of Concrete Res., 25, 169–172.
15.
Wallevik, O. H., and Gjørv, O. E. ( 1990). “Development of coaxial cylinders viscometer for fresh concrete.” Proc., RILEM Colloqium on Properties of Fresh Concrete.
Information & Authors
Information
Published In
History
Published online: May 1, 1999
Published in print: May 1999
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.