Thermal Instability in Buried Cable Backfills
Publication: Journal of Geotechnical Engineering
Volume 115, Issue 1
Abstract
Buried high voltage power cables generate heat when a current is passed through the conductor, and failure of the cable may occur if the conductor or insulation temperature exceeds the design limit. Thermal instability, a moisture migration phenomenon causing a decrease in soil thermal conductivity, has caused thermally induced failure of cables and may be a problem in the case of other buried heat sources as well. Thus accurate methods for predicting thermal instability are needed. Until recently, such problems have been mainly in the domain of electrical and mechanical engineers; however, geotechnical engineers are now frequently involved in the study of this problem. The Hartley and Black method, based on the assumption that the ratio of the time to instability to the diameter squared of the heat source is a constant for a given heat input rate, is investigated. Laboratory tests, scaled model tests, and field tests were used to provide a wide range in the diameter of the tubular heaters employed (1.6 to 406 mm). Based on data collected from scaled model tests, thermal instability was accurately predicted for a field test of three simulated cables. The influence of cyclic versus constant thermal loading on the thermal stability of sand was also investigated, and it was found that the time to instability was not a function of the method of loading for cycle times that are short relative to the time to instability.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Arman, A. N., et al. (1964). “Influence of soil moisture migration of power rating of cables in H. V. transmission systems.” IEEE Proceedings, 111(5), 1000–1016.
2.
Black, W. Z., Hartley, J. G., and Martin, M. A., Jr. (1980). “Thermal stability of soils adjacent to underground transmission power cable.” First and Second Quarterly Report, Project RP 7883, Georgia Institute of Technology, Atlanta, Ga.
3.
Black, W. Z., Hartley, J. G., and Martin, M. A., Jr. (1981). “Thermal stability of soils adjacent to underground transmission cables.” Project RP 7883, Georgia Institute of Technology, Atlanta, Ga.
4.
Boggs, S. A., Chu, S. Y., and Radhakrishna, H. S. (1980). “Measurement of soil thermal properties—Techniques and instrumentation.” IEEE Trans. on Power Apparatus and Systems, PAS‐99(2), 747–752.
5.
Boggs, S. A., Chu, S. Y., and Radhakrishna, H. S. (1981). “Measurement for underground thermal transmission design.” Proc. of the Symp. on Underground Cable Thermal Backfill, Toronto, Canada, 134–146.
6.
Brakelmann, H. (1984). “Physical principles and calculation methods of moisture and heat transfer in cable trenches,” Etz‐Report 19, VDE‐VERLAG, Berlin.
7.
Bush, R. A., Black, W. Z., and Martin, M. A., Jr. (1979). “Soil thermal properties and their effect on thermal instability and the rating of underground power cables.” Proc. 7th IEEE/PES Transmission and Distribution Conference and Exposition, 275–280.
8.
Church, E. A. (1931). “Temperatures in electric power cables under variable loading.” Trans., American Institution of Electrical Engineers, 50, 982.
9.
Dahl, O. D. C. (1924). “Temperature and stress distributions in hollow cylinders.” Trans., American Society of Mechanical Engineers, 161.
10.
Farouki, O. T. (1981). “Measurement of thermal properties of soils.” U.S. Army Corps of Engineers, CRREL Monograph 81‐1.
11.
Goldenburg, H. (1967). “Transient heating of buried power cables.” IEEE Proc., 114(6), 809–815.
12.
Goldenburg, H. (1967). “Thermal transients in linear systems with heat generation linearly time dependent.” IEEE Proc., 114(3), 375–377.
13.
Hartley, J. G. (1977). “An analysis of the thermal stability of the soil environment of underground electrical cables.” Dissertation presented to the Georgia Institute of Technology, at Atlanta, Ga., in partial fulfillment of the requirements for the degree of Doctor of Philosophy.
14.
Hartley, J. G., et al. (1981). “Measurements, correlations, and limitations of soil thermal stability.” Proc. of the Symp. on Underground Cable Thermal Backfills, Toronto, Canada, 121–133.
15.
Hartley, J. G., and Black, W. Z. (1979). “Predicting thermal stability and transient response of soils adjacent to underground power cables.” Proc., 7th IEEE/PES Transmission and Distribution Conf., 1, Apr.
16.
Hartley, J. G., and Black, W. Z. (1983). “Thermal stability of soils adjacent to underground transmission power cables.” School of Mechanical Engineering, Project 7883, Georgia Institute of Technology, Atlanta, Ga.
17.
Highgate, D., and Parr, R. (1984). “A note on cable ratings and moisture recovery during cyclic loading conditions.” KEMA Discussion, Workshop on Buried Power Cables, The Netherlands.
18.
Keating, T. T. (1950). “The cyclic heating of H‐type and SL‐type buried power cables.” Institution of Engineers, Australia, Journal, 22, 149–157.
19.
Kellow, M., Stonge, H., and Mier‐Maza, R. (1981). “Thermal behavior of an underground duct bank cable system under normal and forced cooling conditions,” Proc. of the Symp. on Underground Cable Thermal Backfills, Toronto, Canada, 192–205.
20.
King, S. Y., and Halfter, N. A. (1977). Underground power cables, Hong Kong University Press, Hong Kong.
21.
Martin, M. A. (1981). “Electric utility practices, research, and history for soil thermal property measurements.” Proc. the Symp. on Underground Cable Thermal Backfills, Toronto, Canada, 10–18.
22.
Martin, M. A., et al. (1981). “Practical aspects of applying soil thermal stability measurements to the ratings of underground power cables.” IEEE Trans. on Power Apparatus and Systems, PAS‐100(9), 4236–4249.
23.
McMillan, J. C. (1985). “A study of heat and moisture flow around hot buried pipes,” Dissertation presented to the University of California, at Berkeley, Calif., in partial fulfillment of the requirements for the degree of Doctor of Philosophy.
24.
Mochlinski, K. (1976). “Assessment of the influence of soil thermal resistivity on the ratings of distribution cables.” IEEE Proc., 123(1), 60–72.
25.
Wollaston, F. O. (1949). “Transient temperature phenomena of three conductor cables.” Trans. American Institution of Electrical Engineers, 68(2), 1284–1295.
Information & Authors
Information
Published In
Journal of Geotechnical Engineering
Volume 115 • Issue 1 • January 1989
Pages: 38 - 55
Copyright
Copyright © 1989 ASCE.
History
Published online: Jan 1, 1989
Published in print: Jan 1989
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.