Novel Hybrid Filter for the Treatment of Septic Tank Effluent
Publication: Journal of Environmental Engineering
Volume 132, Issue 7
Abstract
Intermittent sand filtration is a common and effective method for treating septic tank effluent. However, if the loading rate is too high, clogging and ponding of the sand filter surface layer can occur due to the accumulation of excessive biomass and the deposition of suspended solids. This ponding limits the practicality of sand filtration as it makes it necessary to take the filter out of service for maintenance. The objective of this study was to develop and test, on-site, a new hybrid filter system that would reduce the risk of clogging at an organic loading rate substantially greater than the maximum recommended loading rate for intermittent sand filters. The system comprised a deep horizontal flow biofilm reactor (HFBR) over a deep stratified sand filter. The HFBR consisted of a stack of 20 horizontal corrugated polyvinyl chloride sheets, at vertical spacings. The sheets were arranged so that the wastewater flowed over and back along alternate sheets down through the stack. The main biofilm growth formed on these sheets. The hybrid filter was loaded with septic tank effluent from an office/garage complex at the rate of for a period of 400 days in two phases. During the first phase, the effluent volume of was applied in 24 doses/day for , and during the second phase in 6 doses/day for . Biofilms in the HFBR substantially reduced the organic and suspended solids loads that reached the sand filter surface and allowed an average total biochemical oxygen demand loading rate, based on HFBR plan area, of to be applied to the system without clogging. This rate was substantially greater than the maximum recommended loading rate of for intermittent sand filters. During both loading phases a removal of 94% was achieved and nitrification was nearly complete. The average effluent was during both phases. The hybrid filter system appeared to perform better in terms of suspended solids handling and nitrification during the more frequent dosing phase. The hybrid filtration system offers a more compact alternative to intermittent sand filtration on its own with little risk of clogging.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The writers are grateful to Coffey Construction Ltd., Athenry, Co. Galway for support for the work. They also acknowledge the technical help of M. Rathaille, M. O’Brien, and G. Hynes (NUI, Galway).
References
American Public Health Association/American Water Works Association/Water Environment Association (APHA-AWWA-WEF). (1995). Standard methods for the examination of water and wastewater, 19th Ed., Washington, D.C.
Anderson, D. L., Siegrist, R. L., and Otis, R. J. (1985). “Technology assessment of intermittent sand filter.” Rep. No. PB85-232585, Municipal Facilities Division, Office of Municipal Pollution Control, Washington, D.C.
Boller, M., Schwager, A., Eugster, J., and Mottier, V. (1993). “Dynamic behaviour of intermittent buried filters.” Water Sci. Technol., 28(10), 99–107.
Bouwer, E. J., Rijnaarts, H. H.M., Cunningham, A. B., and Gerlach, R. (2000). Biofilms II: Process analysis and application, Wiley, New York.
Daniel, T. C., and Bouma, J. (1974). “Column studies of soil clogging in a slowly permeable soil as a function of effluent quality.” J. Environ. Qual., 3(4), 321–326.
Darby, J., Tchobanoglous, G., and Nor, M. A. (1996). “Shallow intermittent sand filtration: Performance evaluation.” Small Flows J., 2(1), 3–14.
Effert, D., Morand, J., and Cashell, M. (1985). “Field performance of three onsite effluent polishing units.” Proc., 4th Nat. Symp. on Individual and Small Community Sewage Systems, ASAE, New Orleans, 1–11.
Furman, T. D., Calaway, W. T., and Grantham, G. R. (1955). “Intermittent sand filters-multiple loadings.” Sewage Works J., 27(3), 261–276.
Piluk, R. J., and Hao, O. J. (1989). “Evaluation of on-site waste disposal system for nitrogen reduction.” J. Environ. Eng., 115(4), 725–740.
Platzer, C., and Mauch, K. (1997). “Soil clogging in vertical flow reed beds-mechanisms, parameters, consequences and solutions?.” Water Sci. Technol., 35(5), 175–181.
Rodgers, M., Mulqueen, J., and Healy, M. G. (2004). “Surface clogging in an intermittent stratified sand filter.” Soil Sci. Soc. Am. J., 68(6), 1827–1832.
Sauer, D. K., Otis, R. J., and Boyle, W. C. (1976). “Intermittent sand filtration of household water.” J. Environ. Eng. Div. (Am. Soc. Civ. Eng.), 102(4), 789–803.
Schwager, A., and Boller, M. (1997). “Transport phenomena in intermittent filters.” Water Sci. Technol., 35(6), 13–20.
Siegrist, R. L., and Boyle, W. C. (1987). “Wastewater-induced soil clogging development.” J. Environ. Eng., 113(3), 550–566.
U.S. Environmental Protection Agency (USEPA. (1980). “Design manual: Onsite wastewater treatment and disposal systems.” EPA Rep. No. 625/1-80-012, Cincinnati.
Vandevivere, P., and Baveye, P. (1992). “Effect of bacterial extracellular polymers on the saturated hydraulic conductivity of sand columns.” Appl. Environ. Microbiol., 58(5), 1690–1698.
Information & Authors
Information
Published In
Copyright
© 2006 ASCE.
History
Received: Dec 22, 2004
Accepted: Nov 14, 2005
Published online: Jul 1, 2006
Published in print: Jul 2006
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.