Performance and Cost Evaluations of Synthetic Resin Technology for the Removal of Methyl Tert-Butyl Ether from Drinking Water
Publication: Journal of Environmental Engineering
Volume 131, Issue 3
Abstract
This study investigated the performance of synthetic carbonaceous resin technology for the treatment of methyl tert-butyl ether (MTBE) contaminated waters using rapid small-scale column tests (RSSCTs). The RSSCTs were conducted using Ambersorb 563 carbonaceous resin (Rohm and Haas Corp., Philadelphia, Pa.) under multisolute conditions of typical municipal water source, soluble fuel components or additive/by-product, and MTBE. Specifically, one RSSCT column run was conducted with groundwater from Arcadia Wellfield, Santa Monica, Calif., with tert-butyl alcohol (TBA) and MTBE, while the other RSSCT column run was performed with surface water from Lake Perris, Calif., with benzene, toluene, -xylene (BTX) and MTBE. The results obtained were compared to RSSCTs performed using PCB coconut shell granulated activated carbon (GAC) (Calgon Corp., Philadelphia, Pa.). The adsorbent comparisons indicate that the performance (as characterized by indicators such as carbon usage rates or integrated column capacity) of the Ambersorb 563 synthetic resin in multisolute conditions of TBA or BTEX with MTBE in typical municipal water source is significantly superior to that of the coconut shell PCB GAC. Cost comparison for the coconut shell GAC and synthetic resin system was also performed. Under multisolute conditions of typical municipal water source, flow rates, and influent MTBE concentrations, the cost of the resin system, for most of the scenarios evaluated, is demonstrated to be significantly lower than the complementary GAC system under the costing procedure used. Further, when soluble fuel components such as BTX or fuel additives/byproducts such as TBA were present along with MTBE, the predicted higher adsorbent usage rates for the coconut shell GAC were translated into significantly higher treatment costs relative to the synthetic carbonaceous resin system.
Get full access to this article
View all available purchase options and get full access to this article.
References
American Public Health Association, American Water Works Association, and Water Environment Federation (APHA/AWWA/WEF). (1995). Standard methods for the examination of water and wastewater, 18th Ed., Washington, D.C.
Baker, R. J., and Suffet, I. H. (1989). Aquatic humic substances: Influence on fate and treatment of pollutants, I. H. Suffet and P. MacCarthy, Advances in Chemistry Series, Vol. 219, American Chemical Society, Washington, D.C.
California MTBE Research Partnership. (2000). Treatment technologies for removal of methyl tertiary butyl ether (MTBE) from drinking water, 2nd Ed, National Water Research Institute, Fountain Valley, Calif.
Chemical industry statistical handbook. (1998). Chemical Manufacturers Association, Arlington, Va.
Chen, G., Dussert, B. W., and Suffet, I. H. (1997). “Evaluation of granular activated carbon for removal of methyl isoborneol to below odor threshold concentrations in drinking water.” Water Res., 31(5), 1155–1163.
Crittenden, J. C., Berrigan, J. K., and Hand, D. W. (1986). “Design of rapid small-scale adsorption tests for a constant surface diffusivity.” J. Water Pollut. Control Fed., 58(4), 312–319.
Crittenden, J. C., Hand, D. W., Arora, H., and Lykins, B. W. (1987). “Design consideration for GAC treatment of organic chemicals.” J. Am. Water Works Assoc., 79(1), 74–81.
Crittenden, J. C., Reddy, P. S., Arora, H., Trynoski, J., Hand, D. W., Perram, D. L., and Summers, R. S. (1991). “Predicting GAC performance with rapid small-scale column tests.” J. Am. Water Works Assoc., 83(1), 77–87.
Crittenden, J. C., Reddy, P. S., Hand, D. W., and Arora, H. (1989). Prediction of GAC performance using rapid small-scale column tests, American Water Works Association Research Foundation and American Water Works Association, Denver.
Davis, S. W., and Powers, S. E. (2000). “Alternative sorbents for removing MTBE from gasoline-contaminated groundwater.” J. Environ. Eng., 126(4), 354–360.
Franklin, P. M., Koshland, C. P., Lucas, D., and Sawyer, R. F. (2000). Clearing the air: Using scientific information to regulate reformulated fuels. Environ. Sci. Technol., 34(18), 3857–3863.
Gallup, D. L., Isacoff, E. G., and Smith, D. N., III (1996). “Use of Ambersorb carbonaceous adsorbent for removal of BTEX compounds from oil-field produced water.” Environ. Prog., 15(3), 197–203.
Hand, D. W. (1989). “Design of fixed bed adsorbers to remove multicomponent mixtures of volatile and synthetic organic chemicals.” J. Am. Water Works Assoc., 81(1), 67–77.
Hand, D. W., Herlevich, J. A., Jr., Perram, D. L., and Crittenden, J. C. (1994). “Synthetic adsorbent versus GAC for TCE removal.” J. Am. Water Works Assoc., 86(8), 64–72.
Hokanson, D. R., Hand, D. W., Crittenden, J. C., Rogers, T. N., and Oman, E. J. (1994). Adsorption design software for windows (AdDesignS), Michigan Technical Univ., Mich.
Johnson, R., Pankow, J., Bender, D., Price, C., and Zogorski, J. (2000). “MTBE: To what extent will past releases contaminate community water supply wells?” Environ. Sci. Technol., 34(9), 210A–217A.
Keller, A. A., Sandall, O. C., and Rinker, R. G. (1998). “Health and environmental assessment of MTBE.” Vol. 5, Risk assessment, exposure assessment, water treatment and cost benefit analysis, Rep. to the Governor and Legislature of the State of California as sponsored by SB521, Vol. 5, Calif., 1–35.
Malley, J. P., Locandro, R. R., and Wagler, J. L. (1993). “Innovative point-of-entry (POE) treatment for petroleum contaminated water supply wells.” Final Rep., U.S.G.S. New Hampshire Water Resources Research Center, Durham, N.H.
Neely, J. W., and Isacoff, E. G. (1982). Carbonaceous adsorbents for the treatment of ground and surface waters, Vol. 21, Dekker, New York.
Rohm and Haas, Inc. (1992–1999 ). Manufacturer Literature, 100 Independence Mall West, Philadelphia, 19106-2399.
Schnable, J. G., Capangpangan, M. B., and Suffet, I. H. (1991a). “Continuous automatic monitoring of small sample streams using a modified purge-and-trap system.” Liquid Chromatography-Gas Chromatography, 9(12), 849–855.
Schnable, J. G., Capangpangan, M. B., and Suffet, I. H. (1991a). “Continuous automatic monitoring of volatile organics in aqueous streams by a modified purge-and-trap system.” J. Chromatogr., 549, 335–335.
Schnable, J. G., Capangpangan, M. B., and Suffet, I. H. (1991c). “Dynamic headspace analysis to purge-and-trap analysis of volatile organic compounds in drinking water sources.” J. Opt. Commun., 513, 47–54.
Shih, T., Khan, E., Rong, W., Wangpaichitr, M., Kong, J., and Suffet, I. H. (1999). “Sorption for removing methyl tertiary butyl ether from drinking water.” American Water Works Association National Conf. Proc., Chicago.
Shih, T., Wangpaichitr, M., and Suffet, I. H. (2001). Evaluation of the adsorption process for the removal of methyl tertiary butyl ether (MTBE) from drinking water, A. Diaz and D. Drogos, eds., American Chemical Society Symposium Series No. 799, Vol. 799, 208–225.
Shih, T., Wangpaichitr, M., and Suffet, I. H. (2003). “Evaluation of granular activated carbon technology for the removal of methyl tertiary butyl ether (MTBE) from drinking water.” Water Res., 37(2), 375–385.
Snoeyink, V. L., and Summers, S. R. (1999). “Adsorption of organic compounds.” Water quality & treatment, A handbook of community water supplies, 5th Ed., McGraw-Hill, Washington, D.C., 13.1–13.83.
Squillace, P. J., Moran, M. J., Lapham, W. W., Price, C. V., Clawges, R. M., and Zogorski, J. S. (1999). “Volatile organic compounds in untreated ambient groundwater of the United States, 1985–1995.” Environ. Sci. Technol., 33(23), 4176–4187.
Squillace, P. J., Zogorski, J. S., Wilber, W. G., and Price, C. V. (1996). “Preliminary assessment of the occurrence and possible sources of MTBE in groundwater in the United States, 1993–1995.” Environ. Sci. Technol., 30, 1721–1730.
Stocking, A., Suffet, I. H., McGuire, M. J., and Kavanaugh, M. (2001). “Implications of an MTBE odor study for setting drinking water standards.” J. Am. Water Works Assoc., 93(3), 95–105.
Suffet, I. H. (1980). “An evaluation of activated carbon for drinking water treatment: National Academy of Science report.” J. Am. Water Works Assoc., 72, 41–41.
Suffet, I. H., and McGuire, J. (1980). Activated carbon adsorption of organics from the aqueous phase, Vol. 1, Ann Arbor Science, Ann Arbor, Mich.
Suffet, I. H., and Wable, O. (1995). “Removal of taste-and-odor compounds by activated carbon.” Advances in taste-and-odor treatment and control, I. H. Suffet, J. Mallevialle, and E. Kawczyski, eds., American Water Works Research Foundation, Denver, 151–200.
Summers, R. S., Cummings, L., DeMarco, J., Hartman, D. J., Metz, D. H., Howe, E. W., MacLeod, B., and Simpson, M. (1992). Standardized protocol for the evaluation of GAC, American Water Works Association Research Foundation and American Water Works Association, Denver.
Summers, R. S., Haist, B., Koehler, J., Ritz, J., Zimmer, G., and Sontheimer, H. (1989). “The influence of background organic matter on GAC adsorption.” J. Am. Water Works Assoc., 81(5), 66–74.
Yohe, T., Suffet, I. H., and Cairo, P. R. (1981). “Specific organic removal by granular activated carbon pilot contactors.” J. Am. Water Works Assoc., 73, 402–410.
Zimmer, G., Brauch, H. J., and Sontheimer, H. (1989). Aquatic humic substances: Influence on fate and treatment of pollutants, I. H. Suffet and P. McCarthy, eds., Vol 219, Advances in Chemistry Series, American Chemical Society, Washington, D.C.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 131 • Issue 3 • March 2005
Pages: 450 - 460
Copyright
© 2005 ASCE.
History
Received: Sep 3, 2003
Accepted: May 25, 2004
Published online: Mar 1, 2005
Published in print: Mar 2005
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.