Load Dampening System for Vapor Phase Bioreactors
Publication: Journal of Environmental Engineering
Volume 127, Issue 3
Abstract
Vapor phase bioreactors are receiving increasing attention as a cost-effective treatment method for air contaminated with volatile organic compounds (VOCs). In this study, a novel absorption and humidification system was evaluated for its ability to dampen transient VOC loads, and to reduce their detrimental effects on a downstream bioreactor. A model based on the mass transfer characteristics of two target compounds (acetone and toluene) was developed and takes into account a closed water recirculation loop that minimizes fugitive emissions and simultaneously humidifies the inlet gas stream. When water is used as the scrubbing liquid, model and experimental results indicate that the system effectively dampens hydrophilic compounds and segregates them from the hydrophobic compounds in the waste gas stream. The response of a vapor phase bioreactor to the pretreated stream has also been assessed, and results indicate that the load dampening system works effectively for hydrophilic, but not hydrophobic, VOCs. However, when an organic cosolvent is used in conjunction with water, hydrophobic VOCs can also be dampened efficiently.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Barshter, D. W., Paff, S. W., and King, A. B. ( 1993). “Biofiltration—Room temperature incineration.” Proc., Air & Waste Mgmt. Assn. 86th Annu. Meeting & Exhibition, Paper #93-WP94.07, Pittsburgh.
2.
Buchanan, J. ( 1967). Industrial & Engineering Chemistry Fundamentals, 6, 400.
3.
Choi, D. S., Devinny, J. S., and Deshusses, M. A. ( 1998). “Performance of a pilot scale biotrickling filter under non-steady state conditions.” Proc., 1998 USC-TRG Conf. on Biofiltration, F. E. Reynolds, ed., The Reynolds Group, Tustin, Calif.
4.
Deshusses, M., Johnson, C., and Leson, G. ( 1999). “Biofiltration of high loads of ethyl acetate in the presence of toluene.” J. Air & Waste Mgmt. Assn., 49, 973–979.
5.
Dirk-Faitakis, C., and Allen, D. G. ( 1998). “Performance of biofilters treating fluctuating concentrations of air emissions in the forest products industry.” Proc., Air & Waste Mgmt. Assn. 91st Annu. Meeting & Exhibition, Pittsburgh (CD-ROM).
6.
Eklund, B. M., and Nelson, T. P. ( 1995). “Evaluation of VOC emission measurement methods for paint spray booths.” J. Air & Waste Mgmt. Assn., 45, 196–205.
7.
Jutras, E. M., Smart, C. M., Rupert, R., Pepper, I. L., and Miller, R. M. ( 1997). “Field-scale biofiltration of gasoline vapors extracted from beneath a leaking underground storage tank.” Biodegradation, 8, 31–42.
8.
Lesley, M. P., and Rangan, C. R. ( 1997). “Integrating biofiltration with SVE: A case study.” J. Soil Contamination, 6(1), 95–112.
9.
Leson, G., and Winer, A. M. ( 1991). “Biofiltration: An innovative air pollution control technology for VOC emission.” J. Air & Waste Mgmt. Assn., 41(8), 1045–1054.
10.
Mairitsch, K., and Paul, J. ( 1998). “Waste gas treatment with a combined technology of biofilter and adsorption.” Proc., 1998 USC-TRG Conf. on Biofiltration, F. E. Reynolds, ed., The Reynolds Group, Tustin, Calif.
11.
Martin, F. J., and Loehr, R. C. ( 1996). “Effect of periods of non-use on biofilter performance.” J. Air & Waste Mgmt. Assn., 46, 539–546.
12.
Park, J. ( 2000). “Development and evaluation of a slip feed vapor phase bioreactor.” Master's thesis, Civil Engineering Department, University of Texas at Austin.
13.
Peters, D. A., Hickman, G. T., Stefanoff, J. G., and Garcia, M. B. ( 1993). “Laboratory assessment of biofiltration for fuel-derived VOC emissions control.” Proc., Air & Waste Mgmt. Assn. 86th Annu. Meeting & Exhibition, Paper No. 93-WA-52B.06, Pittsburgh.
14.
Rameriz, J., and Kinney, K. A. ( 2000). “Aerosol delivery of nutrients to a compost biofilter.” Proc., Air & Waste Mgmt. Assn. 93rd Annu. Meeting & Exhibition, Pittsburgh (CD-ROM).
15.
Reid, R. C., Prausnitz, J. M., and Sherwood, T. K. ( 1977). The properties of gases and liquids, 3rd Ed., McGraw-Hill, New York.
16.
van Groenestijn, J. W., and Lake, M. E. ( 1998). “Elimination of alkanes from off-gases using trickling filters containing two liquid phases.” Proc., Air & Waste Mgmt. Assn. 91st Annu. Meeting & Exhibition, Paper No. 98-TA20B.02, Pittsburgh (CD-ROM).
17.
Weber, F. J., and Hartmans, S. ( 1995). “Use of activated carbon as a buffer in biofiltration of waste gases with fluctuating concentrations of toluene.” Appl. Microbiol. Biotechnol., 43, 365–369.
18.
Webster, T. S., Cox, H. H., and Deshusses, M. A. ( 1999). “Resolving operational and performance problems encountered in the use of a pilot/full-scale biotrickling filter reactor.” Envir. Progress, 18(3), 162–172.
19.
Williams, T. O., and Miller, F. C. ( 1992). “Biofilters and facility operations.” BioCycle, (Nov.), 75–79.
Information & Authors
Information
Published In
History
Received: Oct 5, 1998
Published online: Mar 1, 2001
Published in print: Mar 2001
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.