Properties of Red Mud Tailings Produced under Varying Process Conditions
Publication: Journal of Environmental Engineering
Volume 124, Issue 3
Abstract
The objective of the paper is to investigate the effect of temperature and caustic soda concentration in the bauxite digestion process on the settling behavior and the physical, chemical, and mineralogical characteristics of the derived red mud. The study was carried out on Jamaican bauxite. The results demonstrate the influence of the goethite-hematite conversion on the settling rate of red mud. This iron mineral transformation affects the specific gravity, which is one of the factors that affects the settling rate of the red muds. The iron conversion in turn is mainly affected by the temperature in the digestion step despite the variation of caustic soda concentration. The results also demonstrate that the specific surface area and the settling rate of red muds are inversely proportional and that a positive correlation exists between the amorphous and cryptocrystalline iron (Fed) and the settling rate of the Jamaican red muds.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Basu, P.(1983). “Reactions of iron minerals in sodium aluminate solutions.”Light Metals, 7, 83–97.
2.
Brassinga, R. D., and Fulford, G. D.(1986). “Determination of specific thickener area requirements for synfloc-flocculated red muds using a traversing gamma-radiation densitometer.”Light Metals, 10, 51–59.
3.
Brunauer, S., Emmett, P. H., and Teller, E.(1938). “Adsorption of gases in multimolecular layers.”J. Am. Chem. Soc., 60, 309–319.
4.
Building Research Institute. (1985). “Stabilised soil bricks.”BRI Tech. Notes, No. 4, Kingston, Jamaica.
5.
Davis, C. E. (1973). “The Mineralogy of Jamaican bauxites.”Proc., Bauxite Symp. II, J. Geo. Soc. of Jamaica. Kingston, Jamaica, 6–20.
6.
Grubbs, D. K., Libby, S. C., Rodenburg, J. K., and Wefers, K. A. (1980). “The geology, mineralogy and clarification properties of red and yellow Jamaican bauxites.”Proc., Bauxite Symp. IV, J. Geo. Soc. of Jamaica. Kingston, Jamaica, 176–186.
7.
Hsu, P. H. (1989). “Aluminium oxides and oxyhydroxides.”Minerals in soil environments, J. B. Dixon, S. B. Weed, and R. C. Dinauer, eds., Soil Science Society of America, Madison, Wis., 331–378.
8.
Li L. Y., and Rutherford(1996). “Effect of bauxite properties on the settling of red mud.”Int. J. Mineral Processing, 48, 169–182.
9.
McKeague, J. A., and Day, J. H.(1966). “Dithionite and oxalate-extractable Fe and Al as aids in differentiating various classes of soils.”Can J. Soil Sci., 46, 13–22.
10.
Mehra, O. P., and Jackson, M L. (1960). “Iron oxide removal from soils and clays by a dithionite-citrate system buffered with sodium bicarbonate.”7th Nat. Conf. Clays and Clay Minerals, Pergamon Press, New York, N.Y., 317–327.
11.
Orban, F., Pinter, T., Sigmond, G., Siklosi, P., Solymar, K., Toth, P., and Zambo, J.(1973). “Processing of bauxites containing goethite.”Hung. Teljes., Hungary, 6, 758.
12.
Ostap, S. (1984). “Effect of bauxite mineralogy in its processing characteristics.”Proc., 1984 Bauxite Symp. Leonard Jacob Jr., ed., AIME, New York, N.Y., 651–671.
13.
Parekh, B. K., and Goldberger, W. M. (1976). “An assessment of technology for possible utilization of Bayer process muds.”Envir. Protection Technol. Ser., Cincinnati, Ohio.
14.
Sheldrick, B. H., ed. (1984). “Analytical methods manual,”LRRI contribution No. 84-30, Land Resource Research Inst., Research Branch, Agriculture Canada, Ottawa, Canada, 10–12.
15.
Solymar, K., Zambo, J., Gado, P., and Orban, M.(1978). “The role of material science in the technological development of alumina production.”Light Metals, 2, 51–68.
16.
Solymar, K., Sajo, I., Steiner, J., and Zoldi, J.(1992). “Characteristics and separability of red mud.”Light Metals, 16, 209–223.
17.
Strahl, E. O. (1971). “The mineralogy of Jamaican bauxite and its effect on Bayer process technology.”Proc., 1971 Bauxite/Alumina Symp., Geo. Soc. of Jamaica. Kingston, Jamaica, 62–69.
18.
UNEP. (1985). “Environmental aspects of alumina production: A technical review.”UNEP/UNIDO Workshop on Envir. Aspects of Alumina Prod., Paris, France.
19.
UNIDO. (1983). “Pilot scale testing of representative samples of bauxite residues/red mud for profitable utilisation in the building materials industry,”Proj. No. SI/JAM/81/802.
20.
Zambo, J.(1979). “Red mud: Its properties handling, storage and utilization.”Travaux, Budapest, Hungary, 15, 265.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 124 • Issue 3 • March 1998
Pages: 254 - 264
Copyright
Copyright © 1998 American Society of Civil Engineers.
History
Published online: Mar 1, 1998
Published in print: Mar 1998
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.