Petroleum Environmental Research Forum Field Study on Biofilters for Control of Volatile Hydrocarbons
Publication: Journal of Environmental Engineering
Volume 123, Issue 6
Abstract
A field study on the treatment of volatile petroleum hydrocarbons (PHC) by biofiltration was conducted by the Petroleum Environmental Research Forum (PERF) between 1992 and 1994. Its objective was to assess the technical, regulatory, and economic feasibility of biofiltration for off-gases from petroleum processing and soil remediation equipment. It involved three small-scale biofilters provided by U.S. vendors, treating off-gas from two soil vapor extraction sites and a source of refinery wastewater. Comprehensive monitoring of biofilter operating parameters and performance was conducted. The results suggest that biofilters remove major petroleum hydrocarbon classes to strongly varying degrees. Typically more than 95% of aromatic compounds such as benzene, and odorous reduced sulfur compounds can be removed at residence times of one minute or less, while removal of more than 70% of light aliphatics will require residence times of several minutes, and will thus require correspondingly large filter volumes and higher capital expenditure. This indicates that off-gas composition and regulatory control objective will largely determine whether biofiltration is economically feasible for a given off-gas stream. The high percentage removal of aromatic hazardous air pollutants (HAP) and odors can generally be accomplished at comparatively short residence times (one minute or less) while the need for high-percentage removal, particularly of light aliphatics (<C5) will generally render biofiltration noncompetitive. Results from the field tests also showed that biofilter performance and operational reliability depend on the selection of filter material, the reliability of the moisture control system, and the level of fluctuation in PHC concentrations. This agrees with the findings from other full-scale biofilter projects. Finally, a preliminary economic comparison of biofilters and established control technologies suggested that biofiltration may, for a representative design case involving off-gas from a refinery wastewater treatment operation, offer considerable savings in total cost of air pollution control for petroleum hydrocarbon streams if regulations require the control of aromatic HAP or odors.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Apel, W. et al. (1993). “Removal of gasoline vapors from air streams by biofiltration.” Idaho Nat. Engrg. Lab., Idaho Falls, Idaho.
2.
Baltzis, B., and Shareefdeen, Z. (1994). “Biofiltration of VOC mixtures: modeling and pilot scale experimental verification.”Proc., 85th Annu. Meeting, Air and Waste Mgmt. Assn., Pittsburgh, Pa.
3.
Chang, A. N., and Yoon, H. (1995). “Biofiltration of gasoline vapors.”Proc., 1995 USC Conf. on Biofiltration, Univ. of Southern California, Los Angeles, Calif.
4.
Devinny, J. S., Hodge, D. S., Chang, A. N., and Reynolds, F. E. (1995). “Biofiltration of gasoline vapors from a soil vapor extraction system.”Proc., Annu. Conf. of ASCE, ASCE, New York, N.Y.
5.
Hodge, D. (1993). “Biofiltration: application for treatment of ethanol vapors,” PhD thesis, Univ. of Southern California, Los Angeles, Calif.
6.
Hodge, D. S., and Devinny, J. S.(1995). “Modeling removal of air contaminants by biofiltration.”J. Envir. Engrg., ASCE, 121, 21–32.
7.
Hodge, D. S., Medina, V. F., Islander, R. L., and Devinny, J. S.(1991). “Treatment of hydrocarbon fuel vapors in biofilters.”Envir. Technol., 12, 655–662.
8.
Kampbell, D. H., Wilson, J. T., Read, H. W., and Stocksdale, T. T.(1987). “Removal of volatile aliphatic hydrocarbons in a soil bioreactor.”J. the Air Pollution Control Assn., 37, 1236.
9.
Leson, G., and Winer, A. M.(1991). “Biofiltration: an innovative air pollution control technology for VOC emissions.”J. the Air and Waste Mgmt. Assn., 41(8), 1045–1054.
10.
Leson, G., and Dharmavaram, S. (1995). “A status overview of biological air pollution control.”Proc., 88th Annu. Meeting, Air and Waste Mgmt. Assn., Pittsburgh, Pa.
11.
Leson, G., Chavira, R., Winer, A., and Hodge, D. (1995). “Experiences with a full-scale biofilter for control of ethanol emissions.”Proc., 88th Annu. Meeting, Air and Waste Mgmt. Assn., Pittsburgh, Pa.
12.
Ottengraf, S. P. P. (1986). “Exhaust gas purification.”Biotechnology, Vol. 8, H. J. Rehm and G. Reed, eds., VCH Verlagsgesellschaft, Weinheim, Germany.
13.
Singleton, B., and Kant, W. (1995). “Three case studies of biofiltration for the removal of BTEX compounds, H2S and organic reduced sulfur compounds.”Proc., 88th Annu. Meeting, Air and Waste Mgmt. Assn., Pittsburgh, Pa.
14.
Togna, P., and Skladany, G. (1994). “Field pilot-scale vapor-phase treatment of styrene using biofiltration.”Bioremediation–field experience, P. E. Flathman, D. E. Teiger, and J. H. Exner, eds., Lewis Publishers, CRC Press, Inc., Boca Raton, Fla., 507–520.
15.
van Lith, C. (1996). “Long term experiences with biofilter material stabilized with inert additives.”Proc., 89th Annu. Meeting, Air and Waste Mgmt. Assn., Pittsburgh, Pa.
16.
van Lith, C., Leson, G., and Michelsen, R. (1997). “Evaluating design options for biofilters.”J. the Air and Waste Mgmt. Assn. 47(1), 37–48.
17.
Yang, Y., and Allen, E. R.(1994). “Biofiltration control of hydrogen sulfide.”J. the Air and Waste Mgmt. Assn., part 1, 44(7), 863–868.
18.
Yang, Y., and Allen, E. R.(1994). “Biofitration control of hydrogen sulfide.”J. the Air and Waste Mgmt. Assn., part 2, 44(11), 1315–1321.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 123 • Issue 6 • June 1997
Pages: 556 - 562
Copyright
Copyright © 1997 American Society of Civil Engineers.
History
Published online: Jun 1, 1997
Published in print: Jun 1997
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.