Maximum COD Loading Capacity in UASB Reactors at 37°C
Publication: Journal of Environmental Engineering
Volume 119, Issue 1
Abstract
The maximum capacity chemical oxygen demand (COD) loading in upflow anaerobic sludge blanket (UASB) reactors is evaluated using three 8.5 L reactors and high‐strength synthetic wastewaters composed of milk and sucrose at 37°C. The study was conducted over a wide‐range COD loading rate (18–260 g·L−1·day−1), by varying hydraulic retention time (HRT) (1.8–10 hr) and COD levels in wastewater (6,000–20,000 mg/L). At COD loading rates of up to 160 g·L−1·day−1, which corresponded to HRT of 1.8 h and COD of 12,000 mg/L in the wastewater, the process removed 94–98% of soluble COD and 75–90% of total COD. At rates higher than 160 g·L−1·day−1, the efficiency of COD removal deteriorated because of sludge disintegration and washout resulting from vigorous mixing by the biogas produced. The capability of volatile suspended solids (VSS) to convert COD to methane increased with COD loading; it reached the maximum of 1.7 g methane COD per gram VSS per day at the COD loading of 100 g·L−1·day−1, corresponding to the food‐to‐microorganism (F/M) ratio of 3 g COD per gram VSS per day. Characteristics of the sludge granules, effluent, and biogas are also discussed.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Aivasidis, A. (1985). “Anaerobic treatment of sulfite evaporator condensate in a fixed bed loop reactor.” Water Sci. Tech., 17(1), 207–221.
2.
Aivasidis, A., and Wandrey, C. (1988). “Recent developments in process and reactor design for anaerobic wastewater treatment.” Water Sci. Tech., 20(1), 211–218.
3.
Dolfing, J. (1987). “Microbiological aspects of granular methanogenic sludge,” PhD thesis, Dept. of Microbiology, Agricultural University, Wageningen, The Netherlands.
4.
Fang, H. H. P., Guohua, L., Jinfu, Z., Bute, C., and Guowei, G. (1990). “Treatment of brewery effluent by UASB process.” J. Envir. Engrg., ASCE, 116(3), 454–460.
5.
Fox, P., and Suidan, M. T. (1990). “Batch tests to determine activity distribution and kinetic parameters for acetate utilization in expanded‐bed anaerobic reactors.” Appl. and Envir. Microbiology, 56(4), 887–894.
6.
Gorris, L. G. M., von Deursen, J. M. A., van der Drift, C., and Vogels, G. D. (1988). “Biofilm development in laboratory methanogenic fluidized bed reactors.” Biotech. Bioengrg., 33, 687–693.
7.
Gossett, J. M., and Belser, R. L. (1982). “Anaerobic digestion of waste activated sludge.” J. Envir. Engrg., ASCE, 108(6), 1101–1120.
8.
Gujer, W., and Zehnder, A. J. B. (1983). “Conversion processes in anaerobic digestion.” Water Sci. Tech., 15(8/9), 127–167.
9.
Henze, M., and Harremoes, P. (1983). “Anaerobic treatment of wastewater in fixed film reactors—A literature review.” Water Sci. Tech., 15(8/9), 1–101.
10.
Hickey, R. F., Wu, W.‐M., Viega, M. C., and Jone, R. (1991). “Start‐up, operation, monitoring and control of high‐rate anaerobic treatment systems.” Water Sci. Tech., 24(8), 207–256.
11.
Hulshof Pol, L. W. (1989). “The phenomenon of granulation of anaerobic sludge,” PhD thesis, Agricultural Univ., Wageningen, The Netherlands.
12.
Iza, J. (1991). “Fluidized bed reactors for anaerobic wastewater treatment.” Water Sci. Tech., 24(8), 109–132.
13.
Jewell, W. J., Switzenbaum, M. S., and Morris, J. W. (1981). “Municipal wastewater treatment with the anaerobic attached microbial film expanded bed process.” J. Water Poll. Control Fed., 53, 482–490.
14.
Kennedy, K. J., and Droste, R. L. (1985). “Start‐up of anaerobic downflow stationary fixed film (DSFF) reactors.” Biotech. Bioengrg., 27, 1152–1165.
15.
Kennedy, K. J., and Droste, R. L. (1991). “Anaerobic wastewater treatment in downflow stationary fixed film reactors.” Water Sci. Tech., 24(8), 157–177.
16.
Lettinga, G., and Hulshoff Pol, L. W. (1991). “UASB‐process design for various types of wastewaters.” Water Sci. Tech., 24(8), 87–107.
17.
Lettinga, G., van Velsen, A. F. M., Homba, S. W., de Zecuw, W. and Klapwijk, A. (1980). “Use of the upflow sludge blanket (USB) reactor concept for biological wastewater treatment.” Biotech. Bioengrg., 22, 699–734.
18.
MacLeod, F. A., Guiot, S. R., and Costeron, J. W. (1990). “Layered structure of bacterial aggregates produced in an upflow anaerobic sludge bed and filter reactor.” Appl. Environ. Microbiology, 56(6), 1598–1607.
19.
Morris, J. W. (1983). “Conversion of particulates in an expanded bed,” PhD thesis, Cornell Univ., Ithaca, N.Y.
20.
Mosey, F. E., and Matthews, R. H. (1982). “A simple gas meter for laboratory scale anaerobic digesters.” Water Research Centre, Stevengage Laboratory, Stevengage, United Kingdom.
21.
Ney, U., Macario, A. J. L., Conway de Macario, E., Aivasidis, A., Schoberth, S. M., and Sahu, H. (1990). “Quantitative microbiological analysis of bacterial community shifts in a high‐rate anaerobic bioreactor treating sulfite evaporator condensate.” Appl. and Envir. Microbiology, 56(8), 2389–2398.
22.
Owen, W. F., Stuckey, D. C., Healy, J. B., Young, L. Y., and McCarty, P. L. (1979). “Bioassay for monitoring biochemical methane potential and anaerobic toxicity.” Water Res., 13, 485–492.
23.
Speece, R. E. (1983). “Anaerobic biotechnology for the industrial wastewater treatment.” Environ. Sci. Tech., 17(9), 416A–427A.
24.
Standard methods for the examination of water and wastewater. (1985). 16th Ed., American Public Health Assoc., Washington, D.C.
25.
Suidan, M. T., Siekerka, G. L., Kao, S. W., and Pfeffer, J. T. (1983). “Anaerobic filters for the treatment of coal gasification wastewater.” Biotech. Bioengrg., 26, 1581–1596.
26.
Sutton, P. M., and Li, A. (1983). “Single phase and two phase anaerobic stabilization in fluidized bed reactors.” Water Sci. Tech., 15(8/9), 333–344.
27.
Switzenbaum, M. S., and Jewell, W. J. (1980). “Anaerobic attached film expanded‐bed reactor treatment.” J. Water Poll. Control. Fed., 52, 1953–1965.
28.
Wang, Y. T., Suidan, M. T., and Rittman, B. E. (1986). “Anaerobic treatment of phenol by an expanded‐bed reactor.” J. Water Poll. Control Fed., 58, 227–233.
29.
Wang, Y. T. (1984). “Modeling of biological activity in expanded‐bed anaerobic activated carbon filters,” PhD thesis, Univ. of Illinois, Urbana‐Champaign, Ill.
30.
Young, J. C. (1991). “Factors affecting the design and performance of upflow anaerobic filters.” Water Sci. Tech., 24(8), 133–155.
31.
Young, J. C., and McCarty, P. L. (1969). “The anaerobic filter for waste treatment.” J. Water Poll. Control Fed., 41, R160–173.
32.
Young, J. C., and Young, H. W. (1991). “Full‐scale treatment of chemical process wastes using anaerobic filters.” J. Water Poll. Control Fed., 63, 153–159.
33.
Zehnder, A. J. B., ed. (1988). Biology of anaerobic microorganisms. John Wiley and Sons, New York, N.Y.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 119 • Issue 1 • January 1993
Pages: 103 - 119
Copyright
Copyright © 1993 American Society of Civil Engineers.
History
Received: Jul 18, 1991
Published online: Jan 1, 1993
Published in print: Jan 1993
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.