Use of Zero-Discharge Technology to Recycle Salt in Desulfurization Wastewater
Publication: Journal of Environmental Engineering
Volume 149, Issue 5
Abstract
As a series of laws and regulations governing the water drainage in coal-fired power plants have been implemented in China, the discharge requirements of desulfurization wastewater from coal-fired power plants are becoming increasingly stringent. Conventional desulfurization wastewater treatment can no longer satisfy the needs of the current zero-discharge policy. It is imperative to develop advanced desulfurization wastewater treatment technology. Low-temperature flue gas waste heat concentration and desulfurization wastewater technology, a current low-cost zero-discharge technology, has attracted the wide attention of the industry. When the wastewater is concentrated nearly 8–15 times, the concentration of chloride ions in the concentrated wastewater can be increased to nearly . Moreover, the wastewater has strong acidity, and the pH is nearly 1.0–2.0. The effective use of this concentrated waste liquid is the key to the success of low-temperature flue gas waste heat concentration desulfurization wastewater treatment technology. Accordingly, this study suggests that the compound water purifying agent of polymeric ferric chloride (PFC) and polymeric ferric sulfate (PFS) can be prepared through the reaction of concentrated high-chlorine wastewater with red mud, and PFC and PFS have a synergistic effect on water purification. The prepared water purifiers outperform PFS or polyaluminum ferric sulfate (PAFS) in selectivity, sensitivity, and cost-effectiveness. Water purifier preparation experiments and flocculating effect comparison experiments were performed. The resource utilization of salt was achieved in the concentrated waste liquid. This technical route provides a novel insight into the reasonable transfer of salt in desulfurization wastewater and the preparation of compound water-purifying agents.
Practical Applications
This study proposes a technical process for zero discharge of desulphurization wastewater coupled with the preparation of a water purifier which changes the conventional preparation method of water purifiers. It solves the problems of high concentrations of chlorine salt and the large use and cost of pharmaceuticals in high-salt wastewater from power plants. Moreover, it used red mud and industrial waste acid resources to turn waste into a valuable resource and solved the problem of misplaced and wasted resources. Low-temperature flue gas waste heat was adopted to concentrate desulfurized wastewater, such that the concentration of chloride ions in wastewater was concentrated into high-chlorine wastewater. The compound water purifier of polymeric ferric chloride and polymeric ferric sulfate was prepared by the reaction of concentrated low-pH and high-chlorine wastewater with red mud and waste acid. The compound water purifier was used for sewage pretreatment to reduce turbidity and chemical oxygen demand (COD) content of sewage.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
All data, models, and code generated or used during the study appear in the published paper.
Acknowledgments
This experimental work was supported by Yanfei Yu, and the sample was provided by Wuxue Lv. The authors thank them.
References
Bai, F., P. Wu, J. Liu, and Y. Gao. 2014. “Synthesis and properties of polyaluminum ferric chloride (PAFC) flocculant.” J. Inner Mongolia Agric. Univ. 35 (6): 158–161.
Barrington, D. J., and G. Ho. 2014. “Towards zero liquid discharge: The use of water auditing to identify water conservation measures.” J. Cleaner Prod. 66 (Mar): 571–576. https://doi.org/10.1016/j.jclepro.2013.11.065.
Chen, D., D.-Q. Zhu, and Y. Chen. 2014. “Preparation of prereduced pellets by pyrite cinder containing nonferrous metals with high temperature chloridizing-reduction roasting technology.” ISIJ Int. 54 (10): 2162–2168. https://doi.org/10.2355/isijinternational.54.2162.
Chen, H., L. Zhan, L. Gu, H. Zhou, Q. Feng, H. Wu, S. Zhao, and L. Yang. 2022. “Fate and distribution of mercury during the desulfurization wastewater evaporation process.” Fuel 318 (Jun): 123609. https://doi.org/10.1016/j.fuel.2022.123609.
Chen, M., C. Zou, W. Tang, Y. Huang, and H. Sun. 2021. “Characterization and flocculation evaluation of a new organic–inorganic hybrid polymer flocculant (PAC-AM-DMC).” J. Appl. Polym. Sci. 138 (47): 51388. https://doi.org/10.1002/app.51388.
Enoch, G. D., W. F. van den Broeke, and W. Spiering. 1994. “Removal of heavy metals and suspended solids from wastewater from wet lime (stone)—Gypson flue gas desulphurization plants by means of hydrophobic and hydrophilic crossflow microfiltration membranes.” J. Membr. Sci. 87 (1–2): 191–198. https://doi.org/10.1016/0376-7388(93)E0146-B.
Fu, F., and Q. Wang. 2011. “Removal of heavy metal ions from wastewaters: A review.” J. Environ. Manage. 92 (3): 407–418. https://doi.org/10.1016/j.jenvman.2010.11.011.
Grant, S. B., et al. 2012. “Taking the ‘waste’ out of ‘wastewater’ for human water security and ecosystem sustainability.” Science 337 (6095): 681–686. https://doi.org/10.1126/science.1216852.
Gu, L., T. Shen, L. Zhan, H. Chen, Q. Feng, H. Zhou, and L. Yang. 2022. “Release characteristics of chloride during single droplet drying process of desulfurization wastewater.” J. Chem. Technol. Biotechnol. 97 (1): 120–129. https://doi.org/10.1002/jctb.6917.
Håkansson, H., and P. Ahlgren. 2005. “Acid hydrolysis of some industrial pulps: Effect of hydrolysis conditions and raw material.” Cellulose 12 (2): 177–183.
Han, X., T. Yuan, D. Zhang, Y. Dai, J. Liu, and J. Yan. 2021. “Waste heat utilization from boiler exhaust gases for zero liquid discharge of desulphurization wastewater in coal-fired power plants: Thermodynamic and economic analysis.” J. Cleaner Prod. 308 (Jun): 127328. https://doi.org/10.1016/j.jclepro.2021.127328.
Huang, T.-L., J. M. MacInnes, and K. R. Cliffe. 2001. “Nitrogen removal from wastewater by a catalytic oxidation method.” Water Res. 35 (9): 2113–2120. https://doi.org/10.1016/S0043-1354(00)00492-9.
Jegatheesan, V., L. Shu, and L. Jegatheesan. 2021. “Producing fit-for-purpose water and recovering resources from various sources: An overview.” Environ. Qual. Manage. 31 (2): 9–28. https://doi.org/10.1002/tqem.21780.
Khan, M. M. T., P. S. Stewart, D. J. Moll, W. E. Mickols, M. D. Burr, S. E. Nelson, and A. K. Camper. 2010. “Assessing biofouling on polyamide reverse osmosis (RO) membrane surfaces in a laboratory system.” J. Membr. Sci. 349 (1–2): 429–437. https://doi.org/10.1016/j.memsci.2009.12.006.
Liang, Y., G. Wang, Z. Wu, W. Liu, M. Song, Y. Sun, X. Chen, H. Zhan, and S. Bi. 2020. “‘Inorganic polymer flocculation catalyst’—Polyaluminum chloride as highly efficient and green catalyst for the Friedel-crafts alkylation of bis(indolyl)methanes.” Catal. Commun. 147 (Dec): 106136. https://doi.org/10.1016/j.catcom.2020.106136.
Liu, H., F. Cheng, and D. Wang. 2009. “Interaction of ozone and organic matter in coagulation with inorganic polymer flocculant-PACl: Role of organic components.” Desalination 249 (2): 596–601. https://doi.org/10.1016/j.desal.2008.06.032.
Ma, S., J. Chai, G. Chen, W. Yu, and S. Zhu. 2016. “Research on desulfurization wastewater evaporation: Present and future perspectives.” Renewable Sustainable Energy Rev. 58 (Jun): 1256–1268. https://doi.org/10.1016/j.rser.2015.12.234.
Ma, S., J. Chai, K. Jiao, L. Ma, S. Zhu, and K. Wu. 2017. “Environmental influence and countermeasures for high humidity flue gas discharging from power plants.” Renewable Sustainable Energy Rev. 73 (Apr): 225–235. https://doi.org/10.1016/j.rser.2017.01.143.
Niskanen, J., M. Lahtinen, and S. Perämäki. 2022. “Acetic acid leaching of neodymium magnets and iron separation by simple oxidative precipitation.” Cleaner Eng. Technol. 10 (Oct): 100544. https://doi.org/10.1016/j.clet.2022.100544.
Ovenden, C., and H. Xiao. 2002. “Flocculation behaviour and mechanisms of cationic inorganic microparticle/polymer systems.” Colloids Surf., A 197 (1–3): 225–234. https://doi.org/10.1016/S0927-7757(01)00903-7.
Shi, Y., C. Zhang, R. Li, S. Zhuo, Y. Jin, L. Shi, S. Hong, J. Chang, C. Ong, and P. Wang. 2018. “Solar evaporator with controlled salt precipitation for zero liquid discharge desalination.” Environ. Sci. Technol. 52 (3): 11822–11830. https://doi.org/10.1021/acs.est.8b03300.
Tong, T., and M. Elimelech. 2016. “The global rise of zero liquid discharge for wastewater management: Drivers, technologies, and future directions.” Environ. Sci. Technol. 50 (13): 6846–6855. https://doi.org/10.1021/acs.est.6b01000.
Vajihinejad, V., S. P. Gumfekar, B. Bazoubandi, Z. Rostami Najafabadi, and J. B. P. Soares. 2019. “Water soluble polymer flocculants: Synthesis, characterization, and performance assessment.” Macromol. Mater. Eng. 304 (2): 1800526. https://doi.org/10.1002/mame.201800526.
Wang, B., Z. Song, and L. Sun. 2021. “A review: Comparison of multi-air-pollutant removal by advanced oxidation processes—Industrial implementation for catalytic oxidation processes.” Chem. Eng. J. 409 (12): 128136. https://doi.org/10.1016/j.cej.2020.128136.
Wang, D., W. Sun, Y. Xu, H. Tang, and J. Gregory. 2004. “Speciation stability of inorganic polymer flocculant–PACl.” Colloids Surf., A 243 (1–3): 1–10. https://doi.org/10.1016/j.colsurfa.2004.04.073.
Wang, D., and H. Tang. 2001. “Modified inorganic polymer flocculant-PFSi: Its preparation, characterization and coagulation behavior.” Water Res. 35 (14): 3418–3428. https://doi.org/10.1016/S0043-1354(01)00034-3.
Wang, X., S. Zheng, Y. Zhang, Y. Zhang, S. Qiao, Z. Long, B. Zhao, and Z. Li. 2022. “Sulfuric acid leaching of ball-milling activated residue after lithium extraction from spent lithium iron phosphate cathode powder.” Waste Manage. 153 (Aug): 31–40. https://doi.org/10.1016/j.wasman.2022.08.009.
Wu, D. Y., D. X. Wang, Z. Q. Liu, S. Rao, and K. F. Zhang. 2022. “Selective recovery of lithium from spent lithium iron phosphate batteries using oxidation pressure sulfuric acid leaching system.” Trans. Nonferrous Met. Soc. China 32 (6): 2071–2079. https://doi.org/10.1016/S1003-6326(22)65931-4.
Wypiór, T., and R. Krzyżyńska. 2020. “Effect of ammonia and ammonium compounds on wet-limestone flue gas desulfurization process from a coal-based power plant—Preliminary industrial scale study.” Fuel 281 (Dec): 118564. https://doi.org/10.1016/j.fuel.2022.123609.
Xin, Y., Z. Zhou, Q. Ming, D. Sun, J. Han, X. Ye, S. Dai, L. Jiang, X. Zhao, and Y. An. 2020. “A two-stage desalination process for zero liquid discharge of flue gas desulfurization wastewater by chloride precipitation.” J. Hazard. Mater. 397 (Oct): 122744. https://doi.org/10.1016/j.jhazmat.2020.122744.
Yang, P., D. Li, W. Zhang, N. Wang, Z. Yang, D. Wang, and T. Ma. 2019. “Flocculation-dewatering behavior of waste activated sludge particles under chemical conditioning with inorganic polymer flocculant: Effects of typical sludge properties.” Chemosphere 218 (Jun): 930–940. https://doi.org/10.1016/j.chemosphere.2018.11.169.
Zhang, W., W. Sun, Y. Zhang, D. Yu, W. Piao, H. Wei, X. Liu, and C. Sun. 2023. “Effect of inorganic salt on the removal of typical pollutants in wastewater by RuO2/TiO2 via catalytic wet air oxidation.” Chemosphere 312 (Feb): 137194. https://doi.org/10.1016/j.chemosphere.2022.137194.
Zhang, W., P. Xiao, Y. Liu, S. Xu, F. Xiao, D. Wang, and C. W. K. Chow. 2014. “Understanding the impact of chemical conditioning with inorganic polymer flocculants on soluble extracellular polymeric substances in relation to the sludge dewaterability.” Sep. Purif. Technol. 132 (6): 430–437. https://doi.org/10.1016/j.seppur.2014.05.034.
Zhao, C., X. Liu, and G. Wang. 2009. “Preparation and properties of polyaluminum ferric chloride by roasting method.” J. Qingdao Univ. Sci. Technol. 2009 (30): 21–25.
Zheng, R., Z. J. Guo, and Y. Zhou. 2010. “Indirect determination of tiopronin by spectrophotometry with o-phenanthroline hydrate-Iron(II).” Chin. J. Anal. Lab. 29 (10): 68–71.
Zhu, Z., L. Xu, Z. Han, J. Liu, L. Zhang, C. Yang, Z. Xu, and P. Liu. 2022. “Defluorination study of spent carbon cathode by microwave high-temperature roasting.” J. Environ. Manage. 302 (5): 114028. https://doi.org/10.1016/j.jenvman.2021.114028.
Information & Authors
Information
Published In
Copyright
© 2023 American Society of Civil Engineers.
History
Received: Jun 30, 2022
Accepted: Dec 12, 2022
Published online: Feb 21, 2023
Published in print: May 1, 2023
Discussion open until: Jul 21, 2023
ASCE Technical Topics:
- Chemical compounds
- Chemical elements
- Chemicals
- Chemistry
- Energy engineering
- Energy infrastructure
- Energy sources (by type)
- Engineering materials (by type)
- Environmental engineering
- Hydro power
- Hydrologic engineering
- Infrastructure
- Lifeline systems
- Materials engineering
- Power plants
- Recycling
- Renewable energy
- Salt water
- Sulfur
- Wastewater management
- Water (by type)
- Water and water resources
- Water discharge
- Water management
- Water treatment
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.