Unconfined Compressive Strength and Visualization of the Microstructure of Coarse Sand Subjected to Different Biocementation Levels
This article has a reply.
VIEW THE REPLYPublication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 145, Issue 8
Abstract
Biocementation processes rely on microbial-induced calcite precipitation (MICP), which is a naturally occurring biochemical process. Biocement materials are a form of environmental cementitious agents used to improve the mechanical properties of granular soils by physically binding soil particles together. Efficient improvement of the macromechanical behavior of coarse sand treated by various amounts of biocement materials requires an in-depth understanding of its microstructure. This paper examined the effect of a number of bacterial suspension and cementation solution flushes on the macromechanical behavior of coarse sand. Also, X-ray computed tomography (XCT), scanning electron microscopy (SEM), and energy dispersive spectroscopy (EDS) were used to investigate changes occurring at microlevels. The results show that compressive strength increased with an increase of biocement materials, and the maximum compressive strength achieved was around 14 MPa. The microscopic investigations were linked to the macromechanical changes, providing unique insight into the causation of the changes. Furthermore, several common soil properties (calcium carbonate content, dry density, void ratio, and porosity) were successfully identified using the XCT technique.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors acknowledge the use of the facilities within the Monash Centre for Electron Microscopy. The XCT equipment used in this study was purchased through a Monash University-led multi-institutional grant funded in part by the Australian Research Council (ARC) Large Equipment and Infrastructure scheme (LEIF) (Grant No. LE13010006).
References
Al Mahbub, A., and A. Haque. 2016. “X-ray computed tomography imaging of the microstructure of sand particles subjected to high pressure one-dimensional compression.” Materials 9 (11): 890. https://doi.org/10.3390/ma9110890.
Al Qabany, A., and K. Soga. 2013. “Effect of chemical treatment used in MICP on engineering properties of cemented soils.” Géotechnique 63 (4): 331–339.
Al Qabany, A., K. Soga, and C. Santamarina. 2012. “Factors affecting efficiency of microbially induced calcite precipitation.” J. Geotech. Geoenviron. Eng. 138 (8): 992–1001. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000666.
Al-Thawadi, S. 2008. “High strength in-situ biocementation of soil by calcite precipitating locally isolated ureolytic bacteria.” Ph.D. thesis, Dept. of Biotechnology, Murdoch Univ.
ASTM. 2004. Standard test method for determination of pore volume and pore volume distribution of soil and rock by mercury intrusion porosimetry. ASTM D4404. West Conshohocken, PA: ASTM.
ASTM. 2006. Standard practice for classification of soils for engineering purposes (unified soil classification system). ASTM D2487. West Conshohocken, PA: ASTM.
ASTM. 2014a. Standard test methods for maximum index density and unit weight of soils using a vibratory table. ASTM D4253. West Conshohocken, PA: ASTM.
ASTM. 2014b. Standard test methods for minimum index density and unit weight of soils and calculation of relative density. ASTM D4254. West Conshohocken, PA: ASTM.
Bang, S., J. Lippert, U. Yerra, S. Mulukutla, and V. Ramakrishnan. 2010. “Microbial calcite, a bio-based smart nanomaterial in concrete remediation.” Int. J. Smart Nano Mater. 1 (1): 28–39. https://doi.org/10.1080/19475411003593451.
Cheng, L., and R. Cord-Ruwisch. 2014. “Upscaling effects of soil improvement by microbially induced calcite precipitation by surface percolation.” Geomicrobiol. J. 31 (5): 396–406. https://doi.org/10.1080/01490451.2013.836579.
Cheng, L., R. Cord-Ruwisch, and M. A. Shahin. 2013. “Cementation of sand soil by microbially induced calcite precipitation at various degrees of saturation.” Can. Geotech. J. 50 (1): 81–90. https://doi.org/10.1139/cgj-2012-0023.
Cheng, L., and R. Cord-Ruwish. 2012. “In situ soil cementation with ureolytic bacteria by surface percolation.” Ecol. Eng. 42: 64–72. https://doi.org/10.1016/j.ecoleng.2012.01.013.
Choi, S. G., S. S. Park, S. Wu, and J. Chu. 2017. “Methods for calcium carbonate content measurement of biocemented soils.” J. Mater. Civ. Eng. 29 (11): 06017015. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002064.
Chu, J., V. Stabnikov, and V. Ivanov. 2012. “Microbially induced calcium carbonate precipitation on surface or in the bulk of soil.” Geomicrobiol. J. 29 (6): 544–549. https://doi.org/10.1080/01490451.2011.592929.
DeJong, J. T., M. B. Fritzges, and K. Nüsslein. 2006. “Microbially induced cementation to control sand response to undrained shear.” J. Geotech. Geoenviron. Eng. 132 (11): 1381–1392. https://doi.org/10.1061/(ASCE)1090-0241(2006)132:11(1381).
DeJong, J. T., B. M. Mortensen, B. C. Martinez, and D. C. Nelson. 2010. “Bio-mediated soil improvement.” Ecol. Eng. 36 (2): 197–210. https://doi.org/10.1016/j.ecoleng.2008.12.029.
Dhami, N. K., M. S. Reddy, and A. Mukherjee. 2013. “Biomineralization of calcium carbonate polymorphs by the bacterial strains isolated from calcareous sites.” J. Microbiol. Biotechnol. 23 (5): 707–714. https://doi.org/10.4014/jmb.1212.11087.
Dick, J., W. De Windt, B. De Graef, H. Saveyn, P. Van der Meeren, N. De Belie, and W. Verstraete. 2006. “Bio-deposition of a calcium carbonate layer on degraded limestone by Bacillus species.” Biodegradation 17 (4): 357–367. https://doi.org/10.1007/s10532-005-9006-x.
Gniel, J., and A. Bouazza. 2009. “Improvement of soft soils using geogrid encased stone columns.” Geotext. Geomembr. 27 (3): 167–175. https://doi.org/10.1016/j.geotexmem.2008.11.001.
Gniel, J., and A. Bouazza. 2010. “Construction of geogrid encased stone columns: A new proposal based on laboratory testing.” Geotext. Geomembr. 28 (1): 108–118. https://doi.org/10.1016/j.geotexmem.2009.12.012.
Hammes, F., and W. Verstraete. 2002. “Key roles of pH and calcium metabolism in microbial carbonate precipitation.” Rev. Environ. Sci. Biotechnol. 1 (1): 3–7. https://doi.org/10.1023/A:1015135629155.
Harkes, M. P., L. A. Van Paassen, J. L. Booster, V. S. Whiffin, and M. C. van Loosdrecht. 2010. “Fixation and distribution of bacterial activity in sand to induce carbonate precipitation for ground reinforcement.” Ecol. Eng. 36 (2): 112–117. https://doi.org/10.1016/j.ecoleng.2009.01.004.
Hasan, A., and K. A. AlShibli. 2010. “Experimental assessment of 3D particle-to-particle interaction within sheared sand using synchrotron microtomography.” Geotechnique 60 (5): 369–379. https://doi.org/10.1680/geot.2010.60.5.369.
Li, W., L. Liu, P. Zhou, L. Cao, L. Yu, and S. Jiang. 2011. “Calcite precipitation induced by bacteria and bacterially produced carbonic anhydrase.” Curr. Sci. 100 (4): 502–508.
Liu, X., and O. Buzzi. 2014. “Use of hand-spray plaster as a coating for soil bulk volume measurement.” Geotech. Test. J. 37 (3): 522–528. https://doi.org/10.1520/GTJ20130091.
Mahawish, A., A. Bouazza, and W. P. Gates. 2016. “Biogrouting coarse materials using soil-lift treatment strategy.” Can. Geotech. J. 53 (12): 2080–2085. https://doi.org/10.1139/cgj-2016-0167.
Mahawish, A., A. Bouazza, and W. P. Gates. 2017. “Microstructure of biocemented coarse sand.” In Proc., Int. Conf. on Piled Foundations and Ground Improvement Technology, 482–491. New York: DFI.
Mahawish, A., A. Bouazza, and W. P. Gates. 2018a. “Effect of particle size distribution on the bio-cementation of coarse aggregates.” Acta Geotech. 13 (4): 1019–1025. https://doi.org/10.1007/s11440-017-0604-7.
Mahawish, A., A. Bouazza, and W. P. Gates. 2018b. “Improvement of coarse sand engineering properties by microbially induced calcite precipitation.” Geomicrobiology 35 (10): 887–897. https://doi.org/10.1080/01490451.2018.1488019.
Mahawish, A., A. Bouazza, and W. P. Gates. 2019a. “Factors affecting the bio-cementing process of coarse sand.” Ground Improv. 172 (1): 25–36. https://doi.org/10.1680/jgrim.17.00039.
Mahawish, A., A. Bouazza, and W. P. Gates. 2019b. “Strengthening crushed coarse aggregates using bio-grouting.” Geomech. Geoeng. 14 (1): 59–70. https://doi.org/10.1080/17486025.2018.1521999.
Martinez, B. C., and J. T. DeJong. 2009. “Bio-mediated soil improvement: Load transfer mechanisms at the micro- and macro- scales.” In Proc., 2009 ASCE US-China Workshop on Ground Improvement Technologies, 242–251. Reston, VA: ASCE.
Montoya, B. M. 2012. “Bio-mediated soil improvement and the effect of cementation on the behavior, improvement, and performance of sand.” Ph.D. thesis, Dept. of Civil and Environmental Engineering, Univ. of California.
Mortensen, B., and J. DeJong. 2011. “Strength and stiffness of MICP treated sand subjected to various stress paths.” In Proc., Geo-Frontiers 2011, Advances in Geotechnical Engineering, 4012–4020. Reston, VA: ASCE.
Naeimi, M., and J. Chu. 2017. “Comparison of conventional and bio-treated methods as dust suppressants.” Environ. Sci. Pollut. Res. 24 (29): 23341–23350. https://doi.org/10.1007/s11356-017-9889-1.
Nafisi, A., and B. M. Montoya. 2018. “A new framework for identifying cementation level of MICP-treated sands.” In Proc., IFCEE, 37–47. Reston, VA: ASCE.
O’Donnell, S. T., and E. Kavazanjian Jr. 2015. “Stiffness and dilatancy improvements in uncemented sands treated through MICP.” J. Geotech. Geoenviron. Eng. 141 (11): 02815004. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001407.
Phillips, A. J., R. Gerlach, E. Lauchnor, A. C. Mitchell, A. B. Cunningham, and L. Spangler. 2013. “Engineered applications of ureolytic biomineralization: A review.” Biofouling 29 (6): 715–733. https://doi.org/10.1080/08927014.2013.796550.
Rong, H., C.-X. Qian, and L.-Z. Li. 2012. “Influence of molding process on mechanical properties of sandstone cemented by microbe cement.” Constr. Build. Mater. 28 (1): 238–243. https://doi.org/10.1016/j.conbuildmat.2011.08.039.
Shahrokhi-Shahraki, R., S. M. A. Zomorodian, A. Niazi, and B. C. O’Kelly. 2015. “Improving sand with microbial-induced carbonate precipitation.” Proc. Inst. Civ. Eng. Ground Improv. 168 (3): 217–230. https://doi.org/10.1680/grim.14.00001.
Stabnikov, V., V. Ivanov, and J. Chu. 2015. “Construction Biotechnology: A new area of biotechnological research and applications.” World J. Microbiol. Biotechnol. 31 (9): 1303–1314. https://doi.org/10.1007/s11274-015-1881-7.
Stocks-Fischer, S., J. K. Galinat, and S. S. Bang. 1999. “Microbiological precipitation of .” Soil Biol. Biochem. 31 (11): 1563–1571. https://doi.org/10.1016/S0038-0717(99)00082-6.
Tagliaferri, F., J. Waller, E. Andò, S. A. Hall, G. Viggiani, P. Bésuelle, and J. T. DeJong. 2011. “Observing strain localisation processes in bio-cemented sand using X-ray imaging.” Granular Matter 13 (3): 247–250. https://doi.org/10.1007/s10035-011-0257-4.
Terzis, D., and L. Laloui. 2017. “On the application of microbially induced calcite precipitation for soils: A multiscale study.” In Advances in laboratory testing and modelling of soils and shales (ATMSS), 388–394. Cham: Springer.
Terzis, D., and L. Laloui. 2018. “3-D micro-architecture and mechanical response of soil cemented via microbial-induced calcite precipitation.” Sci. Rep. 8 (1): 1416. https://doi.org/10.1038/s41598-018-19895-w.
van Paassen, L. A., M. C. M. van Loosdrecht, M. Pieron, A. Mulder, D. J. M. Ngan-Tillard, and T. J. M. Van der Linden. 2009. “Strength and deformation of biologically cemented sandstone.” In Proc., ISRM Regional Symp. -EUROCK 2009, 405–410. Boca Raton, FL: CRC Press/A.A. Balkema.
Van Paassen, L., M. Harkes, G. Van Zwieten, W. Van der Zon, W. Van der Star, and M. Van Loosdrecht. 2010. “Scale up of biogrout: A biological ground reinforcement method.” In Proc., 17th Int. Conf. on soil Mechanics and Geotechnical Engineering, 2328–2333. Amsterdam, Netherlands: Academia and Practice of Geotechnical Engineering.
Van Paassen, L. A. 2009. “Biogrout, ground improvement by microbial induced carbonate precipitation.” Ph.D. thesis, Environmental Biotechnology, Delft Univ. of Technology (TU Delft).
Wei, S., H. Cui, Z. Jiang, H. Liu, H. He, and N. Fang. 2015. “Biomineralization processes of calcite induced by bacteria isolated from marine sediments.” Braz. J. Microbiol. 46 (2): 455–464. https://doi.org/10.1590/S1517-838246220140533.
Weil, M. H., J. T. DeJong, B. C. Martinez, and B. M. Mortensen. 2012. “Seismic and resistivity measurements for real-time monitoring of microbially induced calcite precipitation in sand.” ASTM Geotech. Test. J. 35 (2): 330–341. https://doi.org/10.1520/GTJ103365.
Whiffin, V. S. 2004. “Microbial precipitation for the production of biocement.” Ph.D. thesis, Dept. of Biotechnology, Murdoch Univ.
Whiffin, V. S., L. A. V. Paassen, and M. P. Harkes. 2007. “Microbial carbonate precipitation as a soil improvement technique.” Geomicrobiol. J. 24 (5): 417–423. https://doi.org/10.1080/01490450701436505.
Information & Authors
Information
Published In
Copyright
©2019 American Society of Civil Engineers.
History
Received: Feb 9, 2018
Accepted: Jan 10, 2019
Published online: May 30, 2019
Published in print: Aug 1, 2019
Discussion open until: Oct 30, 2019
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.