Interface Shear Behavior between MICP-Treated Calcareous Sand and Steel
Publication: Journal of Materials in Civil Engineering
Volume 33, Issue 2
Abstract
Microbial-induced carbonate precipitation (MICP) is an innovative ground improvement technique that utilizes bacteria to induce calcium carbonate precipitation to cement soil particles. In this paper, the interface strength between calcareous sand and steel was improved using the MICP process. The interface shear behavior between MICP-treated calcareous sand and steel was investigated experimentally under different cementation levels and normal stresses. With the increase of content, the peak shear strength increased, accompanied by obvious volume dilation, and the corresponding shear displacement was reduced. The shear band thickness was suppressed greatly from to , and the percentage interface slip increased from 77.8% to 95.7%. With the increase of normal stress, the thickness of shear band increased and then remained stable. Both the peak and mobilized strength at 5 mm increased. MICP products changed the interface morphology and led to shear dilation of the sand sample, especially for high cementation levels. However, if the normal stress is large enough, the raised edges on the interface will be cut off and obvious contraction in the local layer near the interface appears. MICP cementation was found to have a remarkable effect on improving the cohesion of the calcareous sand–steel interface according to the Coulomb criterion.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
All data, models, and code generated or used during the study appear in the published article.
Acknowledgments
The authors acknowledge the support from the National Natural Science Foundation of China (Nos. 51779220 and 51939010), the Natural Science Foundation of Zhejiang Province (No. LHZ19E090003), the Key Research and Development program of Zhejiang Province (No. 2018C03031), and the Joint Fund of the Ministry of Education for Pre-Research of Equipment (No. 6141A02022137).
References
Amini-Kiasari, M., M. S. Pakbaz, and G. R. Ghezelbash. 2019. “Comparison of effects of different nutrients on stimulating indigenous soil bacteria for biocementation.” J. Geotech. Geoenviron. Eng. 31 (6): 04019067. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002693.
ASTM. 2016a. Standard test methods for maximum index density and unit weight of soils using a vibratory table. ASTM D4253-16e1. West Conshohocken, PA: ASTM.
ASTM. 2016b. Standard test methods for minimum index density and unit weight of soils and calculation of relative density. ASTM D4254. West Conshohocken, PA: ASTM.
Bu, C., K. Wen, S. Liu, U. Ogbonnya, and L. Li. 2018. “Development of bio-cemented constructional materials through microbial induced calcite precipitation.” Mater. Struct. 51 (1): 30. https://doi.org/10.1617/s11527-018-1157-4.
Burbank, M. B., T. Weaver, T. Green, B. Williams, and R. Crawford. 2011. “Precipitation of calcite by indigenous microorganisms to strengthen liquefiable soils.” Geomicrobiol. J. 28 (4): 301–312. https://doi.org/10.1080/01490451.2010.499929.
Cheng, L., R. Cord-Ruwisch, and M. A. Shahin. 2013. “Cementation of sand soil by microbially induced calcite precipitation at various degrees of saturation.” Can. Geotech. J. 50 (1): 81–90. https://doi.org/10.1139/cgj-2012-0023.
Cheng, L., and M. A. Shahin. 2019. “Microstructural and geomechanical study on biocemented sand for optimization of MICP process.” J. Mater. Civ. Eng. 31 (4): 04019025. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002660.
Chou, C. W., E. A. Seagren, A. H. Aydilek, and M. Lai. 2011. “Biocalcification of sand through ureolysis.” J. Geotech. Geoenviron. Eng. 137 (12): 1179–1189. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000532.
Chu, J., V. Ivanov, V. Stabnikov, and B. Li. 2013. “Microbial method for construction of aquaculture pond in sand.” Géotechnique 63 (10): 871–875. https://doi.org/10.1680/geot.SIP13.P.007.
Chu, J., V. Stabnikov, and V. Ivanov. 2012. “Microbially induced calcium carbonate precipitation on surface or in the bulk of soil.” Geomicrobiol. J. 29 (6): 544–549. https://doi.org/10.1080/01490451.2011.592929.
Coop, M. R., and J. H. Atkinson. 1993. “The mechanics of cemented carbonate sands.” Géotechnique 43 (1): 53–67. https://doi.org/10.1680/geot.1993.43.1.53.
DeJong, J. T., J. D. Frost, and M. Sacs. 2000. “Relating quantitative measures of surface roughness and hardness to geomaterial interface strength.” In Proc., GeoEng2000 (CD-ROM). Sydney, Australia: International Society for Rock Mechanics.
DeJong, J. T., and Z. J. Westgate. 2009. “Role of initial state, material properties, and confinement condition on local and global soil-structure interface behavior.” J. Geotech. Geoenviron. Eng. 135 (11): 1646–1660. https://doi.org/10.1061/(ASCE)1090-0241(2009)135:11(1646).
DeJong, J. T., D. J. White, and M. F. Randolph. 2006. “Microstructure observation and modelling of soil-structure interface behavior using PIV.” Soils Found. 46 (1): 15–28. https://doi.org/10.3208/sandf.46.15.
Feng, K., and B. M. Montoya. 2015. “Influence of confinement and cementation level on the behavior of microbial induced calcite precipitated sands under monotonic drained loading.” J. Geotech. Geoenviron. Eng. 142 (1): 1943–5606. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001379.
Hu, B. 2008. “Research on the particle breakage mechanical characteristic and constitutive model of calcareous sand under triaxial conditions.” Ph.D. thesis, Geotechnical Engineering, Institute of Rock and Soil Mechanical, Chinese Academy of Sciences.
Ismail, M. A., H. A. Joer, W. H. Sim, and M. F. Randolph. 2002. “Effect of cement type on shear behavior of cemented calcareous soil.” J. Geotech. Geoenviron. Eng. 128 (6): 520–529. https://doi.org/10.1061/(ASCE)1090-0241(2002)128:6(520).
Jafarian, Y., H. Javdanian, and A. Haddad. 2018. “Strain-dependent dynamic properties of Bushehr siliceous-carbonate sand: Experimental and comparative study.” Soil Dyn. Earthquake Eng. 107 (Apr): 339–349. https://doi.org/10.1016/j.soildyn.2018.01.033.
Jiang, N. J., and K. Soga. 2016. “The applicability of microbially induced calcite precipitation (MICP) for internal erosion control in gravel-sand mixtures.” Géotechnique 67 (1): 42–55. https://doi.org/10.1680/jgeot.15.P.182.
Jiang, N. J., C. S. Tang, L. Y. Yin, Y. H. Xie, and N. Shi. 2019. “Applicability of microbial calcification method for sandy-slope surface erosion control.” J. Mater. Civ. Eng. 31 (11): 04019250. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002897.
Li, C., S. Wang, Y. X. Wang, G. Yu, and B. Siriguleng. 2019. “Field experimental study on stability of bio-mineralization crust in the desert.” [In Chinese.] Rock Soil Mech. 40 (4): 1291–1298. https://doi.org/10.16285/j.rsm.2018.0677.
Li, H. Y., C. Li, and T. J. Zhou. 2018. “An improved rotating soak method for MICP-treated fine sand in sample preparation.” Geotech. Test. J. 41 (4): 805–814. https://doi.org/10.1520/GTJ20170109.
Li, Y. J., Z. Guo, L. Z. Wang, Y. Li, and Z. Liu. 2020. “Shear resistance of MICP cementing material at the interface between calcareous sand and steel.” Mater. Lett. 274 (1): 128009. https://doi.org/10.1016/j.matlet.2020.128009.
Lin, H., M. T. Suleiman, H. M. Jabbour, and D. G. Brown. 2018. “Bio-grouting to enhance axial pull-out response of previous concrete ground improvement piles.” Can. Geotech. J. 55 (1): 119–130. https://doi.org/10.1139/cgj-2016-0438.
Lin, H., M. T. Suleiman, H. M. Jabbour, D. G. Brown, and E. Kavazanjian. 2016. “Enhancing the axial compression response of previous concrete ground improvement piles using biogrouting.” J. Geotech. Geoenviron. Eng. 142 (10): 04016045. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001515.
Liu, L., H. L. Liu, A. W. Stuedlein, and T. M. Evans. 2019. “Strength, stiffness, and microstructure characteristics of biocemented calcareous sand.” Can. Geotech. J. 56 (10): 1502–1513. https://doi.org/10.1139/cgj-2018-0007.
Ma, R. N., H. X. Guo, X. H. Cheng, and J. R. Liu. 2018. “Permeability experiment study of calcareous sand treated by microbially induced carbonate precipitation using mixing methods.” [ In Chinese.] Supplement, Rock Soil Mech. 39 (S2): 217–223. https://doi.org/10.16285/j.rsm.2018.0515.
McClelland, B. 1988. “Calcareous sediments: An engineering enigma.” In Proc., Int. Conf. on Calcareous Sediments, 777–784. London: International Society for Soil Mechanics and Foundation Engineering.
Montoya, B. M., and J. T. DeJong. 2015. “Stress-strain behavior of sands cemented by microbially induced calcite precipitation.” J. Geotech. Geoenviron. Eng. 141 (6): 04015019. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001302.
Montoya, B. M., J. T. DeJong, and R. W. Boulanger. 2013. “Dynamic response of liquefiable sand improved by microbial-induced calcite precipitation.” Géotechnique 63 (4): 302–312. https://doi.org/10.1680/geot.SIP13.P.019.
Rodriguez-Navarro, C., C. Jimenez-Lopea, and A. Rodriguez-Navarro. 2007. “Bacterially mediated mineralization of vaterite.” Geochim. Cosmochim. Acta 71 (5): 1197–1213. https://doi.org/10.1016/j.gca.2006.11.031.
Rui, S. J., L. Z. Wang, Z. Guo, X. Cheng, and B. Wu. 2020a. “Monotonic behavior of interface shear between carbonate sand and steel.” Acta Geotech. https://doi.org/10.1007/s11440-020-00987-9.
Rui, S. J., L. Z. Wang, Z. Guo, W. Zhou, and Y. Li. 2020b. “Cyclic behavior of interface shear between carbonate sand and steel.” Acta Geotech. https://doi.org/10.1007/s11440-020-01002-x.
Salehzadeh, H., M. Hassanlourad, and H. Shahnazari. 2012. “Shear behavior of chemically grouted carbonate sands.” Int. J. Geotech. Eng. 6 (4): 445–454. https://doi.org/10.3328/IJGE.2012.06.04.445-454.
Salifu, E., E. Maclachlan, K. R. Iyer, C. W. Kanpp, and A. Tarantino. 2016. “Application of microbially induced calcite precipitation in erosion mitigation and stabilisation of sandy soil foreshore slopes: A preliminary investigation.” Eng. Geol. 201 (Feb): 96–105. https://doi.org/10.1016/j.enggeo.2015.12.027.
Seif El Dine, B., J. C. Dupla, R. Frank, J. Canou, and Y. Kazan. 2010. “Mechanical characterization of matrix coarse-grained soils with a large-sized triaxial device.” Can. Geotech. J. 47 (4): 425–438. https://doi.org/10.1139/T09-113.
Tejchman, J., and W. Wu. 1995. “Experimental and numerical study of sand–steel interfaces.” Int. J. Numer. Anal. Methods Geomech. 19 (8): 513–536. https://doi.org/10.1002/nag.1610190803.
Tovar-Valencia, R. D., A. Galvis-Castro, R. Salgado, and M. Prezzi. 2018. “Effect of surface roughness on the shaft resistance of displacement model piles in sand.” J. Geotech. Geoenviron. Eng. 144 (3): 04017120. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001828.
Uesugi, M., and H. Kishida. 1986. “Influence factors of friction between steel and dry sands.” Soils Found. 26 (2): 33–46. https://doi.org/10.3208/sandf1972.26.2_33.
Uesugi, M., H. Kishida, and Y. Tsubakihara. 1988. “Behavior of sand particles in sand-steel friction.” Soils Found. 28 (1): 107–118. https://doi.org/10.3208/sandf1972.28.107.
van Paassen, L. A. 2011. “Bio-mediated ground improvement: From laboratory experiment to pilot applications.” In Geo-Frontiers: Advances in geotechnical engineering, 4099–4108. Dallas, TX: ASCE.
van Paassen, L. A., C. M. Daza, M. Staal, D. Y. Sorokin, W. Vander Zon, and M. C. M. Van Loosdrecht. 2010. “Potential soil reinforcement by microbial denitrification.” Ecol. Eng. 36 (2): 168–175. https://doi.org/10.1016/j.ecoleng.2009.03.026.
Wang, X. Z., Y. Y. Jiao, R. Wang, M. J. Hu, Q. S. Meng, and F. Y. Tan. 2011. “Engineering characteristics of the calcareous sand in Nansha Islands, South China Sea.” Eng. Geol. 120 (1–4): 40–47. https://doi.org/10.1016/j.enggeo.2011.03.011.
Wang, X. Z., X. Wang, Z. C. Jin, Q. S. Meng, C. Q. Zhu, and R. Wang. 2017. “Shear characteristic of calcareous gravelly soil.” Bull. Eng. Geol. Environ. 76 (2): 561–573. https://doi.org/10.1007/s10064-016-0978-z.
Whiffin, V. S., L. A. van-Paassen, and M. P. Harkes. 2007. “Microbial carbonate precipitation as a soil improvement technique.” Geomicrobiol. J. 24 (5): 417–423. https://doi.org/10.1080/01490450701436505.
Wu, C. Z., J. Chu, S. Wu, L. Cheng, and L. A. van-Paassen. 2019a. “Microbially induced calcite precipitation along a circular flow channel under a constant flow condition.” Acta Geotech. 14 (3): 673–683. https://doi.org/10.1007/s11440-018-0747-1.
Wu, C. Z., J. Chu, S. Wu, and Y. Hong. 2019b. “3D characterization of the microbially induced carbonate precipitation within rock fracture and the resulted permeability reduction.” Eng. Geol. 249 (Jan): 23–30. https://doi.org/10.1016/j.enggeo.2018.12.017.
Xiao, P., H. L. Liu, Y. Xiao, A. W. Stuedlein, and T. M. Evans. 2018. “Liquefaction resistance of bio-cemented calcareous sand.” Soil Dyn. Earthquake Eng. 107 (Apr): 9–19. https://doi.org/10.1016/j.soildyn.2018.01.008.
Yang, Y., J. Chu, Y. Xiao, H. L. Liu, and L. Cheng. 2019. “Seepage control in sand using bioslurry.” Constr. Build. Mater. 212 (Jul): 342–349. https://doi.org/10.1016/j.conbuildmat.2019.03.313.
Zhao, Q., L. Li, C. Li, M. D. Li, F. Amini, and H. Z. Zhang. 2014. “Factors affecting improvement of engineering properties of MICP treated soil catalyzed by bacteria and urease.” J. Mater. Civ. Eng. 26 (12): 04014094. https://doi.org/10.1061/(ASCE)MT.1943-5533.0001013.
Information & Authors
Information
Published In
Copyright
© 2020 American Society of Civil Engineers.
History
Received: Jan 17, 2020
Accepted: Jul 13, 2020
Published online: Nov 27, 2020
Published in print: Feb 1, 2021
Discussion open until: Apr 27, 2021
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.