Solidification and Stabilization of Sewage Sludge and MSWI Bottom Ash for Beneficial Use as Construction Materials
Publication: Journal of Materials in Civil Engineering
Volume 31, Issue 1
Abstract
This paper investigates the feasibility of converting municipal sewage sludge and municipal solid waste incineration (MSWI) bottom ash to a construction material for the dikes of a sludge-only containment. The sewage sludge and MSWI bottom ash were solidified and stabilized by various binders including portland cement, lime, gypsum, and a combination of some of these binders. The solidified/stabilized products, referred to as solidified sludge, would possess higher strength and lower leachability of toxicity, and thus may be beneficially used as the dike construction material. To assess the feasibility of the beneficial use, a series of laboratory tests including strength test, leaching test, wetting-drying test, and biodegradation test was performed to determine the most suitable binder, the optimum mixing ratio, and both short-term and long-term properties of the solidified sludge. It was found that the use of combined cement and gypsum as a binder was most effective in increasing strength of the solidified sludge and decreasing leaching potential. Wetting-drying cycles reduced both short-term and long-term strengths of the solidified sludge. After four cycles (over eight months), the unconfined compression strength (UCS) was decreased by 78% while the cohesion intercept was decreased by 71% and the friction angle by 17%. Biodegradation also reduced the UCS of the solidified sludge, and after the 12-month test, the reduction in UCS was approximately 73%. The findings of the laboratory tests indicated that both short-term and long-term properties of the solidified sludge should be considered in the design and construction of the containment dikes.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study was supported by the National Science Foundation of China (NSFC) (Grants Nos. 51208470, 51578508, and 51768060) and the Cooperation Program of Qinghai Province (Grant No. 2017-HZ-804). The authors would like to thank the financial support from these organizations.
References
ASTM. 2015. Standard test methods for wetting and drying compacted soil-cement mixtures. ASTM D599. West Conshohocken, PA: ASTM.
Aydilek, A. H., and T. B. Edil. 2008. “Solidification/stabilization of PCB-contaminated wastewater treatment sludges.” In Proc., ASCE GeoCongress 2008: Geotechnics of Waste Management and Remediation. Reston, VA: ASCE.
Bell, F. G. 1996. “Lime stabilization of clay minerals and soils.” Eng. Geol. 42 (4): 223–237. https://doi.org/10.1016/0013-7952(96)00028-2.
Campbell, H. W., R. J. Rush, and R. Tew. 1978. Sludge dewatering design manual research report. Burlington, ON, Canada: Ontario Ministry of the Environment.
Chen, G., P. Lock Yue, and A. S. Mujumdar. 2002. “Sludge dewatering and drying.” Drying Technol. 20 (4–5): 883–916. https://doi.org/10.1081/DRT-120003768.
Chimenos, J. M., A. I. Fernández, L. Miralles, J. R. Rosell, and A. N. Ezquerra. 2005. “Change of mechanical properties during short-term natural weathering of MSWI bottom ash.” Environ. Sci. Technol. 39 (19): 7725–7730. https://doi.org/10.1021/es050420u.
Feng, L., J. Luo, and Y. Chen. 2015. “Dilemma of sewage sludge treatment and disposal in China.” Environ. Sci. Technol. 49 (8): 4781–4782. https://doi.org/10.1021/acs.est.5b01455.
Hanehara, S., F. Tomosawa, M. Kobayakawa, and K. R. Hwang. 2001. “Effects of water/powder ratio, mixing ratio of fly ash, and curing temperature on pozzolanic reaction of fly ash in cement paste.” Cem. Concr. Res. 31 (1): 31–39. https://doi.org/10.1016/S0008-8846(00)00441-5.
Hou, Y. X., and P. Y. Hong. 2017. “China sludge treatment industry research report.” Shenzhen, Guangdong, China: CI Consulting.
Izquierdo, M., Á. López-Soler, E. V. Ramonich, M. Barra, and X. Querol. 2002. “Characterisation of bottom ash from municipal solid waste incineration in Catalonia.” J. Chem. Technol. Biotechnol. 77 (5): 576–583. https://doi.org/10.1002/jctb.605.
Li, L., W. Zhu, S. J. Ji, and X. J. Zheng. 2008. “Influence of micro-organism on long-term strength of solidified/stabilized sludge.” [In Chinese.] Chin. J. Geotech. Eng. 30 (12): 1778–1782.
Lim, S., W. Jeon, J. Lee, K. Lee, and N. Kim. 2002. “Engineering properties of water/wastewater-treatment sludge modified by hydrated lime, fly ash and loess.” Water Res. 36 (17): 4177–4184. https://doi.org/10.1016/S0043-1354(02)00150-1.
Lin, C., W. Zhu, and J. Han. 2013. “Strength and leachability of solidified sewage sludge with different additives.” J. Mater. Civ. Eng. 25 (11): 1594–1601. https://doi.org/10.1061/(ASCE)MT.1943-5533.0000738.
Liu, Y., Y. Li, X. Li, and Y. Jiang. 2008. “Leaching behavior of heavy metals and PAHs from MSWI bottom ash in a long-term static immersing experiment.” Waste Manage. (Oxford) 28 (7): 1126–1136. https://doi.org/10.1016/j.wasman.2007.05.014.
Luz, C. A., J. C. Rocha, M. Cheriaf, and J. Pera. 2006. “Use of sulfoaluminate cement and bottom ash in the solidification/stabilization of galvanic sludge.” J. Hazard. Mater. 136 (3): 837–845. https://doi.org/10.1016/j.jhazmat.2006.01.020.
MCC (Ministry of Construction of China). 2009. The disposal of sludge from municipal wastewater treatment plant-sludge quality for co-landfilling. [In Chinese.] GB/T23485. Beijing: Standards Press of China.
MEPC (Ministry of Environmental Protection of China). 2002a. Emission standard for municipal waste water treatment plant. [In Chinese.] GB 18918. Beijing: Ministry of Environmental Protection of China.
MEPC (Ministry of Environmental Protection of China). 2002b. Environmental quality standards for surface water. GB 3838. Beijing: Ministry of Environmental Protection of China.
MEPC (Ministry of Environmental Protection of China). 2007. Identification standards for hazardous wastes identification for extraction toxicity. [In Chinese.] GB 5085.3. Beijing: Ministry of Environmental Protection of China.
MEPC (Ministry of Environmental Protection of China). 2010. Solid waste-extraction procedure for leaching toxicity—Horizontal vibration method. [In Chinese.] HJ 557. Beijing: Ministry of Environmental Protection of China.
MWRC (Ministry of Water Resources of China). 1999. Standard for soil test method. [In Chinese.] GB/T50123. Beijing: China Planning Press.
NRC (National Research Council). 1996. Use of reclaimed water and sludge in food crop production. Washington, DC: National Academies Press.
O’Kelly, B. C. 2005. “Sewage sludge to landfill: Some pertinent engineering properties.” J. Air Waste Manage. Assoc. 55 (6): 765–771. https://doi.org/10.1080/10473289.2005.10464670.
O’Kelly, B. C. 2006. “Geotechnical properties of municipal sewage sludge.” Geotech. Geol. Eng. 24 (4): 833–850. https://doi.org/10.1007/s10706-005-6611-8.
Pecqueur, G., C. Crignon, and B. Quénée. 2001. “Behaviour of cement-treated MSWI bottom ash.” Waste Manage. (Oxford) 21 (3): 229–233. https://doi.org/10.1016/S0956-053X(00)00094-5.
Tay, J. H., and A. T. C. Goh. 1991. “Engineering properties of incinerator residue.” J. Environ. Eng. 117 (2): 224–235. https://doi.org/10.1061/(ASCE)0733-9372(1991)117:2(224).
Wang, J. H., and Y. Q. Gao. 2006. “Study on the strength degradation mechanism of cement-soils resulting from dry-wet cycles.” [In Chinese.] China Railway Sci. 27 (5): 23–27.
Yu, J., and K. Wang. 2010. “Investigation and analysis on the treatment and disposal of sewage sludge in China.” J. Residuals Sci. Technol. 7 (1): 21–27.
Zhan, X. J. 2015. “Study on the consolidation mechanism of sewage sludge under combined effect of chemical conditioning and vacuum preloading and its application.” Ph.D. dissertation, Dept. of Civil Engineering, Zhejiang Univ.
Zhang, H., Y. Zhao, R. Huang, H. Zhou, F. Qin, and D. Liu. 2009. “Biodegradation and stabilization of landfilled biological and chemical sludge.” Huanjing Kexue Xuebao/Acta Scientiae Circumstantiae 29 (10): 2103–2109.
Zhen, G. Y., et al. 2013. “Characterization of controlled low-strength material obtained from dewatered sludge and refuse incineration bottom ash: Mechanical and microstructural perspectives.” J. Environ. Manage. 129: 183–189. https://doi.org/10.1016/j.jenvman.2013.07.008.
Information & Authors
Information
Published In
Copyright
©2018 American Society of Civil Engineers.
History
Received: Jan 2, 2018
Accepted: Jul 17, 2018
Published online: Oct 31, 2018
Published in print: Jan 1, 2019
Discussion open until: Mar 31, 2019
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.