Differential Stone Decay of the Spanish Tower Façade in Bizerte, Tunisia
Publication: Journal of Materials in Civil Engineering
Volume 29, Issue 6
Abstract
The Spanish Fortress of Bizerte in Tunisia shows differential erosion patterns on the rock ashlars used in the construction of its main façade (sixteenth century) exposed to marine aerosol action and several restoration works. In order to determine the origin of this erosion and the degree of stone decay, a combination of microdestructive and nondestructive techniques have been used on-site and in the laboratory. Moisture measurements, ultrasonic velocity propagation, and water absorption by a Karsten pipe test, together with polarized light and fluorescence optical microscopy, mercury intrusion porosimetry, and ion chromatography analyses, were carried out to perform petrophysical characterization of stone samples and determination of soluble salts. Results show that the differential stone weathering is caused by small variations in the petrographic characteristics of the construction’s geomaterials, such as the type and degree of cementation, porous network configuration, and presence or absence of soluble salts. These variations are also detected by the portable nondestructive techniques, showing their analytical sensitivity to small petrophysical changes even in the same type of rock and their performance in predicting future degradations not currently visible on the surface of the rocks.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This work was carried out from a collaboration between Universidad Complutense de Madrid (UCM) and the Faculty of Sciences of Bizerte, Tunisia, under the AECID AP/042080/11 project. Laboratory analyses were carried out at Instituto de Geociencias (CSIC, UCM) and were supported by Rafael Fort and the GEOMATERIALES (S2009/MAT-1629) Program. The work was also supported by a JAE-PreDoc 2010-2014 fellowship program of the Spanish National Research Council (CSIC) and the Adaptability and Employment Program of the European Social Fund (ESF 2007-2013). Special thanks go to the technicians Andres Lira and Blanca Gallardo from IGEO (CSIC, UCM) for performing MIP and ion chromatography analyses, and María Ascensión Barajas for the thin sections preparation at the Faculty of Geology (UCM).
References
Alvarez de Buergo, M. (1994). “Estudio del método delamedidadela velocidad de propagación delsonidoysu aplicación aedificios históricos [Study method of measuring the sound propagation speed and its application to historical buildings].” Ing. Civ., 94, 69–74.
Aly, N., Gomez-Herasb, M., Hamed, A., Álvarez de Buergo, M., and Solimane, F. (2015). “The influence of temperature in a capillary imbibition salt weathering simulation test on Mokattam limestone.” Mater. Constr., 65(317), 1–11.
Andreini, M., De Falco, A., Giresini, L., and Sassu, M. (2014). “Mechanical characterization of masonry walls with chaotic texture: Procedures and results of in-situ tests.” Int. J. Archit. Herit., 8(3), 376–407.
Angeli, M., Bigas, J. P., Benavente, D., Menendez, B., Hebert, R., and David, C. (2007). “Salt crystallization in pores: Quantification and estimation of damage.” Environ. Geol., 52, 205–213.
Bouita, H. (1992). Bizerte: Les monuments islamiques [Bizerte: Islamic monuments], Beït Al-Hikma, Carthage, Tunisie (in French).
Bromblet, P., Vergès-Belmin, V., and Simon, S. (2012). “Ultrasonic velocity measurements for the long-term monitoring of the degradation of marble columns in the cloister of the church of Saint-Trophine in Arles (France).” Proc., 12th Int. Congress on the Deterioration and Conservation of Stone, Historic Education Preservation Foundation, Washington, DC.
Burkinshaw, R. (2002). “What is the moisture meter trying to tell us?” Struct. Survey, 20(5), 162–172.
Calleja, L., Montoto, B., Pérez, B., Suárez del Río, L., Martínez, A., and Menéndez, B. (1989). “An ultrasonic method to analyse the progress of weathering during cyclic salt crystallization laboratory tests.” Proc., 1st Int. Symp. on the Conservation of Monuments in the Mediterranean Basin: The Influence of Coastal Environment and Salt Spray on Limestone and Marble, Grafo Edizioni, Brescia, Italy, 313–318.
Cardell, C., Benavente, D., and Rodríguez-Gordillo, J. (2008). “Weathering of limestone building material by mixed sulphate solutions: Characterization of stone microstructure, reaction products and decay forms.” Mater. Charact., 59(10), 1371–1385.
Croci, G., and Delgado Rodrigues, J. (2002). “Surface and structural stability for the conservation of historic buildings.” Science and technology of the environment for sustainable protection of cultural heritage: EC advanced study course, Univ. College London, London.
Duarte, E. R., Flores-Colen, I., and De Brito, J. (2011). “In-situ testing techniques for in-service evaluation of water penetration in rendered façades—The portable moisture meter and Karsten tube.” Proc., 12th DBMC Int. Conf. on Durability of Building Materials and Components, Univ. of Porto, Portugal, 1307–1314.
Esbert, R., Ordaz, J., Alonso, F. J., Montoto, M., González-Limón, T., and Álvarez de Buergo, M. (1997). “Manual de diagnosis y tratamiento de materiales pétreos y cerámicos: Colegio de Aparejadores y Arquitectos Técnicos de Barcelona.” Colección Manuales de Diagnosis, 5, 139.
Flores-Colen, I., De Brito, J., and Freitas, V. (2011). “On-site performance assessment of rendering façades for predictive maintenance.” Struct. Survey, 29(2), 133–146.
Fort, R., et al. (2013). “Evolution in the use of natural building stone in Madrid.” Q. J. Eng. Geol., 46(4), 421–429.
Fort, R., Fernández-Revuelta, B., Varas, M. J., Alvarez de Buergo, M., and Taborda, M. (2008). “Influence of the anisotropy in the durability of Cretaceous dolostones of the region of Madrid against salt crystallization.” Mater. Constr., 58, 74–95.
Gomez-Heras, M., and Fort, R. (2007). “Patterns of halite (NaCl) crystallisation in building stone conditioned by laboratory heating regimes.” Environ. Geol., 52(2), 239–247.
Goudie, A. S., (1999). “Experimental salt weathering of limestones in relation to rock properties.” Earth. Surf. Process., 24, 715–724.
Gupta, A. S., and Rao, K. S. (1998). “Index properties of weathered rocks: Interrelationships and applicability.” B. Eng. Geol. Environ., 57, 161–172.
Herinck, S., De Bouw, M., Pien, A., and Vanhellemont, Y. (2012). “Innovative test procedure on injection products against rising damp for historic masonry constructions.” Proc., Workshop and Training Day, Oslo, 24–26.
Iñigo, A. C., Alonso, R., and Vicente-Tavera, S. (2001). “Dissolution of salts crystallized in building materials using ultrasound: An alternative to NORMAL (1983) standard methodology.” Ultrason. Sonochem., 8, 127–130.
Kahraman, S. (2007). “The correlations between the saturated and dry P-wave velocity of rocks.” Ultrasonics, 46(4), 341–348.
Kramar, S., Mladenović, A., Kozamernik, M., and Mirtič, B. (2010). “Durability evaluation of some Slovenian building limestones.” Mater. Geoenviron., 57(3), 331–346.
López-Arce, P., Doehne, E., Greenshields, J., Benavente, D., and Young, D. (2009a) “Treatment of rising damp and salt decay: The historic masonry buildings of Adelaide, South Australia.” Mater. Struct., 42(6), 827–848.
López-Arce, P., Garcia-Guinea, J., Benavente, D., Tormo, L., and Doehne, E. (2009b). “Deterioration of dolostone by magnesium sulphate salt: An example of incompatible building materials at Bonaval Monastery, Spain.” Constr. Build. Mater., 23, 846–855.
López-Arce, P., Gomez-Villalba, L. S., Pinho, L., Fernández-Valle, M. E., Álvarez de Buergo, M., and Fort, R. (2010). “Influence of porosity and relative humidity on consolidation of dolostone with calcium hydroxide nanoparticles: Effectiveness assessment with non-destructive techniques.” Mater. Charact., 61(2), 168–184.
López-Arce, P., Zornoza-Indart, A., Vázquez-Calvo, C., Gomez-Heras, M., Alvarez de Buergo, M., and Fort, R. (2011). “Evaluation of Portable Raman for the characterization of salt effluorescences at Petra, Jordan.” Spectrosc. Lett., 44(7–8), 505–510.
Martinez-Martinez, J., Benavente, D., and García del Cura, M. A. (2011). “Spatial attenuation: The most sensitive ultrasonic parameter for detecting petrographic features and decay processes in carbonate rocks.” Environ. Geol., 119, 84–95.
Massari, G., and Massari, I. (1993). “Damp buildings: Old and new Roma.” Int. Centre for the Study of the Preservation and the Restoration of Cultural Property (ICCROM), ICCROM, Rome.
Menezes, A. (2012). In-situ analysis of the physical performance of rendering facades, Instituto Superior Técnico, Lisbon (in Portuguese).
Menezes, A., Glória Gomes, M., and Flores-Colen, I. (2015). “In-situ assessment of physical performance and degradation analysis of rendering walls.” Constr. Build. Mater., 75, 283–292.
Min, K., Park, J., and Han, D. (2005). “Durability of building stones against artificial salt crystallization.” The American Geophysical Union, Fall Meeting, San Francisco.
Moropoulou, A., Labropoulos, K. C., Delegou, E. T., Karoglou, M., and Bakolas, A. (2013). “Non-destructive techniques as a tool for the protection of built cultural heritage.” Constr. Build. Mater., 48, 1222–1239.
Mustoe, G. E. (1982). “The origin of honeycomb weathering.” Geol. Soc. Am. Bull., 93, 108–115.
Nwaubani, S. O., and Dumbelton, J. (2001). “A practical approach to in-situ evaluation of surface-treated structures.” Constr. Build. Mater., 15, 199–212.
Papida, S., Murphy, W., and May, E. (2000). “The use of sound velocity determination for the non-destructive estimation of physical and microbial weathering of lime- stones and dolomites.” Proc., 9th Int. Congress on Deterioration and Conservation of Stone, Elsevier, Amsterdam, Netherlands, 609–17.
Paskoff, R., and Sanlaville, P. (1983). “Les côtes de la Tunisie: Variation du niveau marin depuis le Tyrrhénien.” Maison de l’Orient, Lyon.
Philippon, J., Jeannette, D., and Lefevre, R. A. (1992). La conservation de la pierre monumentale en France. Presse du CNRS, Paris.
Pittarello, L., Bellezza, G., Almesberger, D., and Geometrante, R. (2000). “Anamnesis and diagnosis of column sand capitals of “Nostra Signora delle Grazie” Sanctuary in Imperia (Italy) and quality control of their consolidation by ultrasonic instruments.” Proc., 15th World Conf. on Nondestructive Testing, Italian Society for Nondestructive Testing and Monitoring Diagnostics-AIPnD, Brescia, Italy, 15–21.
Price, C. A. (1996). “Stone conservation. An overview of current research. Research in conservation.” Getty Conservation Institute, Los Angeles.
RILEM. (1980). “Essais recommandés pour mesurer l’altération des pierres et évaluer l’efficacité des méthodes de traitement [Recommended tests to measure the rock weathering and evaluate the effectiveness of treatment methods].”, Berlin, Germany (in French).
Ruedrich, J., and Siegesmund, S. (2007). “Salt and ice crystallisation in porous sandstones.” Environ. Geol., 52, 225–249.
Russell, S. A. (1927). Stone preservation committee report (Appendix I), HM Stationary Office, London.
Simon, S. and Lind, A. M. (1999). “Decay of limestone blocks in the block fields of Karnak Temple (Egypt): Nondestructive damage analysis and control of consolidation treatments.” ICOM Committee for Conservation, Triennial Meeting (12th), Vol. 2, ICOM, Paris, 743–749.
Surfer 8 [Computer software]. Golden Software, Golden, CO.
Tavares, M., Magalhães, A. C., Veiga, M., and Aguiar, J. (2005). “Diagnosis methods for coatings of ancient buildings: Importance and applicability of in situ tests.” Boletín del Instituto Andaluz del Patrimonio Histórico, 53, 11–17 (in Spanish).
Török, A. (2003). “Surface strength and mineralogy of weathering crusts on limestone buildings in Budapest.” Build. Environ., 38, 1185–1192.
Vallet, J. M., and Vallet-Coulomb, C. (1999). “Characterization of residual efficiency of ancient water repellent products applied on calcareous stones by using water absorption measurements under low pressure (pipe method).” Proc., 6th Int. Conf. on Non-Destructive Testing and Microanalysis for the Diagnostics and Conservation of the Cultural and Environmental Heritage, Istituto Centrale del Restauro, I.C.R, Roma, 417–430.
Vandevoorde, D., et al. (2013). “Validation of in situ applicable measuring techniques for analysis of the water adsorption by stone.” Procedia Chem., 8, 317–327.
Van Hees, R., Van Der Klugt, L., De Witte, E., De Clerq, L., Binda, H., and Baronio, G. (1995). “Test methods for the evaluation of the in situ performance of water-repellent treatments.” Proc., 1st Int. Symp. on Surface Treatment of Building Materials with Water Repellent Agents, Publikatieburo Bouwkunde TU Delft Library, Delft, Netherlands.
Vasconcelos, G., Lourenc, P. B., Alves, C. A. S., and Pamplona, J. B. (2008). “Ultrasonic evaluation of the physical and mechanical properties of granites.” Ultrasonic, 48(5), 453–466.
Weiss, T., Siegesmund, S., and Rasolofosaon, P. N. J. (2000). “The relationship between deterioration, fabric, velocity and porosity constraint.” Proc., 9th Int. Congress on Deterioration and Conservation of Stone, Elsevier Science, Amsterdam, Netherlands, 215–223.
Winkler, E. M. (1994). Stone in architecture, properties, durability, Springer, Berlin.
Zoghlami, K., and Gómez Gras, D. (2009). “Provenance des roches utilisées dans la construction du Fort d’Espagne de la ville de Bizerte (Tunisie) [Provenance of rocks used in the construction of the Spanish Fort in the city of Bizerte (Tunisia)].” Proc., Int. Meeting on Architectural Heritage of the Mediterranean, Lisbon, 48–49 (in French).
Information & Authors
Information
Published In
Journal of Materials in Civil Engineering
Volume 29 • Issue 6 • June 2017
Copyright
©2016 American Society of Civil Engineers.
History
Received: Feb 8, 2016
Accepted: Aug 4, 2016
Published online: Dec 5, 2016
Discussion open until: May 5, 2017
Published in print: Jun 1, 2017
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.