Strength of High Water-Content Marine Clay Stabilized by Low Amount of Cement
Publication: Journal of Geotechnical and Geoenvironmental Engineering
Volume 139, Issue 12
Abstract
An ideal solution for disposal of large volumes of unwanted dredged clays is to stabilize and use them as fill materials for land reclamations. This kind of stabilized dredged fill (SDF) requires a lower cement amount () compared with traditional cement-treated soils. Strength behavior might be different for mixes within the inactive zone (lower ) and those within the active zone (higher ). The SDF is fully/partially within the inactive zone. A new set of unconfined compressive strength () data as well as data compiled from literature covering both lower and higher are analyzed. First, main parameters governing of cement-stabilized clays are identified: (1) cement amount (), and (2) water content (). Then, behaviors in the inactive zone and active zone are compared. Results indicate that a nonlinear normalized trend is commonly observed in the inactive zone whereas a linear one is observed in the active zone. In both zones, the normalized curve (or normalized curve) is unique for a given soil type, regardless of (or ). The key conclusion is that and should be considered as separate variables in the estimation of , rather than in a combined form such as water:cement ratio (). The practical outcome is the development of an empirical formula as a function of and for estimation of of cement-stabilized clays. Validation results show the proposed formula is applicable to both inactive zone and active zone.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study has been supported by Singapore’s Ministry of National D&R Fund on “Enhancing the use of unwanted soils for land reclamation purpose—Solving an environmental problem and developing a viable alternate fill.” The authors acknowledge the invaluable cooperation and assistance offered by Housing and Development Board and Surbana International Consultants Pte Ltd.
References
Baghdadi, Z. A. (1982). “Accelerated strength testing of soil-cement.” Ph.D. thesis, Univ. of Arizona, Tucson, AZ.
Bergado, D. T., Anderson, L. R., Miura, N., and Balasubramaniam, A. S. (1996). Soft ground improvement in lowland and other environments, ASCE, Reston, VA.
Boutouil, M., and Levacher, D. (2005). “Effect of high initial water content on cement-based sludge solidification.” Ground Improv., 9(4), 169–174.
Chew, S. H., Kamruzzaman, A. H. M., and Lee, F. H. (2004). “Physicochemical and engineering behaviour of cement treated clays.” J. Geotech. Geoenviron. Eng., 130(7), 696–706.
Chiu, C. I., Zhu, W., and Zhang, C. L. (2008). “Yielding and shear behaviour of cement-treated dredged materials.” Eng. Geol., 103(1), 1–12.
Consoli, N. C., Cruz, R. C., and Floss, M. F. (2010). “Parameters controlling tensile and compressive strength of artificially cemented sand.” J. Geotech. Geoenviron. Eng., 136(5), 759–763.
Consoli, N. C., Foppa, D., Festugato, L., and Heineck, K. (2007). “Key parameters for strength control of artificially cemented soils.” J. Geotech. Geoenviron. Eng., 133(2), 197–205.
Consoli, N. C., Rosa, A. D., Corte, M. B., Lopes, L., and Consoli, B. S. (2011a). “Porosity-cement ratio controlling strength of artificially cemented clays.” J. Mater. Civ. Eng., 23(8), 1249–1254.
Consoli, N. C., Rosa, D. A., Cruz, R. C., and Rosa, A. D. (2011b). “Water content, porosity and cement content as parameters controlling strength of artificially cemented silty soil.” Eng. Geol., 122(3–4), 328–333.
Consoli, N. C., Viana da Fonseca, A., Cruz, R. C., and Heineck, K. S. (2009). “Fundamental parameters for the stiffness and strength control of artificially cemented sand.” J. Geotech. Geoenviron. Eng., 135(9), 1347–1353.
Gallavresi, F. (1992). “Grouting improvement of foundation soils.” Proc., Grouting, Soil Improvement and Geosynthetics, ASCE, Reston, VA, 1–38.
Hassan, M. M., and Ravaska, O. (2008). “Strength and permeability characteristics of cement stabilized soft Finnish clay.” Proc., 2nd Int. Workshop on Geotechnics of Soft Soils: Focus on Ground Improvement, Taylor & Francis, New York, 227–233.
Herzog, A., and Mitchell, J. K. (1963). “Reactions accompanying stabilization of clay with cement.” Highway Research Record 36, Highway Research Board, Washington, DC, 146–171.
Horpibulsuk, S., and Miura, N. (2001). “A new approach for studying behaviour of cement stabilized clays.” Proc., 15th Int. Conf. on Soil Mechanics and Geotechnical Engineering, Taylor & Francis, New York, 1759–1762.
Horpibulsuk, S., Miura, N., and Bergado, D. T. (2004). “Undrained shear behavior of cement admixed clay at high water content.” J. Geotech. Geoenviron. Eng., 130(10), 1096–1105.
Horpibulsuk, S., Miura, N., and Nagaraj, T. S. (2003). “Assessment of strength development in cement-admixed high water content clays with Abrams’ law as a basis.” Geotechnique, 53(4), 439–444.
Horpibulsuk, S., Miura, N., and Nagaraj, T. S. (2005). “Clay-water/cement ratio identity for cement admixed soft clays.” J. Geotech. Geoenviron. Eng., 131(2), 187–192.
Horpibulsuk, S., Rachan, R., and Suddeepong, A. (2011a). “Assessment of strength development in blended cement admixed Bangkok clay.” Constr. Build. Mater., 25(4), 1521–1531.
Horpibulsuk, S., Rachan, R., Suddeepong, A., and Chinkulkijniwat, A. (2011b). “Strength development in cement admixed Bangkok clay: Laboratory and field investigations.” Soils Found., 51(2), 239–251.
Japanese Geotechnical Society (JGS). (2000). “Practice for making and curing stabilized soil specimens without compaction.” JGS T 0821-2000, Tokyo(in Japanese).
Japanese Geotechnical Society (JGS). (2009). “Method for unconfined compression test of soils.” JIS A 1216:2009, Japanese Standards Association, Tokyo (in Japanese).
Jongpradist, P., Jumlongrach, N., Youwai, S., and Chucheepsakul, S. (2010). “Influence of fly ash on unconfined compressive strength of cement-admixed clay at high water content.” J. Mater. Civ. Eng., 22(1), 49–58.
Kamruzzaman, A. H. M., Chew, S. H., and Lee, F. H. (2009). “Structuration and destructuration behaviour of cement-treated Singapore marine clay.” J. Geotech. Geoenviron. Eng., 135(4), 573–589.
Kitazume, M., and Hayano, K. (2007). “Strength properties and variance of cement-treated ground using the pneumatic flow mixing method.” Ground Improv., 11(1), 21–26.
Kitazume, M., and Satoh, T. (2003). “Development of a pneumatic flow mixing method and its application to Central Japan International Airport construction.” Ground Improv., 7(3), 139–148.
Lee, F. H., Lee, Y., Chew, S. H., and Yong, K. Y. (2005). “Strength and modulus of marine clay-cement mixes.” J. Geotech. Geoenviron. Eng., 131(2), 178–186.
Locat, J., Tanaka, H., Tan, T. S., Dasari, G. R., and Lee, H. (2002). “Natural soils: Geotechnical behaviour and geological knowledge.” Proc., Int. Workshop on Characterisation and Engineering Properties of Natural Soils, Swets & Zeitlinger, Singapore, 3–28.
Low, H. E. (2004). “Compressibility and undrained behaviour of natural Singapore marine clay: Effect of soil structure.” M.Eng. thesis, National Univ. of Singapore, Singapore.
Low, H. E., Phoon, K. K., Tan, T. S., and Leroueil, S. (2008). “Effect of soil microstructure on the compressibility of natural Singapore marine clay.” Can. Geotech. J., 45(2), 161–176.
Lu, Y. T., Tan, T. S., and Phoon, K. K. (2011). “Use of elevated curing temperature for accelerated testing of cement stabilized dredged Singapore marine clay.” Proc., 2011 Pan-Am CGS Geotechnical Conf., Canadian Geotechnical Society, Richmond, BC, Canada, 1–8.
Mitchell, J. K., and El-Jack, S. (1965). “The fabric of soil-cement and its formation.” Proc., 14th National Conf. on Clays and Clay Minerals, Pergamon, Oxford, U.K., 297–305.
Miura, N., Horpibulsuk, S., and Nagaraj, T. S. (2001). “Engineering behaviour of cement stabilized clay at high water content.” Soils Found., 41(5), 33–45.
Nagaraj, T. S., and Miura, N. (1996). “Induced cementation of soft ground: A parametric assessment.” Proc., Int. Symp. on Lowland Technology, Saga Univ., Saga, Japan, 85–97.
Nagaraj, T. S., Miura, N., Prakash, Y., and Yamadera, A. (1995). “Analysis of compressibility and permeability behaviour of soils with induced cementation.” Proc., Indian Geotechnical Conf. (IGC-95), Indian Geotechnical Society, New Delhi, India, 53–56.
Narendra, B. S., Sivapullaiah, P. V., Suresh, S., and Omkar, S. N. (2006). “Prediction of unconfined compressive strength of soft grounds using computational intelligence techniques: A comparative study.” Comput. Geotech., 33(3), 196–208.
Rahman, M. M., Taiyab, M. A., Siddique, A., and Uddin, M. K. (2008). “A short-cut method for predicting strength of cement treated soft Bangladesh clays and the alteration of other engineering parameters.” Geotech. Eng., 39(3), 159–167.
Rios, S., Viana da Fonseca, A., and Baudet, B. A. (2012). “Effect of the porosity/cement ratio on the compression of cemented soil.” J. Geotech. Geoenviron. Eng., 138(11), 1422–1426.
Tan, T. S., Goh, T. L., and Yong, K. Y. (2002). “Properties of Singapore marine clays improved by cement mixing.” Geotech. Test. J., 25(4), 422–433.
Tan, T. S., Lu, Y. T., Phoon, K. K., and Karthikeyan, M. (2011). “Innovative approaches to land reclamation in Singapore.” Proc., Advances in Ground Technology and Geo-Information, Research Publishing, Singapore, 85–102.
Tang, Y. X., Miyazaki, Y., and Tsuchida, T. (2001). “Practice of reused dredgings by cement treatment.” Soils Found., 41(5), 129–143.
Terashi, M., and Tanaka, H. (1981). “Ground improved by deep mixing method.” Proc., 10th Int. Conf. on Soil Mechanics and Foundation Engineering, A.A. Balkem, Rotterdam, Netherlands, 777–780.
Uddin, K. (1994). “Strength and deformation behaviour of cement treated Bangkok clay.” Ph.D. thesis, Asian Institute of Technology, Bangkok, Thailand.
Uddin, K., Balasubramaniam, A. S., and Bergado, D. T. (1997). “Engineering behaviour of cement- treated Bangkok soft clay.” Geotech. Eng., 28(1), 89–119.
Yamadera, A. (1999). “Microstructural study of geotechnical characteristics of marine clays.” Ph.D. thesis, Saga Univ., Saga, Japan.
Yin, J. H., and Lai, C. K. (1998). “Strength and stiffness of Hong Kong marine deposits mixed with cement.” Geotech. Eng., 29(1), 29–44.
Zen, K., Yamazaki, H., Yoshizawa, H., and Mori, K. (1992). “Development of premixing method against liquefaction.” Proc., 9th Asian Conf. on Soil Mechanics and Foundation Engineering, Kluwer Academic Publishers, Dordrecht, Netherlands, 461–464.
Zhu, W., Zhang, C. L., and Chiu, A. C. F. (2007). “Soil-water transfer mechanism for solidified dredged materials.” J. Geotech. Geoenviron. Eng., 133(5), 588–598.
Information & Authors
Information
Published In
Copyright
© 2013 American Society of Civil Engineers.
History
Received: Aug 21, 2012
Accepted: Apr 22, 2013
Published online: Apr 23, 2013
Published in print: Dec 1, 2013
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.