Performance Enhancement of Solar Water Heater with a Thermal Water Pump
Publication: Journal of Energy Engineering
Volume 141, Issue 4
Abstract
In order to reduce weight on a building roof and save electrical energy for water circulation, a solar water heater with a built-in thermal water pump was introduced. However, such a system still does not have high enough effectiveness. The target of this study was to improve the efficiency of the solar water heater by eliminating critical losses such as vapor and head losses. Consequently, a new system of flat plate solar collectors, an overhead tank placed at the peak level, a larger water storage tank without a heat exchanger at the lower level, a new vent tube and a one-way valve for water circulation control were constructed. The discharge head was reduced to be 0.5 m. A pump was powered by steam and air and operated at a solar collector temperature of about 70–80.2°C and gauge pressure of 2.2–6.3 kPa. The stored hot water of the solar water heater ranged between 25 and . Furthermore, the max water temperature in the storage tank was roughly 64.6°C. The max daily pump efficiency was about 0.0012%. For the 0.5 m h discharge head, the solar water heater had daily max thermal efficiency of about 41.2% compared to 17.4% for a previous system of the same type. The system simulation gave a reasonable agreement with the experimental results (error of less than ). Long-term performance and economic analysis were included.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors gratefully acknowledge the financial support provided by the National Research Council of Thailand and the Energy Technology Division, School of Energy Environment and Materials, King Mongkut’s University of Technology Thonburi. This work also was supported by the Higher Education Research Promotion and National Research University Project of Thailand, Office of the Higher Education Commission.
References
Al-Haddad, A. A., Enaya, E., and Fahim, M. A. (1996). “Performance of a thermodynamic water pump.” Appl. Therm. Eng., 16(4), 321–334.
Badescu, V. (1989). “The theoretical maximum efficiency of solar converters with and without concentration.” Int. J. Energy, 14(4), 237–239.
Cengel, Y. A., and Boles, M. A. (1994). Thermodynamics: An engineering approach, 2nd Ed., McGraw-Hill, New York.
Center Analysis of Ozone and Radiation. (2013). Meteorological observations bureau, Thai Meteorological Dept., 〈http://ozone.tmd.go.th/Solar_chart/Daily/BK_G-d-B_monthly.png〉.
Dobriansky, Y. (2011). “Concepts of self-acting circulation loops for downward heat transfer (reverse thermosiphons).” Energy Convers. Manage., 52(1), 414–425.
Filippeschi, S. (2006). “On periodic two-phase thermosyphons operating against gravity.” Int. J. Therm. Sci., 45(2), 124–137.
Incropera, F. P., and De Witt, D. P. (1990). Fundamentals of heat and mass transfer, 3rd Ed., Wiley, New York.
Khalifa, A. N. (1998). “Forced versus natural circulation solar water heaters: A comparative performance study.” Renewable Energy, 14(1–4), 77–82.
Li, M., Wang, R. Z., Luo, H. L., Wang, L. L., and Huang, H. B. (2002). “Experiments of a solar flat plate hybrid system with heating and cooling.” Appl. Therm. Eng., 22(13), 1445–1454.
Liengjindathaworn, S., Kirtikara, K., Namprakai, P., and Kiatsiriroat, T. (2002). “Parametric studies of a pulsating-steam water pump.” Int. J. Ambient Energy, 23(1), 37–46.
Perry, R. H., Green, D. W., and Maloney, J. O. (1997). Perry’s chemical engineers’ handbook, 7th Ed., McGraw-Hill, New York.
Picken, D. J., Seare, K. D. R., and Goto, F. (1997). “Design and development of a water piston solar powered steam pump.” Sol. Energy, 61(3), 219–224.
Roonprasang, N., Namprakai, P., and Pratinthong, N. (2008). “Experimental studies of a new solar water heater system using a solar water pump.” Int. J. Energy, 33(4), 639–646.
Roonprasang, N., Namprakai, P., and Pratinthong, N. (2009). “A novel thermal water pump for circulating water in a solar water heating system.” Appl. Therm. Eng., 29(8–9), 1598–1605.
Sumathy, K. (1999). “Experimental studies on a solar thermal water pump.” Appl. Therm. Eng., 19(5), 449–459.
Sutthivirode, K., Namprakai, P., and Roonprasang, N. (2009). “A new version of a solar water heating system coupled with a solar water pump.” Appl. Energy, 86(9), 1423–1430.
Wong, Y. W., and Sumathy, K. (1999). “Solar thermal water pumping systems: A review.” Renewable Sustainable Energy Rev., 3(2–3), 185–217.
Wong, Y. W., and Sumathy, K. (2000). “Performance of a solar water pump with n-pentane and ethyl-ether as working fluids.” Energy Convers. Manage., 41(9), 915–927.
Wong, Y. W., and Sumathy, K. (2001). “Thermodynamic analysis and optimization of solar thermal water pump.” Appl. Therm. Eng., 21(5), 613–627.
Information & Authors
Information
Published In
Journal of Energy Engineering
Volume 141 • Issue 4 • December 2015
Copyright
© 2014 American Society of Civil Engineers.
History
Received: Dec 14, 2013
Accepted: Jun 12, 2014
Published online: Aug 5, 2014
Discussion open until: Jan 5, 2015
Published in print: Dec 1, 2015
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.