Microstructural Modeling of Early-Age Creep in Hydrating Cement Paste
This article has been corrected.
VIEW CORRECTIONPublication: Journal of Engineering Mechanics
Volume 142, Issue 11
Abstract
This paper presents a new approach to model the creep behavior of cement paste at early ages. The creep behavior is simulated by applying a time-varying generalized Maxwell model on the individual elements of a finite-element mesh of a simulated three-dimensional microstructure and compared with results in the literature. All mechanical properties of the constituent phases are taken from literature and Maxwell chain parameters are obtained by fitting the intrinsic creep of calcium silicate hydrate (C-S-H). A reasonable agreement between the simulations and the experimental results are obtained by assuming a constant C-S-H density of . It was found that better agreements could be obtained at low degree of hydrations, by assuming a loosely packed C-S-H growing in the microstructure. It was also found that the short-term creep characteristics of C-S-H from nanoindentation can be used to reproduce macroscopic creep at least over a few days. The results show how numerical models can be used to upscale phase characteristics to macroscopic properties of composites.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The authors gratefully acknowledge the financial support from the Swiss National Science Foundation. The authors thank Dr. A. Guidoum and Dr. M. Vandamme for fruitful discussions. The authors would also like to thank the reviewers of this article for comments that helped in significantly improving the manuscript.
References
Acker, P. (2001). “Micromechanical analysis of creep and shrinkage mechanisms.” Proc., 6th Int. Conf., CONCREEP 6 of Creep, Shrinkage and Durability Mechanics of Concrete and Other Quasi-Brittle Materials, F. J. Ulm, Z. P. Bazant, and F. H. Wittmann, eds., Elsevier, Oxford, U.K., 15–25.
Argyris, J. H., and Kelsey, S. (1954). Energy theorems and structural analysis, Butterworths, London.
Bažant, Z. P. (1972). “Numerical determination of long-range stress history from strain history in concrete.” Mater. Struct., 5(3), 135–141.
Bažant, Z. P., and Baweja, S. (2000). “Creep and shrinkage prediction model for analysis and design of concrete structures: Model B3.” Creep and shrinkage-structural design effects, ACI SP-194, A. Al-Manaseer, ed., American Concrete Institute, Farmington Hills, MI, 1–83.
Bell, F. (1994). “A survey of the engineering properties of some anhydrite and gypsum from the north and midlands of England.” Eng. Geol., 38(1-2), 1–23.
Bernard, O., Ulm, F.-J., and Germaine, J. T. (2003). “Volume and deviator creep of calcium-leached cement-based materials.” Cem. Concr. Res., 33(8), 1127–1136.
Bishnoi, S., and Scrivener, K. L. (2009). “Studying nucleation and growth kinetics of alite hydration using μic.” Cem. Concr. Res., 39(10), 849–860.
Constantinides, G., and Ulm, F. J. (2004). “The effect of two types of C-S-H on the elasticity of cement based materials: results from nanoindentation and micromechanical modelling.” Cem. Concr. Res., 34(1), 67–80.
Constantinides, G., and Ulm, F. J. (2007). “The nanogranular nature of C-S-H.” J. Mech. Phys. Solids., 55(1), 64–90.
Do, Q. H., Bishnoi, S., and Scrivener, K. L. (2013). “Numerical simulation of porosity in cements.” Transp. Porous Med., 99(1), 101–117.
Do, Q. H., Bishnoi, S., and Scrivener, K. L. (2015). “Microstructural modelling of the elastic properties of C3S at early ages.” Comput. Concr., 16(1), 125–140.
Grasley, Z. C., and Lange, D. A. (2007). “Constitutive modeling of the aging viscoelastic properties of portland cement paste.” Mech. Time-Depend. Mater., 11(3), 175–198.
Guidoum, A. (1994). “Simulation numérique 3D des comportenments des bétons en tant que composites granulaires [3D numerical simulation of the behavior of concrete as granular composites].” Ph.D. thesis, Ecole Polytechnique Federale de Lausanne, Lausanne, Switzerland (in French).
Huet, C. (1993). “Some basis tools and pending problems in the development of constitutive equations for the delayed behaviour of concrete.” Creep and Shrinkage of concrete, Z. P. Bažant and I. Carol, ed., Spon, London, 189–200.
Kamali, S., Moranville, M., Garboczi, E., Prene, S., and Gerard, B. (2004). “Hydrate dissolution influence on the Young’s modulus of cement pastes.” Proc., Int. Symp., Fracture Mechanics of Concrete Structures (FraMCoS-V), V. C. Li, et al., eds., Vail, 631–638.
Muller, A. C. A., Scrivener, K. L., Gajewicz, A. M., and McDonald, P. J. (2013a). “Densification of C-S-H Measured by 1H NMR relaxometry.” J. Phys. Chem. C, 117(1), 403–412.
Muller, A. C. A., Scrivener, K. L., Gajewicz, A. M., and McDonald, P. J. (2013b). “Use of bench-top NMR to measure the density, composition and desorption isotherm of C-S-H in cement paste.” Microporous Mesoporous Mater., 178(1), 99–103.
Pichler, C., and Lackner, R. (2008). “A multiscale creep model as basic for simulation of early-age concrete behavior.” Comput. Concr., 5(4), 295–328.
Sanahuja, J., and Toulemonde, C. (2011). “Numerical homogenization of concrete microstructures without explicit meshes.” Cem. Concr. Res., 41(12), 1320–1329.
Scheiner, S., and Hellmich, C. (2009). “Continuum microviscoelasticity model for aging basic creep of early-age concrete.” J. Eng. Mech., 307–323.
Sedef, M., Samur, E., and Basdogan, C. (2006). “Real-time finite element simulation of linear Viscoelastic tissue behavior based on experimental.” IEEE Comput. Graphics Appl., 26(6), 58–68.
Šmilauer, V., and Bažant, Z. P. (2010). “Identification of viscoelastic C-S-H behavior in mature cement paste by FFT-based homogenization method.” Cem. Concr. Res., 40(2), 197–207.
Tamtsia, B. T., Beaudoin, J. J., and Marchand, J. (2004). “The early age short-term creep of hardening cement paste load-induced hydration effects.” Cem. Concr. Res., 26(5), 481–489.
Taylor, H. F. W. (1997). Cement chemistry, Thomas Telford, London.
Thomas, J. J., Allen, A. J., and Jennings, H. M. (2009). “Hydration kinetics and microstructure development of normal and CaCl2-Accelerated tricalcium silicate pastes.” J. Phys. Chem. C, 113(46), 19836–19844.
Thomas, J. J., and Jennings, H. M. (2006). “A colloidal interpretation of chemical aging of the C-S-H gel and its effects on the properties of cement paste.” Cem. Concr. Res., 36(1), 30–38.
Turner, M. J., Clough, R. W., Martin, H. C., and Topp, L. J. (1956). “Stiffness and deflection analysis of complex structure.” J. Aeronaut. Sci., 23(9), 805–823.
Ulm, F. J., Le Maou, F., and Boulay, C. (1999). “Creep and shrinkage coupling: New review of some evidence.” Revue Française De Génie Civil, 3(3-4), 21–38.
Vandamme, M. (2008). “The nanogranular origin of concrete creep: A nanoindentation investigation of microstructure and fundamental properties of calcium-silicate-hydrates.” Ph.D. thesis, Civil and Environmental Engineering Dept., Massachusetts Institute of Technology, Cambridge, MA.
Vandamme, M., and Ulm, F. J. (2009). “Nanogranular origin of concrete creep.” Proc. Natl. Acad. Sci., 106(26), 10552–10557.
Velez, K., Maximilien, S., Damido, D., Fantozzi, G., and Sorrentino, F. (2001). “Determination by nanoindentation of elastic modulus and hardness of pure constituents of Portland cement clinker.” Cem. Concr. Res., 31(4), 555–561.
Wendner, R., Hubler, M. H., and Bažant, Z. P. (2015). “Statistical justification of model B4 for multi-decade concrete creep using laboratory and bridge databases and comparisons to other models.” Mater. Struct., 48(4), 815–833.
Zienkiewicz, O. C., and Taylor, R. L. (2000). The finite element method, Solid mechanics, 5th Ed., Vol. 2, Butterworth-Heinemann, Oxford, U.K.
Zienkiewicz, O. C., Watson, M., and King, I. P. (1968). “A numerical method of visco-elastic stress analysis.” Int. J. Mech. Sci., 10(10), 807–827.
Information & Authors
Information
Published In
Copyright
© 2016 American Society of Civil Engineers.
History
Received: Apr 14, 2015
Accepted: May 25, 2016
Published online: Jul 25, 2016
Published in print: Nov 1, 2016
Discussion open until: Dec 25, 2016
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.