Analysis and Optimization of Simultaneous Nitrification, Denitrification, and Phosphorus Removal in Sequencing Batch Reactors for Sewage Treatment at High-Altitude Areas
Publication: Journal of Environmental Engineering
Volume 148, Issue 11
Abstract
The biological treatment process in high-altitude areas faces the problems of low biological activities, high aeration energy consumption, and low treatment efficiency due to the low atmosphere pressure and consequently low oxygen content. As a new type of simultaneous nitrogen and phosphorus removal process, simultaneous nitrification, denitrification, and phosphorus removal (SNDPR) has the advantages of high efficiency, low operation cost, and low aeration energy. Compared with the traditional sewage biological treatment process, SNDPR needs less dissolved oxygen (DO) and can save carbon source, so it may be suitable for solving the problems in high-altitude areas caused by low pressure and low oxygen. In this study, SNDPR system reactors were operated under different atmosphere pressures, one at 100 kPa and three at 72 kPa, with different anaerobic/aeration time. The chemical oxygen demand (COD) and total phosphate (TP) removal performance remained the same efficiency, while the nitrogen-removal rate increased slightly at 72 kPa. The low atmosphere pressure enhanced the phosphorus-accumulating organisms but inhibited ammonia-oxidizing bacteria based on the cycle study results. Studies on the activities of enzymes related to nitrogen removal showed that the processes of and were enhanced, while the processes of and were restrained as the atmosphere pressure declined. Under the condition of 72 kPa, the SNDPR systems were optimized by prolonging the anaerobic time and reducing the aeration time. The residual ammonium concentration increased predictably () as the aeration time decreased, while the nitrogen-removal efficiency improved. The aeration energy consumption at 72 kPa by a shorter aeration time was 89% of that at 100 kPa. The further study on the microbial community analysis showed that the abundance of Dechloromonas [identified as denitrifying phosphorus-accumulating organisms (DPAOs)] increased from 0.126% at 100 kPa to 5.499% at 72 kPa, which explained the nitrogen removal and phosphate uptake under the low atmosphere pressure.
Get full access to this article
View all available purchase options and get full access to this article.
Data Availability Statement
The data presented in this study are available on request from the corresponding author.
Acknowledgments
This work was financially supported by the Key Research and Development Program of Xizang (XZ202001ZY0052G) and the National Natural Science Foundation of China (52160004).
References
Antonyuk, S. V., R. W. Strange, G. Sawers, R. R. Eady, and S. S. Hasnain. 2005. “Atomic resolution structures of resting-state, substrate- and product-complexed Cu-nitrite reductase provide insight into catalytic mechanism.” Proc. Natl. Acad. Sci. 102 (34): 12041–12046. https://doi.org/10.1073/pnas.0504207102.
APHA (American Public Health Association). 2005. Standard methods for the examination of water and wastewater. Washington, DC: APHA.
Beun, J. J., J. J. Heijnen, and M. C. M. Van Loosdrecht. 2001. “N-removal in a granular sludge sequencing batch airlift reactor.” Biotechnol. Bioeng. 75 (1): 82–92. https://doi.org/10.1002/bit.1167.
Cai, J., P. Liang, Y. Qiu, J. Cao, and X. Huang. 2020. “A mass balance framework to evaluate the new pathways of biological nutrient removal in wastewater treatment.” J. Water Process Eng. 37 (Oct): 101523. https://doi.org/10.1016/j.jwpe.2020.101523.
Cedervall, P., A. B. Hooper, and C. M. Wilmot. 2013. “Structural studies of hydroxylamine oxidoreductase reveal a unique heme cofactor and a previously unidentified interaction partner.” Biochemistry 52 (36): 6211–6218. https://doi.org/10.1021/bi400960w.
Chen, H., A. Li, D. Cui, C. Cui, and F. Ma. 2019. “Evolution of microbial community and key genera in the formation and stability of aerobic granular sludge under a high organic loading rate.” Bioresour. Technol. Rep. 7 (Sep): 100280. https://doi.org/10.1016/j.biteb.2019.100280.
Chen, H., X. Zhao, Y. Cheng, M. Jiang, X. Li, and G. Xue. 2018. “Iron robustly stimulates simultaneous nitrification and denitrification under aerobic conditions.” Environ. Sci. Technol. 52 (3): 1404–1412. https://doi.org/10.1021/acs.est.7b04751.
Chen, Y., S. Li, Y. Lu, G. Zhu, and H. Cheng. 2020. “Simultaneous nitrification, denitrification and phosphorus removal (SNDPR) at low atmosphere pressure.” Biochem. Eng. J. 160 (Aug): 107629. https://doi.org/10.1016/j.bej.2020.107629.
Chuang, S. H., and C. F. Ouyang. 2000. “The biomass fractions of heterotrophs and phosphate-accumulating organisms in a nitrogen and phosphorus removal system.” Water Res. 34 (8): 2283–2290. https://doi.org/10.1016/S0043-1354(99)00380-2.
Coats, E. R., D. L. Watkins, C. K. Brinkman, and F. J. Loge. 2011. “Effect of anaerobic HRT on biological phosphorus removal and the enrichment of phosphorus accumulating organisms.” Water Environ. Res. 83 (5): 461–469. https://doi.org/10.2175/106143010X12851009156402.
Dai, X., Y. Peng, X. Wang, and S. Wang. 2016. “Effect of different anaerobic time on the nutrient removal in simultaneous nitrification-denitrification and phosphorus removal (SNDPR) systems enriched with phosphorus accumulating organisms.” [In Chinese.] China Environ. Sci. 36 (1): 92–99.
Fang, D., G. Zhao, X. Xu, Q. Zhang, Q. Shen, Z. Fang, L. Huang, and F. Ji. 2018. “Microbial community structures and functions of wastewater treatment systems in plateau and cold regions.” Bioresour. Technol. 249 (Feb): 684–693. https://doi.org/10.1016/j.biortech.2017.10.063.
Guerrero, J., A. Guisasola, and J. A. Baeza. 2011. “The nature of the carbon source rules the competition between PAO and denitrifiers in systems for simultaneous biological nitrogen and phosphorus removal.” Water Res. 45 (16): 4793–4802. https://doi.org/10.1016/j.watres.2011.06.019.
Guo, X., J. H. Kim, S. K. Behera, and H. S. Park. 2008. “Influence of dissolved oxygen concentration and aeration time on nitrite accumulation in partial nitrification process.” Int. J. Environ. Sci. Technol. 5 (4): 527–534. https://doi.org/10.1007/BF03326050.
He, Q., L. Chen, S. Zhang, L. Wang, J. Liang, W. Xia, H. Wang, and J. Zhou. 2018. “Simultaneous nitrification, denitrification and phosphorus removal in aerobic granular sequencing batch reactors with high aeration intensity: Impact of aeration time.” Bioresour. Technol. 263 (Sep): 214–222. https://doi.org/10.1016/j.biortech.2018.05.007.
He, Q., W. Zhang, S. Zhang, and H. Wang. 2017. “Enhanced nitrogen removal in an aerobic granular sequencing batch reactor performing simultaneous nitrification, endogenous denitrification and phosphorus removal with low superficial gas velocity.” Chem. Eng. J. 326 (Oct): 1223–1231. https://doi.org/10.1016/j.cej.2017.06.071.
Hossain, M. I., L. Cheng, and R. Cord-Ruwisch. 2019. “Energy efficient COD and N-removal from high-strength wastewater by a passively aerated GAO dominated biofilm.” Bioresour. Technol. 283 (Jul): 148–158. https://doi.org/10.1016/j.biortech.2019.03.056.
Juliette, L. Y., M. R. Hyman, and D. J. Arp. 1993. “Inhibition of ammonia oxidation in Nitrosomonas europaea by sulfur compounds: Thioethers are oxidized to sulfoxides by ammonia monooxygenase.” Appl. Environ. Microbiol. 59 (11): 3718–3727. https://doi.org/10.1128/aem.59.11.3718-3727.1993.
Kristjansson, J. K., and T. C. Hollocher. 1980. “First practical assay for soluble nitrous oxide reductase of denitrifying bacteria and a partial kinetic characterization.” J. Biol. Chem. 255 (2): 704–707. https://doi.org/10.1016/S0021-9258(19)86236-1.
Kuba, T., E. Murnleitner, M. C. M. Van Loosdrecht, and J. J. Heijnen. 1996. “A metabolic model for biological phosphorus removal by denitrifying organisms.” Biotechnol. Bioeng. 52 (6): 685–695. https://doi.org/10.1002/(SICI)1097-0290(19961220)52:6%3C685::AID-BIT6%3E3.0.CO;2-K.
Kuba, T., G. Smolders, M. C. M. Van Loosdrecht, and J. J. Heijnen. 1993. “Biological phosphorus removal from wastewater by anaerobic-anoxic sequencing batch reactor.” Water Sci. Technol. 27 (5–6): 241–252. https://doi.org/10.2166/wst.1993.0504.
Lee, J.-K., K.-H. Lee, and S.-B. Yim. 2007. “Optimization of nitrogen removal in a sequencing batch reactor system by variation of the time distribution.” J. Environ. Sci. Health, Part A 42 (11): 1655–1663. https://doi.org/10.1080/10934520701518182.
Li, C., S. Liu, T. Ma, M. Zheng, and J. Ni. 2019. “Simultaneous nitrification, denitrification and phosphorus removal in a sequencing batch reactor (SBR) under low temperature.” Chemosphere 229 (Aug): 132–141. https://doi.org/10.1016/j.chemosphere.2019.04.185.
Li, D., Z. Wei, S. Li, H. Lao, W. Wang, H. Zeng, and J. Zhang. 2021. “Performance and operational strategy of simultaneous nitrification, denitrification, and phosphorus removal system under the condition of low organic loading rate in wet weather.” Chemosphere 270 (May): 129464. https://doi.org/10.1016/j.chemosphere.2020.129464.
Liu, J., Y. Yuan, B. Li, Q. Zhang, L. Wu, X. Li, and Y. Peng. 2017. “Enhanced nitrogen and phosphorus removal from municipal wastewater in an anaerobic-aerobic-anoxic sequencing batch reactor with sludge fermentation products as carbon source.” Bioresour. Technol. 244 (Nov): 1158–1165. https://doi.org/10.1016/j.biortech.2017.08.055.
Liu, Y. 2015. “Calculation on air supply quantity of surface aerator for sewage treatment plant of high-altitude city.” [In Chinese.] Non-Ferrous Met. Eng. Res. 36 (4): 62–64.
Lo, I. W., K. V. Lo, D. S. Mavinic, D. Shiskowski, and W. Ramey. 2010. “Contributions of biofilm and suspended sludge to nitrogen transformation and nitrous oxide emission in hybrid sequencing batch system.” J. Environ. Sci. 22 (7): 953–960. https://doi.org/10.1016/S1001-0742(09)60204-7.
McGrath, J. W., and J. P. Quinn. 2000. “Intracellular accumulation of polyphosphate by the yeast Candida humicola G-1 in response to acid pH.” Appl. Environ. Microbiol. 66 (9): 4068–4073. https://doi.org/10.1128/AEM.66.9.4068-4073.2000.
Niu, L., Y. Li, P. Wang, W. Zhang, C. Wang, W. Cai, and L. Wang. 2016. “Altitude-scale variation in nitrogen-removal bacterial communities from municipal wastewater treatment plants distributed along a 3600-m altitudinal gradient in China.” Sci. Total Environ. 559 (Jul): 38–44. https://doi.org/10.1016/j.scitotenv.2016.03.175.
Osaka, T., S. Yoshie, S. Tsuneda, A. Hirata, N. Iwami, and Y. Inamori. 2006. “Identification of acetate-or methanol-assimilating bacteria under nitrate-reducing conditions by stable-isotope probing.” Microb. Ecol. 52 (2): 253–266. https://doi.org/10.1007/s00248-006-9071-7.
Otte, S., J. Schalk, J. G. Kuenen, and M. S. Jetten. 1999. “Hydroxylamine oxidation and subsequent nitrous oxide production by the heterotrophic ammonia oxidizer Alcaligenes faecalis.” Appl. Microbiol. Biotechnol. 51 (2): 255–261. https://doi.org/10.1007/s002530051390.
Smolders, G. J. F., J. Van der Meij, M. C. M. Van Loosdrecht, and J. J. Heijnen. 1994. “Model of the anaerobic metabolism of the biological phosphorus removal process: Stoichiometry and pH influence.” Biotechnol. Bioeng. 43 (6): 461–470. https://doi.org/10.1002/bit.260430605.
Szabo, E., R. Liebana, M. Hermansson, O. Modin, F. Persson, and B. M. Wilen. 2017. “Microbial population dynamics and ecosystem functions of anoxic/aerobic granular sludge in sequencing batch reactors operated at different organic loading rates.” Front. Microbiol. 8 (May): 770. https://doi.org/10.3389/fmicb.2017.00770.
Toyofuku, M., N. Nomura, E. Kuno, Y. Tashiro, T. Nakajima, and H. Uchiyama. 2008. “Influence of the Pseudomonas quinolone signal on denitrification in Pseudomonas aeruginosa.” J. Bacteriol. 190 (24): 7947–7956. https://doi.org/10.1128/JB.00968-08.
Wang, X., S. Wang, T. Xue, B. Li, X. Dai, and Y. Peng. 2015. “Treating low carbon/nitrogen (C/N) wastewater in simultaneous nitrification-endogenous denitrification and phosphorous removal (SNDPR) systems by strengthening anaerobic intracellular carbon storage.” Water Res. 77 (Jun): 191–200. https://doi.org/10.1016/j.watres.2015.03.019.
Wang, X., S. Wang, J. Zhao, X. Dai, B. Li, and Y. Peng. 2016. “A novel stoichiometries methodology to quantify functional microorganisms in simultaneous (partial) nitrification-endogenous denitrification and phosphorus removal (SNEDPR).” Water Res. 95 (May): 319–329. https://doi.org/10.1016/j.watres.2015.12.046.
Wang, X., J. Zhao, D. Yu, G. Chen, S. Du, J. Zhen, and M. Yuan. 2019. “Stable nitrite accumulation and phosphorous removal from nitrate and municipal wastewaters in a combined process of endogenous partial denitrification and denitrifying phosphorus removal (EPDPR).” Chem. Eng. J. 355 (Jan): 560–571. https://doi.org/10.1016/j.cej.2018.08.165.
Wang, Y., G. Guo, H. Wang, T. Stephenson, J. Guo, and L. Ye. 2013. “Long-term impact of anaerobic reaction time on the performance and granular characteristics of granular denitrifying biological phosphorus removal systems.” Water Res. 47 (14): 5326–5337. https://doi.org/10.1016/j.watres.2013.06.013.
Xiang, Y., Z. Shao, H. Chai, F. Ji, and Q. He. 2020. “Functional microorganisms and enzymes related nitrogen cycle in the biofilm performing simultaneous nitrification and denitrification.” Bioresour. Technol. 314 (Oct): 123697. https://doi.org/10.1016/j.biortech.2020.123697.
Zeng, R. J., R. Lemaire, Z. Yuan, and J. Keller. 2003. “Simultaneous nitrification, denitrification, and phosphorus removal in a lab-scale sequencing batch reactor.” Biotechnol. Bioeng. 84 (2): 170–178. https://doi.org/10.1002/bit.10744.
Zhang, M., Q. Yang, J. Zhang, C. Wang, S. Wang, and Y. Peng. 2016. “Enhancement of denitrifying phosphorus removal and microbial community of long-term operation in an anaerobic anoxic oxic–biological contact oxidation system.” J. Biosci. Bioeng. 122 (4): 456–466. https://doi.org/10.1016/j.jbiosc.2016.03.019.
Zhang, T., B. Wang, X. Li, Q. Zhang, L. Wu, Y. He, and Y. Peng. 2018. “Achieving partial nitrification in a continuous post-denitrification reactor treating low C/N sewage.” Chem. Eng. J. 335 (Mar): 330–337. https://doi.org/10.1016/j.cej.2017.09.188.
Zhao, J., X. Wang, X. Li, S. Jia, Q. Wang, and Y. Peng. 2019. “Improvement of partial nitrification endogenous denitrification and phosphorus removal system: Balancing competition between phosphorus and glycogen accumulating organisms to enhance nitrogen removal without initiating phosphorus removal deterioration.” Bioresour. Technol. 281 (Jun): 382–391. https://doi.org/10.1016/j.biortech.2019.02.109.
Zhu, Z., Y. Yang, A. Fang, Y. Lou, G. Xie, N. Ren, and D. Xing. 2020. “Quorum sensing systems regulate heterotrophic nitrification-aerobic denitrification by changing the activity of nitrogen-cycling enzymes.” Environ. Sci. Technol. 2 (Apr): 100026. https://doi.org/10.1016/j.ese.2020.100026.
Information & Authors
Information
Published In
Copyright
© 2022 American Society of Civil Engineers.
History
Received: Mar 28, 2022
Accepted: May 26, 2022
Published online: Aug 27, 2022
Published in print: Nov 1, 2022
Discussion open until: Jan 27, 2023
ASCE Technical Topics:
- Aeration
- Biological processes
- Chemical compounds
- Chemical elements
- Chemical processes
- Chemicals
- Chemistry
- Denitrification
- Energy consumption
- Energy engineering
- Entrainment
- Environmental engineering
- Hydraulic engineering
- Municipal wastes
- Nitrogen
- Nutrient pollution
- Phosphorus
- Pollutants
- Pollution
- Sewage
- Waste management
- Wastes
- Water and water resources
- Water pollution
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.