Methane Production of Algal Biomass from Facultative Stabilization Pond: Evaluation of Anaerobic Biodegradability and Codigestion with Sewage Sludge
Publication: Journal of Environmental Engineering
Volume 144, Issue 5
Abstract
Anaerobic biodegradability tests of algae biomass produced on a facultative sewage stabilization pond were conducted at 303 K for up to 24 days. The addition of urea and enabled the algae biomass to adjust its chemical oxygen ratio to . Comparison with the raw substrate showed that it contained sufficient amounts of N and P for bacteria metabolism. The addition of anaerobic sludge as inoculum did not affect the overall degradation efficiency but increased the initial biogas production rate, from 9.2 (without inoculum) up to with 10% volume/volume (v/v) inoculum. The codigestion of algae biomass and anaerobic sludge was evaluated in the range of 5–50% (v/v) of algae biomass, and specific methane production of substrate combination achieved values up to volatile solids, which is 10 times higher than the degradation of just raw sludge. Destruction of volatile solids also increased with the addition of algae biomass, varying from 20% degradation (with raw sludge) up to 42% when 50% (v/v) of algae biomass was added.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This work was supported by project funds from the Brazilian National Council for Research and Development (CNPq) and the Carlos Chagas Filho Foundation for Research Support in the State of Rio de Janeiro (FAPERJ).
References
Abdel-Raouf, N., Al-Homaidan, A. A., and Ibraheem, I. B. M. (2012). “Microalgae and wastewater treatment.” Saudi J. Biol. Sci., 19(3), 257–275.
Barthel, L., Oliveira, P. A., and Costa, R. H. R. (2008). “Plankton biomass in secondary ponds treating piggery waste.” Braz. Arch. Biol. Technol., 51(6), 1287–1298.
Beltrán, C., Jeison, D., Fermoso, F. G., and Borja, R. (2016). “Batch anaerobic co-digestion of waste activated sludge and microalgae (Chlorella sorokiniana) at mesophilic temperature.” J. Environ. Sci. Health, Part A Toxic/Hazard. Subst. Environ. Eng., 51(10), 847–850.
Brune, D. E., Lundquist, T. J., and Benemann, J. R. (2009). “Microalgal biomass for greenhouse gas reductions: Potential for replacement of fossil fuels and animal feeds.” J. Environ. Eng., 1136–1144.
Chernicharo, C. A. L. (2007). “Anaerobic reactors: Biological wastewater treatment.” Biological wastewater treatment series, Vol. 4, IWA Publishing, London.
Debowski, M., Zieliński, M., Grala, A., and Dudek, M. (2013). “Algae biomass as an alternative substrate in biogas production technologies—Review.” Renewable Sustainable Energy Rev., 27, 596–604.
Furtado, A. L. F. F., Calijuri, M. C., Lorenzi, A. S., Honda, R. Y., Genuário, D. B., and Fiore, M. F. (2009). “Morphological and molecular characterization of cyanobacteria from a Brazilian facultative wastewater stabilization pond and evaluation of microcystin production.” Hydrobiologia, 627(1), 195–209.
Garoma, T., and Nguyen, D. (2016). “Anaerobic co-digestion of microalgae Scenedesmus sp. and TWAS for biomethane production.” Water Environ. Res., 88(1), 13–20.
Golueke, C. G., Oswald, W. J., and Gotaas, H. B. (1957). “Anaerobic digestion of algae.” Appl. Microbiol., 5(1), 47–55.
Greenberg, A. E., Clesceri, L. S., and Eaton, A. D. (2005). Standard methods for the examination of water and wastewater, Water Environment Federation, Washington DC.
Jankowska, E., Sahu, A. K., and Oleskowicz-Popiel, P. (2017). “Biogas from microalgae: Review on microalgae’s cultivation, harvesting and pretreatment for anaerobic digestion.” Renewable Sustainable. Energy Rev., 75, 692–709.
Jensen, V. K., Cammarota, M. C., and Volschan, I., Jr. (2014). “Methane production from residual algal biomass in facultative stabilization pond.” Proc., 4th Int. Conf. on Algal Biomass, Biofuels & Bioproducts, Elsevier B.V., Amsterdam, Netherlands.
Kwietniewskan, E., and Tys, J. (2014). “Process characteristics, inhibition factors and methane yields of anaerobic digestion process, with particular focus on microalgal biomass fermentation.” Renewable Sustainable Energy Rev., 34, 491–500.
Lu, D., and Zhang, X. J. (2016). “Biogas production from anaerobic codigestion of microalgae and septic sludge.” J. Environ. Eng., 04016049.
Mata, T. M., Martins, A. A., and Caetano, N. S. (2010). “Microalgae for biodiesel production and other applications: a review.” Renewable Sustainable Energy Rev., 14(1), 217–232.
Mata-Alvarez, J., Dosta, J., Romero-Güiza, M. S., Fonoll, X., Peces, M., and Astals, S. (2014). “A critical review on anaerobic co-digestion achievements between 2010 and 2013.” Renewable Sustainable Energy Rev., 36, 412–427.
Nartker, S., Ammerman, M., Aurandt, J., Stogsdil, M., Hayden, O., and Antle, C. (2014). “Increasing biogas production from sewage sludge anaerobic co-digestion process by adding crude glycerol from biodiesel industry.” Waste Manage., 34(12), 2567–2571.
Olsson, J., et al. (2014). “Co-digestion of cultivated microalgae and sewage sludge from municipal waste water treatment.” Bioresour. Technol., 171, 203–210.
PAST version 3.16 [Computer software]. 3Dconnexion, Waltham, MA.
Regueiro, L., Carballa, M., Álvarez, J. A., and Lema, J. M. (2012). “Enhanced methane production from pig manure anaerobic digestion using fish and biodiesel wastes as co-substrates.” Bioresour. Technol., 123, 507–513.
Salerno, M., Nurdogan, Y., and Lundquist, T. J. (2009). “Biogas production from algae biomass harvested at wastewater treatment ponds.” Proc., 2009 Bioenergy Eng. Conf., American Society of Agricultural and Biological Engineers, Seattle, 11–14.
Samson, R., and LeDuy, A. (1983). “Improved performance of anaerobic digestion of Spirulina maxima algal biomass by addition of carbon-rich wastes.” Biotechnol. Lett., 5(10), 677–682.
Santos-Ballardo, D. U., Font-Segura, X., Ferrer, A. S., Barrena, R., Rossi, S., and Valdez-Ortiz, A. (2015). “Valorisation of biodiesel production wastes: Anaerobic digestion of residual Tetraselmis suecica biomass and co-digestion with glycerol.” Waste Manage. Res., 33(3), 250–257.
Sialve, B., Bernet, N., and Bernard, O. (2009). “Anaerobic digestion of microalgae as a necessary step to make microalgal biodiesel sustainable.” Biotechnol. Adv., 27(4), 409–416.
Wang, M., and Park, S. (2015). “Investigation of anaerobic digestion of Chlorella sp. and Micractinium sp. grown in high-nitrogen wastewater and their co-digestion with waste activated sludge.” Biomass Bioenergy, 80, 30–37.
Wang, M., Sahu, A. K., Rusten, B., and Park, C. (2013). “Anaerobic co-digestion of microalgae Chlorella sp. and waste activated sludge.” Bioresour. Technol., 142, 585–590.
Ward, A. J., Lewis, D., and Green, F. (2014). “Anaerobic digestion of algae biomass: A review.” Algal Res., 5, 204–214.
Yuan, X., Wang, M., Park, C., Sahu, A. K., and Ergas, S. J. (2012). “Microalgae growth using high strength wastewater followed by anaerobic co-digestion.” Water Environ. Res., 84(5), 396–404.
Zeng, X., Danquahb, M. K., Chena, X. D., and Lu, Y. (2011). “Microalgae bioengineering: From fixation to biofuel production.” Renewable Sustainable Energy Rev., 15(6), 3252–3260.
Zhao, B., et al. (2014). “Efficient anaerobic digestion of whole microalgae and lipid-extracted microalgae residues for methane energy production.” Bioresour. Technol., 161, 423–430.
Information & Authors
Information
Published In
Copyright
©2018 American Society of Civil Engineers.
History
Received: Jan 28, 2017
Accepted: Oct 17, 2017
Published online: Feb 21, 2018
Published in print: May 1, 2018
Discussion open until: Jul 21, 2018
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.