Leaching of Heavy Metals from Personal Computer Components: Comparison of TCLP with a European Leaching Test
Publication: Journal of Environmental Engineering
Volume 139, Issue 11
Abstract
The objective of this work was to quantify the leaching of nine heavy metals from four desktop personal computer components (PCCs), namely, integrated drive electronics (IDE) cables, video cards, random-access memory (RAM), and CPUs, using two different leaching tests. One test was the toxicity characteristic leaching procedure (TCLP), which is widely used in the United States. The TCLP was augmented using a five-step sequential leaching procedure to further investigate the influence of increasing liquid-to-solid () ratios on the amount of metals leached. The other leaching test was based on European standards following the requirements of a European decision regarding acceptance of waste at landfills. The European leaching test was performed at the natural pH of the materials. Results showed that the masses of some metals leached during the TCLP were up to two orders of magnitude greater than the corresponding masses measured by the European leaching test. Lead and zinc were the dominant metals leached from all four PCCs. Video cards, RAM, and CPUs were classified as hazardous wastes according to the U.S. EPA’s TCLP limit for lead. Based on the limits of the European decision, IDE cables, video cards, and RAM chips were classified as nonhazardous and should be disposed of to nonhazardous waste landfills. CPUs should be disposed of to hazardous waste landfills. The amount of metals leached increased with an increasing liquid-to-solid ratio.
Get full access to this article
View all available purchase options and get full access to this article.
References
Dimitrakakis, E., Gidarakos, E., and Loizidou-Malami, M. (2006). “WEEE management: The situation in Greece.” Proc., VIII Int. Conf. on the Protection and Restoration of the Environment, Technical Univ. of Crete, Chanea, Crete.
European Committee for Standardization (CEN). (2002a). “Characterization of waste—Leaching—Compliance test for leaching of granular waste materials and sludges. Part 1: One stage batch test at a liquid to solid ratio of for materials with high solid content and with particle size below 4 mm (without or with size reduction).”, Brussels, Belgium.
European Committee for Standardization (CEN). (2002b). “Characterisation of waste—Leaching—Compliance test for leaching of granular waste materials and sludges. Part 2: One stage batch test at a liquid to solid ratio of for materials with particle size below 4 mm (without or with size reduction).”, Brussels, Belgium.
European Committee for Standardization (CEN). (2005). “Characterization of waste—Leaching behaviour tests—Influence of pH on leaching with initial acid/base addition.” CEN/TS 14429, Brussels, Belgium.
European Committee for Standardization (CEN). (2006). “Characterization of waste—Leaching behaviour tests—Influence of pH on leaching with continuous pH-control.” CEN/TS 14997, Brussels, Belgium.
European Union. (2003). “Council decision 2003/33/EC establishing criteria and procedures for the acceptance of waste at landfills pursuant to article 16 of and Annex II to Directive 1999/31/EC.” Off. J. Eur. Communities, Brussels, Belgium.
Ghosh, A., Mukiibi, M., and Ela, W. (2004). “TCLP underestimates leaching of arsenic from solid residuals under landfill conditions.” Environ. Sci. Tech., 38(17), 4677–4682.
Ghosh, A., Sáez, E., and Ela, W. (2006). “Effect of pH, competitive anions and NOM on the leaching of arsenic from solid residuals.” Sci. Total Environ., 363(1–3), 46–59.
Jang, Y. C., and Townsend, T. G. (2003). “Leaching of lead from computer printed wire boards and cathode ray tubes by municipal solid waste landfill leachates.” Environ. Sci. Tech., 37(20), 4778–4784.
Karamalidis, A., and Voudrias, E. (2008). “Leaching behavior of metals released from cement-stabilized/solidified refinery oily sludge by means of sequential toxicity characteristic leaching procedure.” J. Environ. Eng., 134(6), 493–504.
Li, Y., Richardson, J. B., Walker, A. K., and Yuan, P. C. (2006). “TCLP heavy metal leaching of personal computer components.” J. Environ. Eng., 132(4), 497–504.
Lincoln, J. D., Ogunseitan, O. A., Shapiro, A. A., and Saphores, J. D. M. (2007). “Leaching assessments of hazardous materials in cellular telephones.” Environ. Sci. Tech., 41(7), 2572–2578.
Musson, S., Jang, Y., Townsend, T., and Chung, I. H. (2000). “Characterization of lead leachability from cathode ray tubes using the toxicity characteristic leaching procedure.” Environ. Sci. Tech., 34(20), 4376–4381.
Svensson, B. M., Mårtensson, L., Mathiasson, L., and Eskilsson, L. (2005). “Leachability testing of metallic wastes.” Waste Manage. Res., 23(5), 457–467.
U.S. Environmental Protection Agency, Test Methods for Evaluating Solid Waste, Phys./Chem. Methods. (1992). “Method 1311: Toxicity Characteristic Leaching Procedure, Revision 0.” 〈http://www.epa.gov/epawaste/hazard/testmethods/sw846/pdfs/1311.pdf〉 (Jan. 23, 2012).
U.S. Environmental Protection Agency, Test Methods for Evaluating Solid Waste, Phys./Chem. Methods. (1996). “Method 3050B: Acid digestion of sediments, sludges and soils, Revision 2” 〈http://www.epa.gov/epawaste/hazard/testmethods/sw846/pdfs/3050b.pdf〉 (Jan. 23, 2012).
Vann, K., Musson, S., and Townsend, T. (2006a). “Factors affecting TCLP lead leachability from computer CPUs.” Waste Manage., 26(3), 293–298.
Vann, K., Musson, S., and Townsend, T. (2006b). “Evaluation of a modified TCLP methodology for RCRA toxicity characterization of computer CPUs.” J. Hazard. Mater., 129(1–3), 101–109.
Yang, G. (1993). “Environmental threats of discarded picture tubes and printed circuit boards.” J. Hazard. Mater., 34(2)235–243.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 139 • Issue 11 • November 2013
Pages: 1375 - 1381
Copyright
© 2013 American Society of Civil Engineers.
History
Received: Jul 1, 2012
Accepted: Jul 9, 2013
Published online: Jul 11, 2013
Published in print: Nov 1, 2013
Discussion open until: Dec 11, 2013
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.