Biological Nutrient Removal in Municipal Wastewater Treatment: New Directions in Sustainability
Publication: Journal of Environmental Engineering
Volume 138, Issue 3
Abstract
To control eutrophication in receiving water bodies, biological nutrient removal (BNR) of nitrogen and phosphorus has been widely used in wastewater treatment practice, both for the upgrade of existing wastewater treatment facilities and the design of new facilities. However, implementation of BNR activated sludge AS systems presents challenges attributable to the technical complexity of balancing influent chemical oxygen demand (COD) for both biological phosphorus (P) and nitrogen (N) removal. Sludge age and aerated/unaerated mass fractions are identified as key parameters for process optimization. Other key features of selected BNR process configurations are discussed. Emerging concerns about process sustainability and the reduction of carbon footprint are introducing additional challenges in that influent COD, N, and P are increasingly being seen as resources that should be recovered, not simply removed. Energy recovery through sludge digestion is one way of recovering energy from influent wastewater but which presents a specific challenge for BNR: generation of sidestreams with high nutrient and low COD loads. Technologies designed specifically to treat these side-stream loads are overviewed in this paper. Finally, relatively high levels of nitrous oxide emissions, a powerful greenhouse gas, have been shown to occur in the BNR process under certain conditions, particularly in the presence of high nitrite concentrations. The advantages of using process modeling tools is discussed in view of optimizing BNR processes to meet effluent requirements and to meet goals of sustainability and reducing carbon footprints.
Get full access to this article
View all available purchase options and get full access to this article.
References
Adam, C., Gnirss, R., Lesjean, B., Buisson, H., and Kraume, M. (2002). “Enhanced biological phosphorus removal in membrane bioreactors.” Water Sci. Technol., 46(4–5), 281–286.
Appels, L., Baeyens, J., Degrève, J., and Dewil, R. (2008). “Principles and potential of the anaerobic digestion of waste-activated sludge.” Prog. Energy Combust. Sci., 34(6), 755–781.
Banister, S S, and Pretorius, W A (1998). “Optimisation of primary sludge acidogenic fermentation for biological nutrient removal.” Water SA, 24(1), 35–41.
Barker, P. S., and Dold, P. L. (1997). “General model for biological nutrient removal activated sludge systems: Model presentation.” Water Environ. Res., 69(5), 969–984.
Bortone, G., Saltarelli, R., Alonso, V., Sorm, R., Wanner, and Tilche, A. (1996). “Biological anoxic phosphorus removal—The DEPHANOX process.” Water Sci. Technol., 34(1/2), 119–128.
Daigger, G. T., and Crawford, G. V. (2005). “Incorporation of biological nutrient removal (BNR) into membrane bioreactors.” Proc., IWA Nutrient Management in Wastewater Treatment Processes and Recycle Streams, IWA, London.
De Kreuk, M. K., Picioreanu, C., Hosseini, M., Xavier, J. B., and Van Loosdrecht, M. C. M. (2007). “Kinetic model of a granular sludge SBR—Influences on nutrient removal.” Biotechnol. Bioeng. 97(4), 801–815.
Dold, P. L., Fairlamb, P. M., Jones, R., Takács, I., and Murthy, S. (2007). “Sidestream modelling incorporated into whole plant simulation.” CLONIC (Closing the nitrogen cycle from urban landfill leachate by biological nutrient removal over nitrate and thermal treatment) final seminar, European Commission, Brussels, Belgium.
Dold, P. L., Hu, Z., and Gan, Y. (2009). “Nutrient removal MBR systems: Factors in design and operation.” Proc., 5th IWA Specialized Membrane Conference and Exhibition, IWA, London.
Ekama, G. A., and Wentzel, M. C. (1999). “Difficulties and development in biological nutrient removal technology and modeling.” Water Sci. Technol., 39(6), 1–11.
Foley, J., de Haas, D., Yuan, Z., and Lant, P. (2010). “Nitrous oxide generation in full-scale biological nutrient removal wastewater treatment plants.” Water Res., 44(3), 831–844.
Henze, M, et al. (1999). “Activated sludge model no. 2d.” Water Sci. Technol., 39(1), 165–182.
Henze, M., van Loosdrecht, M. C. M., Ekama, G. A., and Brdjanovic, D (2008). Biological wastewater treatment: Principles, design and modelling, IWA, London.
Hiatt, W. C., and Grady, C. P. L., Jr. (2008). “An updated process model for carbon oxidation, nitrification, and denitrification.” Water Environ. Res., 80(11), 2145–2156.
Hu, Z., Sötemann, S. W., Moodley, R., Wentzel, M. C., and Ekama, G. A. (2003). “Experimental investigation on the external nitrification biological nutrient removal activated sludge system-the ENBNRAS system.” Biotechnol. Bioeng., 83(3), 260–273.
Hu, Z., Wentzel, M. C., and Ekama, G. A. (2000). “External nitrification in biological nutrient removal activated sludge systems.” Water SA, 26(2), 225–238.
Hu, Z., Wentzel, M. C., and Ekama, G. A. (2007). “A general model for biological nutrient removal activated sludge systems: Model development.” Biotechnol. Bioeng., 98(6), 1242–1258.
Houweling, D., Dold, P. L., and Barnard, J. (2010). “Theoretic limits to biological removal-rethinking the influent COD:N:P ratio.” Proc., 83rd Annual Water Environment Federation Technical Exhibition and Conf., Water Environment Federation, Alexandria, VA.
Houweling, D, Dold, P, Wunderlin, P, Joss, A., and Siegrist, H. (2011). “ Emissions: Impact of process configuration and diurnal loading patterns.” Proc., WEF/IWA Nutrient Recovery and Management 2011, Water Environment Federation, Alexandria, VA.
Jones, R. M. et al. (2007). “Simulation for operation and control of reject water treatment processes.” Proc., 80th Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Jones, R. M., and Takacs, I. (2004). “Modeling the impact of anaerobic digestion on the overall performance of biological nutrient removal wastewater treatment plants.” Proc., 77th Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Kang, S. J. Kevin, P. Olmstead, Krista, M. Takacs, and James, Collins (2009). “Energy sustainability and nutrient removal from municipal wastewater.” Proc., 82nd Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Latimer, R., Pitt, P. A., and van Niekerk, A. (2007). “Review of primary sludge fermentation performance in both and USA.” Proc., 80th Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Latimer, R. J., Pitt, P., Dold, P., Takács, I., and Lynch, T. J. (2008). “Kinetic parameters for modeling two-step nitrification and denitrification—Case study.” Proc., 1st IWA/WEF Wastewater Treatment Modelling Seminar, IWA, London.
Lesjean, B., Gnirss, R., Adam, C., Kraume, M., and Luck, F. (2003). “Enhanced biological phosphorus removal process implemented in membrane bioreactors to improve phosphorous recovery and recycling.” Water Sci. Technol., 48(1), 87–94.
Liu, W., Hu, Z., Walker, R. L., and Dold, P. L. (2009). “Enhanced nutrient removal MBR system with chemical addition for low effluent TP.” Proc., 5th IWA Specialised Membrane Conf. and Exhibition, IWA, London.
Mąkinia, J., Stensel, H. D., Czerwionka, K., Drewnowski, J., and Zapero, D. (2009). “Nitrogen transformations and mass balances in anaerobic/anoxic/aerobic batch experiments with full-scale biomasses from BNR activated sludge systems.” Proc., IWA Nutrient Removal Conf., IWA, London.
Monti, A., Hall, E. R., and van Loosdrecht, M. C. (2007). “Kinetics of phosphorus release and uptake in a membrane-assisted biological phosphorus removal process.” J. Environ. Eng., 133(9), 899–908.
Moodley, R, Wentzel, M. C., and Ekama, G. A. (1999). “External nitrification in biological nutrient removal activated sludge systems.” Research Report W100, Dept. of Civil Eng., Univ. of Cape Town, Rondebosch, 7701, South Africa.
Moser-Engler, R., Udert, D., Wild, D., and Siegrist, H. (1998). “Products from primary sludge fermentation and their suitability for nutrient removal.” Water Sci. Technol, 38(1), 265–273.
Muller, A., et al. (2004). “Full-scale implementation of external nitrifcation biological nutrient removal at the Daspoort Water Care Works, Tshwane Municipality.” Water SA, 30(5), 585–591.
Muller, A., et al. (2006). “Two-years operating experience of full-scale external nitrification BNR activated sludge.” Proc., 9th Bienn. WISA Conf. and Exhibition, 21–25 May, Durban, South Africa.
Narayanan, B. et al. (2002). “Fermentation of return activated sludge to enhance biological P removal.” Proc., 72nd Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Phagoo, D., Fry, D., Machisko, J., and Penny, J. (2005). “Enhanced BNR with MBR—a unique combination.” Proc., 78th Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Ramphao, M., Wentzel, M. C., Merritt, R., Ekama, G. A., Young, T., and Buckley, C. A. (2005). “Impact of membrane solid-liquid separation on design of biological nutrient removal activated sludge systems.” Biotechnol. Bioeng., 89(6), 630–646.
Randall, C. W., and Sen, D. (1996). “Full-scale evaluation of an integrated fixed film activated sludge (IFAS) process for enhanced nitrogen removal.” Water Sci. Technol., 33(12), 155–162.
Rossle, W. H., and Pretorius, W. A. (2001). “A review of characterization requirements for in-line prefermenters, Paper 2: Process characterization.” Water SA 27(3), 413–422.
Sen, D., Mitta, P., and Randall, C. W. (1994). “Performance of fixed film media integrated in activated sludge reactors to enhanced nitrogen removal.” Wat. Sci. Technol., 30(11), 13–24.
Sen, D., Randall, C. W., and Liu, H. (1995). “Effect of suspended solids MCRT on COD and nitrogen removal kinetics of biofilm support media integrated in activated sludge systems.” Proc., 68th annual WEFTEC, Water Environment Federation, Alexandria, VA.
Shiskowski, D. M., and Mavinic, D. S. (2006). “The influence of nitrite and pH (nitrous acid) on aerobic-phase, autotrophic generation in a wastewater treatment bioreactor.” Environ. Sci. Technol., 5, 273–283.
Sin, G., et al. (2008). “Nitrite effect on the phosphorus uptake activity of phosphate accumulating organisms (PAOs) in pilot-scale SBR and MBR reactors.” Water SA, 34(2), 249–260.
Sorm, R., Bortone, G., Saltarelli, R., Jenicek, P., Wanner, J., and Tilche, A. (1996). “Phosphate uptake under anoxic conditions and fixed film nitrification in nutrient removal activated sludge system.” Water Res., 30(7), 1573–1584.
Sötemann, S., Vermande, S. M., Wentzel, M. C., and Ekama, G. A. (2003). “Comparison of the performance of an external nitrification biological nutrient removal activated sludge system with a UCT biological nutrient removal activated sludge system.” Water SA Special Ed.: WISA Proc. 2002, 105–113.
Steichen, M., Kadava, A., Shaw, A., Scanlan, P., Martin, M., and Kazemi, S. (2010). “A new paradigm: Carbon footprint and sustainability assessment for process selection.” Proc., 83rd Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Tong, J., and Chen, Y. (2007). “Enhanced biological phosphorus removal driven by short-chain fatty acids produced from waste activated sludge alkaline fermentation.” Environ. Sci. Technol., 41(20), 7126–7130.
Tremblay, S., Hilger, H., Barnard, J., deBarbadillo, C., and Goins, P. (2005). “Phosphorus accumulating organisms utilization of volatile fatty acids produced by fermentation of anaerobic mixed liquor.” Proc., 78th Annual WEFTEC, Water Environment Federation, Alexandria, VA.
Vanrolleghem, P. A. et al. (2005). “Continuity-based interfacing of models for waste-water systems described by Petersen matrices.” Water Sci. Technol., 52(1–2), 493–500.
Volcke, E. I. P., van Loosdrecht, M. C. M., and Vanrolleghem, P. A. (2006). “Continuity-based interfacing for plant-wide simulation: A general approach.” Water Res., 40(15), 2817–2828.
Wanner, J., Kucman, K., and Graup, P. (1988). “Activated sludge process with biofilm cultivation.” Water Res., 22(2), 207–215.
Wentzel, M. C., Dold, P. L., Ekama, G. A., and Marais, G.V.R. (1990). “Biological excess phosphorus removal-Steady state process design.” Water SA, 16(1), 29–48.
Wentzel, M. C., Ekama, G. A., and Marais, G. V. R. (1992). “Process and modelling of nitrification denitrification biological excess phosphorus removal systems-a review.” Water Sci. Technol., 25(6), 59–82.
WERF. (2010). “Greenhouse nitrogen emission from wastewater treatment operations.” Report U4R07a, Water Environment Research Foundation, Alexandria, VA.
Wilson, A. W., and Dold, P. L. (1998). “Using a process simulator for design, analysis, de-bottlenecking and operation of wastewater treatment plants.” Presented at the 50th Annual Conf. of the Western Canada Water and Wastewater Assoc., Calgary, Alberta, Canada.
Yuan, H., Chen, Y., Zhang, H., Jiang, S., Zhou, Q., and Gu, G. (2006). “Improved bioproduction of short-chain fatty acids (SCFAs) from excess sludge under alkaline conditions.” Environ. Sci. Technol., 40(6), 2025–2029.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 138 • Issue 3 • March 2012
Pages: 307 - 317
Copyright
© 2012 American Society of Civil Engineers.
History
Received: Oct 29, 2010
Accepted: Jul 14, 2011
Published online: Jul 16, 2011
Published in print: Mar 1, 2012
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.