Performance Assessment of a New Type of Membrane Bioreactor under Steady State and Transient Operating Conditions
Publication: Journal of Environmental Engineering
Volume 137, Issue 9
Abstract
Methyl--butyl ether (MTBE) is an additive to gasoline that serves as an oxygenate to increase the octane rating and improve combustion efficiency. Assessment of MTBE biodegradation under aerobic conditions was performed in lab-scale biomass concentrator reactors (BCRs). These reactors were bench-scale microcosms that retain and concentrate biomass thereby enabling biodegradation to sub- level. The BCRs were run under low hydraulic retention times with a synthetically prepared feed containing of several oxygenates, MTBE, diisopropyl ether (DIPE), ethyl--butyl ether (ETBE), -amyl methyl ether (TAME), -amyl alcohol (TAA), and the primary gasoline constituents benzene, toluene, ethyl benzene, and -xylene (BTEX). The BCRs were effective in the removal of the aforementioned contaminants to concentrations lower than the targeted , which is below the U.S. Environmental Protection Agency (EPA) taste and odor threshold of . Reactor performance was also evaluated under shock loading and intermittent feeding (starvation tests) of the contaminants of concern to evaluate the reactor’s robustness in recovering from such stresses. The BCRs were found to be highly resilient to fluctuations in substrate and flow conditions.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
We thank Nita Naik, Jaiho Cho, Salam Musaad, and Larry Heitkamp for their contributions to this research.
References
Albertson, N. H., Nystrom, T., and Kjelleberg, S. (1990). “Macromolecular synthesis during recovery of the marine Vibrio sp S14 from starvation.” J. Gen. Microbiol., 136(11), 2201–2207.
American Public Health Association (APHA). (1998). Standard methods for the examination of water and wastewater, 20th Ed., L. S. Clesceri, A. E. Greenberg, and A. D. Eaton, eds., Washington, DC.
Andrews, C. (1998). “MTBE—A long-term threat to ground water quality.” Ground Water, 36(5), 705–706.
Belpoggi, F., Soffritti, M., and Maltoni, C. (1995). “Methyl-tertiary-butyl ether (MTBE)—A gasoline additive—Causes testicular and lymphohaematopoietic cancers in rats.” Toxicol. Ind. Health, 11(2), 119–149.
Carter, J. M., Grady, S. J., Delzer, G. C., Koch, B., and Zogorski, J. S. (2006). “Occurrence of MTBE and other gasoline oxygenates in CWS source waters.” J. Am. Water Works Assoc., 98(4), 91–104.
Fan, A. M., and Alexeeff, G. V. (1999). “Public health goal for methyl tertiary butyl ether (MTBE) in drinking water.” 〈http://www.oehha.ca.gov/water/phg/pdf/mtbe_f.pdf〉 (Feb. 2010).
Fang, F., Zhu, R., Zhang, L., and Chen, J. (2008). “Biodegradation of MTBE with ethanol co-substrate using an SBR and microbial community structure.” Huanjing Kexue Xuebao, 28(11), 2206–2212.
Hunkeler, D., Butler, B. J., Aravena, R., and Barker, J. F. (2001). “Monitoring biodegradation of methyl tert-butyl ether (MTBE) using compound-specific carbon isotope analysis.” Environ. Sci. Technol., 35(4), 676–681.
Johnson, D. R., Park, J., Kukor, J. J., and Abriola, L. M. (2006). “Effect of carbon starvation on toluene degradation activity by toluene monooxygenase-expressing bacteria.” Biodegradation, 17(5), 437–445.
Johnson, M. L. (1998). “Exposure of humans to MTBE from drinking water.” Report to the Governor and Legislature of the State of California as Sponsored by SB 251, Vol V, Univ. of California at Davis, Davis, CA.
Kharoune, M., Pauss, A., and Lebeault, J. M. (2001). “Aerobic biodegradation of an oxygenates mixture: ETBE, MTBE and TAME in an upflow fixed-bed reactor.” Water Res., 35(7), 1665–1674.
Konopka, A. (1999). “Theoretical analysis of the starvation response under substrate pulses.” Microb. Ecol., 38(4), 321–329.
Konopka, A., Zakharova, T., and Nakatsu, C. (2002). “Effect of starvation length upon microbial activity in a biomass recycle reactor.” J. Ind. Microbiol. Biotechnol., 29(5), 286–291.
Konopka, A., Zakharova, T., Oliver, L., Paseuth, E., and Turco, R. F. (1998). “Physiological state of a microbial community in a biomass recycle reactor.” J. Ind. Microbiol. Biotechnol., 20(3-4), 232–237.
Kwak, K., Jung, S., Chung, S., Kang, C., Huh, Y., and Bae, S. (2006). “Optimization of culture conditions for CO2 fixation by a chemoautotrophic microorganism, strain YN-1 using factorial design.” Biochem. Eng. J., 31(1), 1–7.
Lee, E., and Cho, K. (2009). “Effect of substrate interaction on the degradation of methyl tert-butyl ether, benzene, toluene, ethylbenzene, and xylene by Rhodococcus sp.” J. Hazard. Mater., 167, (1-3), 669–674.
Lin, C., Cheng, Y., and Tsai, S. (2007). “Multi-substrate biodegradation kinetics of MTBE and BTEX mixtures by Pseudomonas aeruginosa.” Process Biochem., 42(8), 1211–1217.
Morrison, J. R., Suidan, M. T., and Venosa, A. D. (2002). “Use of membrane bioreactor for biodegradation of MTBE in contaminated water.” J. Environ. Eng., 128(9), 836–841.
Pruden, A., Sedran, M., Suidan, M. T., and Venosa, A. D. (2003). “Biodegradation of MTBE and BTEX in an aerobic fluidized bed reactor.” Water Sci. Technol., 47(9), 123–128.
Pruden, A., Suidan, M. T., Morrison, J. R., and Venosa, A. D. (2002). “Denaturing gradient gel electrophoresis analysis of a methyl tert-butyl ether degrading culture applied in a membrane bioreactor.” Water Sci. Technol.: Water Supply, 2(2), 207–212.
Pruden, A., Suidan, M. T., Venosa, A. D., and Wilson, G. J. (2001). “Biodegradation of methyl tert-butyl ether under various substrate conditions.” Environ. Sci. Technol., 35(21), 4235–4241.
Purswani, J., Pozo, C., Rodriguez-Diaz, M., and Gonzalez-Lopez, J. (2008). “Selection and identification of bacterial strains with methyl-tert-butyl ether, ethyl-tert-butyl ether, and tert-amyl methyl ether degrading capacities.” Environ. Toxicol. Chem., 27(11), 2296–2303.
Salanitro, J. P., Diaz, L. A., Williams, M. P., and Wisniewski, H. L. (1994). “Isolation of a bacterial culture that degrades methyl -butyl ether.” Appl. Environ. Microbiol., 60(7), 2593–2596.
Saponaro, S., Negri, M., Sezenna, E., Bonomo, L., and Sorlini, C. (2009). “Groundwater remediation by an in situ biobarrier: A bench scale feasibility test for methyl tert-butyl ether and other gasoline compounds.” J. Hazard. Mater., 167(1-3), 545–552.
Schirmer, M., Butler, B. J., Church, C. D., Barker, J. F., and Nadarajah, N. (2003). “Laboratory evidence of MTBE biodegradation in Borden aquifer material.” J. Contam. Hydrol., 60(3-4), 229–249.
Sedran, M. A., Pruden, A., Wilson, G. J., Suidan, M. T., and Venosa, A. D. (2002). “Effect of BTEX on degradation of MTBE and TBA by mixed bacterial consortium.” J. Environ. Eng., 128(9), 830–835.
Shih, T., Rong, Y., Harman, T., and Suffet, M. (2004). “Evaluation of the impact of fuel hydrocarbons and oxygenates on groundwater resources.” Environ. Sci. Technol., 38(1), 42–48.
Squillace, P. J., Zogorski, J. S., Wilber, W. G., and Price, C. V. (1996). “Preliminary assessment of the occurrence and possible sources of MTBE in groundwater in the United States, 1993–1994.” Environ. Sci. Technol., 30(5), 1721–1730.
U.S. EPA. (2008). “UST program facts.” 〈http://www.epa.gov/oust/pubs/ustfacts.pdf〉 (Feb. 2010).
Van Wezel, A., Puijker, L., Vink, C., Versteegh, A., and de Voogt, P. (2009). “Odour and flavour thresholds of gasoline additives (MTBE, ETBE and TAME) and their occurrence in dutch drinking water collection areas.” Chemosphere, 76(5), 672–676.
Yogalakshmi, K. N., Kurian, J., and Visvanathan, C. (2007). “Response of membrane bioreactor to feed starvation shock load.” Asian J. Water, Environ. Pollut., 4(2), 81–86.
Zein, M. M., Suidan, M. T., and Venosa, A. D. (2004). “MtBE biodegradation in a gravity flow, high-biomass retaining bioreactor.” Environ. Sci. Technol., 38(12), 3449–3456.
Zein, M. M., Suidan, M. T., and Venosa, A. D. (2006). “Bioremediation of groundwater contaminated with gasoline hydrocarbons and oxygenates using a membrane-based reactor.” Environ. Sci. Technol., 40(6), 1997–2003.
Zhang, L. L., Zhu, R. Y., Chen, J. M., and Cai, W. M. (2008). “Biodegradation of methyl tert-butyl ether as a sole carbon source by aerobic granules cultivated in a sequencing batch reactor.” Bioprocess Biosyst. Eng., 31(6), 527–534.
Zogorski, J. S. et al. (1996). “Fuel oxygenates and water quality: current understanding of sources, occurrence in natural waters, environmental behavior, fate, and significance.” Report, Interagency Oxygenated Fuel Assessment, U.S. Geological Survey, Rapid City, SD.
Information & Authors
Information
Published In
Copyright
© 2011 American Society of Civil Engineers.
History
Received: Apr 23, 2010
Accepted: Mar 8, 2011
Published online: Mar 10, 2011
Published in print: Sep 1, 2011
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.